Dien 938h

RENR9764-04 August 2011

Harness And Wire Electrical Schematic Symbols CONN 3

CONN 2

Symbols

CONN 1

70

T

50

53

Pressure Symbol

Temperature Symbol

39

Circuit Breaker Symbol

Flow Symbol

Symbols and Definitions Fuse - A component in an electrical circuit that will open the circuit if too much current flows through it.

9

41

Level Symbol

Switch (Normally Open): A switch that will close at a specified point (temp, press, etc.). The circle indicates that the component has screw terminals and a wire can be disconnected from it.

40

Switch (Normally Closed): A switch that will open at a specified point (temp, press, etc.). No circle indicates that the wire cannot be disconnected from the component.

7

31

Ground (Wired): This indicates that the component is connected to a grounded wire. The grounded wire is fastened to the machine. Ground (Case): This indicates that the component does not have a wire connected to ground. It is grounded by being fastened to the machine.

26

2

Reed Switch: A switch whose contacts are controlled by a magnet. A magnet closes the contacts of a normally open reed switch; it opens the contacts of a normally closed reed switch.

35

52

Volume 1 - Off Machine Switch Specification

T

Part No.

Function

114-5333

A/C (High/Low) Pressure

313-5104

Primary & Secondary Steering Pressure

314-2405

Low Brake Oil Pressure

Actuate 275 to 1750 kPa¹ (39.9 to 253.8 psi) 1,200 kPa MAX (174 psi MAX) 10,700 kPa MAX (1552 psi MAX)

Deactuate -

Contact Position

700 ± 100 kPa (102 ± 14.5 psi) 8,960 ± 537 kPa (1300 ± 78 psi)

A-B Normally Open A-C Normally Closed A-B Normally Open A-C Normally Closed

Normally Open²

Relay (Magnetic Switch): A relay is an electrical component that is activated by electricity. It has a coil that makes an electromagnet when current flows through it. The electromagnet can open or close the switch part of the relay.

66 CONN 9

¹ With increasing pressure the closed condition can be maintained up to 2800 kpa (405 psi), with decreasing pressure the closed condition can be maintained down to 170 kpa (25psi).

938H: MCC1-UP MJC1-UP JKM1-UP LKM1-UP

Solenoid: A solenoid is an electrical component that is activated by electricity. It has a coil that makes an electromagnet when current flows through it. The electromagnet can open or close a valve or move a piece of metal that can do work.

CONN 8

33

938H & IT38H Wheel Loader Electrical System

Sender: A component that is used with a temperature or pressure gauge. The sender measures the temperature or pressure. Its resistance changes to give an indication to the gauge of the temperature or pressure.

MAGNETIC LATCH SOLENOID - A magnetic latch solenoid is an electrical component that is activated by electricity and held latched by a permanent magnet. It has two coils (latch and unlatch) that make electromagnet when current flows through them. It also has an internal switch that places the latch coil circuit open at the time the coil latches.

² Contact position at the contacts of the harness connector.

IT38H: JNJ1-UP

Harness and Wire Symbols 1 2

36

1 2

Deutsch connector: Typical representation of a Deutsch connector. The plug contains all sockets and the receptacle contains all pins.

Harness Identification Letter(s): (A, B, C, ..., AA, AB, AC, ...)

Wire, Cable, or Harness Assembly Identification: Includes Harness Identification Letters and Harness Connector Serialization Codes

Harness Connector Serialization Code: The "C" stands for "Connector" and the number indicates which connector in the harness. (C1, C2, C3, .....)

Part Number for Connector Plug

C-C4 AG-C3 130-6795 130-6795

10

13

80

77

1

74

5A

Receptacle Pin or Socket Number

Single Wire Connector

CONN 4

Part Number For Connector Recepticle

Socket

Pin

44

L-C12 3E-5179

AG-C4 111-7898

325-AG135 PK-14

21

Sure-Seal connector: Typical representation of a Sure-Seal connector. The plug and receptacle contain both pins and sockets.

9X-1123

Component Part Number

Plug

200-L32 BK-14

2

Harness identification code: This example indicates wire 135 in harness "AG".

Fuse (5 Amps)

Ground Connection

Circuit Identification Number

Wire Gauge

Wire Color

Volume 1 of 2: Engine & Chassis Wiring © 2011 Caterpillar, All Rights Reserved

Printed in U.S.A.

(CH) HARNESS - ENGINE APPLICATION HARNESS & (PE) HARNESS - BASIC ENGINE HARNESS

Component Identifiers (CID¹) Module Identifier (MID²) Engine Control System (MID No. 036)

34 91

Schematic Location

CONN 1

D-17

CONN 2

D-17

CONN 3

D-17

CONN 4

F-15

CONN 5

G-15

CONN 6

K-16

CONN 7

L-16

CONN 8

72

15

73 CONN 24

E-13

CONN 9

E-13

CONN 10

C-9

CONN 11

J-8

CONN 12

E-6

CONN 13

G-6

CONN 14

I-6

CONN 15

G-4, K-4

CONN 16

CONN 26

43

H-2

CONN 17

H-2

CONN 18

H-2

CONN 19

I-2

CONN 20

J-2

CONN 21

J-2

CONN 22

K-2

CONN 23

CONN 22

D-4, K-2

CONN 24

L-2

CONN 25

D-2

CONN 26

L-2

CONN 27

L-2

42

The connectors shown in this chart are for harness to harness connectors. Connectors that join a harness to a component are generally located at or near the component. See the Component Location Chart.

Schematic Location

Machine Location

0004

Cylinder #4 Injector

Alarm - Backup

I-17

1

Sensor - Torque Converter Oil Temperature

H-7

49

0005

Cylinder #5 Injector

Alternator

J-15

2

Sensor - Wastegate

D-18

50

0006

Cylinder #6 Injector

51

0041

8 Volt DC Supply

Battery

J-12

3

Sensor - XMSN Pump Pressure

H-7

Breaker - Buss (Cab)

H-13

4

Solenoid - A/C Clutch

H-16

52

0091

Throttle Position Sensor

Breaker - Glow Plugs

G-13

5

Solenoid - Axle Oil Cooler Clutch

G-16

53

0100

Engine Oil Pressure Sensor

Breaker - Main

H-13

6

Solenoid - Clutch # 3 (Reverse)

I-7

54

0110

Engine Coolant Temperature Sensor

0168

Battery Voltage

Control - Engine

E-16

7

Solenoid - Clutch #1 (Forward Low)

J-7

55

Control - Hood Raise/Lower Motor

I-11

8

Solenoid - Clutch #2 (Forward High)

J-7

56

0171

Ambient Air Temperature Sensor

Glowplugs 1-6

G-16

9

Solenoid - Clutch #4 (Speed #2)

I-7

57

0172

Intake Air Temp Sensor

Ground - Engine Block

I-16

10

Solenoid - Clutch #5 (Speed #3)

I-7

58

67

J-11

11

Solenoid - Clutch #6 (Speed #1)

I-7

59

12

Solenoid - Differential Lock (Front)

B-10

60

0261

Engine Timing Calibration

Ground - LH Frame Starter

I-15

13

Solenoid - Differential Lock (Rear)

B-10

61

0262

5V DC Sensor Supply

Ground - Secondary Steering

J-11

14

Solenoid - Differential Lock Actuation

C-10

62

Horn - Forward (938H)

L-2

15

Solenoid - Fan Brake Load Bypass

I-9

63

Horn - Forward (IT38H)

G-1

16

Solenoid - Fan Pump

F-16

64

Motor - Autolube Pump

L-1

17

Solenoid - Fan Valve

F-16

65

Motor - Fuel Priming Pump

G-15

18

Solenoid - Fuel Pump

D-18

Motor - Hood Actuator

I-17

19

Solenoid - Implement Pilot Shutoff (938H)

I-2

55 54

0267

Remote Shutdown Input

0268

Programed Parameter Fault

0291

Engine Cooling Fan Solenoid

0296

Transmission Control

66

0342

Sec Engine Speed Sensor

67

0526

Turbo Wastegate Actuator

1438

Engine Cooling Fan Solenoid #2

Motor - Secondary Steering

J-10

20

Solenoid - Implement Pilot Shutoff (IT38G)

F-1

68

Motor - Starter

J-15

21

Solenoid - Implement Power Management

A-9

69

Motor - Washer Pump (Front)

K-9

22

Solenoid - Injector 1-6

D-17

70

Motor - Washer Pump (Rear)

K-9

23

Solenoid - Quick Coupler

I-1

71

57 CONN 14

59

1639

Mach Sec System ECM

1779

Fuel Rail Pressure Valve Solenoid

1785

Intake Manifold Pressure Sensor

1797

Fuel Rail Pressure Sensor

Relay - Glowplug

G-13

24

Solenoid - Ride Control #1

H-2

72

Relay - Main

H-13

25

Solenoid - Ride Control #2

H-2

73

1834

Ignition Key Swtich

Resistor - CAN Datalink (Engine)

E-14

26

Solenoid - Start Aid

F-15

74

1849

Engine Fan Reverse Relay

Sender - Fuel Level

K-16

27

Solenoid - Variable Speed Fan

B-10

75

2246

Glow Plug Start Aid Relay

Sender - Hydraulic Oil Temperature

E-7

28

Solenoid - XMSN Pump Flow Bypass

I-9

76

Sender - Rear Axle Oil Temperature

J-15

29

Suppressor - HVAC Arc

H-16

77

Sender - XMSN Oil Temperature

J-7

30

Suppressor - Quick Coupler Arc

H-1

78

Sensor - Ambient Air Temperature

F-15

31

Suppressor - Secondary Steering Arc

J-10

79

Sensor - Articulation Angle

H-9

32

Switch - A/C Pressure

H-16

80

Sensor - Cam Speed

E-18

33

Switch - Bucket Position (IT38H)

F-1

81

J-7

34

Switch - Bucket/Tilt Position (938H)

K-2

82

E-18

35

Switch - Case Drain Filter

B-10

E-18

36

Switch - Disconnect

J-12

I-1

37

Switch - Fork Position (IT38H)

G-1

85

Sensor - Front Wheel Speed (RH)

I-1

38

Switch - Front Axle Oil Monitoring

J-2

86

D-18

39

Switch - Fuel Priming Pump

G-15

87

Sensor - Intake Manifold Pressure

E-18

40

Switch - Ground Level Shutdown

I-11

88

E-18

41

Switch - Hood Actuator

I-11

89

Sensor - Lift Cylinder Head End Pressure

K-2

42

Switch - Hydraulic Filter Bypass

C-10

90

Sensor - Lift Position

K-2

43

Switch - Lift Position (938H)

L-2

91

44

Switch - Lift Position (IT38H)

H-1

I-7

45

Switch - Low Brake Oil Pressure

Sensor - Output Speed (Trailing)

I-7

46

Switch - Steering Pressure (Primary)

K-9

94

Sensor - Rear Wheel Speed (LH)

L-17

47

Switch - Steering Pressure (Secondary)

K-9

95

L-17

48

Switch - XMSN Filter Bypass

C-10

45

¹ The CID is a diagnostic code that indicates which circuit is faulty. ² The MID is a diagnostic code that indicates which electronic control module diagnosed the fault.

Failure Mode Identifiers (FMI)¹

46

92

Sensor - Output Speed (Leading)

Sensor - Rear Wheel Speed (RH)

C-10

58

84

Sensor - Intake Manifold Temperature

D-18

51

83

Sensor - Front Wheel Speed (LH)

Sensor - Oil Pressure

CONN 18

Engine Speed Sensor Personality Module

K-12

Sensor - Fuel Rail Pressure

CONN 15

0190 0253

Ground - Frame

Sensor - Crank Speed

17

56

Ground - LH Frame

Sensor - Coolant Temperature

CONN 27

Cylinder #2 Injector Cylinder #3 Injector

Component

Sensor - Converter Output Speed

CONN 16

0002 0003

Machine Location

Component

Connector Location (Volume 1)

Cylinder #1 Injector

Schematic Location

CONN 20

82

Component

0001

Component Location (Volume 1)

CONN 23

Connector Number

CID

49

CONN 17

93

96

CONN 21 CONN 19 TRANSMISSION AR

FMI No.

Failure Description

0

Data valid but above normal operational range.

1

Data valid but below normal operational range.

2

Data erratic, intermittent, or incorrect.

3

Voltage above normal or shorted high.

4

Voltage below normal or shorted low.

5

Current below normal or open circuit.

6

Current above normal or grounded circuit.

7

Mechanical system not responding properly.

8

Abnormal frequency, pulse width, or period.

9

Abnormal update.

10

Abnormal rate of change.

11

Failure mode not identifiable.

12

Bad device or component.

13

Out of calibration.

14

Parameter failures.

15

Parameter failures.

16

Parameter not available.

17

Module not responding.

18

Sensor supply fault.

19

Condition not met.

20

Parameter failures.

¹The FMI is a diagnostic code that indicates what type of failure has occurred.

(AG) HARNESS - 938H FRONT FRAME HARNESS

(AT) HARNESS - TRANSMISSION HARNESS LH TAIL LAMPS

1 27

64

Event Code

CONN 6

81

65

92

85

Event Codes Engine Control

NOT SHOWN

CONN 7

NOT SHOWN

0194

28

RH TAIL LAMPS

CONN 12

CONN 9

29

CONN 23

47

11

CONN 8

CONN 13

12

79

78

24 89

CONN 11

5

30

3

B

48 6

CONN 15

High Engine Coolant Temperature Engine Overspeed

0396

High Fuel Rail Pressure

0398

Low Fuel Rail Pressure

0441

Idle Elevated to Increase Batt Voltage

0539

High Intake Manifold Air Temperature

1044

High Intake Manifold Pressure

1045

Low Intake Manffold Pressure

0049

Coasting in Neutral Warning

0284

Low Brake Accumulator Pressure

0329

Transmission Filter Plugged

0454

Hydraulic Case Drain Filter Plugged

0490

Park Brake On - Not In Neutral

0627

Parking Brake On - Machine In Motion

0861

Clock Manual Alignment Required

0878

High Hydraulic Oil Temp

0879

Hydraulic Tank Oil Filter Plugged

2129

High Front Axle Temp

2130

High Rear Axle Temp

0643

86

68

0361 0362

Event Codes Payload Control

19

4

User Defined Shutdown Low Engine Oil Pressure

Event Codes Machine Control

22

71

0265 0360

23

A

16

Condition High Exhaust Temperature

Lift Pressure Change During Weigh

0783

Machine Pitched or Bucket Tilted

0784

Weight too heavy to zero

1027

Lift Too Slow To Weigh

1028

Lift Stopped During Weigh

1042

Excessive Lift Speed Change

1043

Lift Too Jerky During Weigh

2083

Payload Memory Low

2138

Payload Memory Full

Event Codes Product Link Control

14 0861

20

69

Zero Timer Expired

0782

Manual Clock Alignment Required

94 25

37

8

38

32

83 76

90

VIEW OF AREA (A) (AC) HARNESS - IT38H FRONT FRAME HARNESS

88

Related Electrical Service Manuals

NOT SHOWN

Title Alternator:

63

75 84

95

NOT SHOWN

93 96

62

61

60

CONN 10

(CJ) HARNESS - MAIN CHASSIS HARNESS, (CV) HARNESS - SECONDARY STEERING HARNESS & (HC) HARNESS - HYDRAULIC SERVICE CENTER HARNESS

VIEW OF AREA (B)

Form Number 235-7132 (65A) Std 235-7133 (80A) Atch

SENR4130

Engine Control System:

KENR5392

Machine Control System:

RENR8999

Machine Monitoring System:

RENR6319

Payload Control System:

SENR6614

36 Page,

18

RENR9764-04 VOL 1 of 2

87

(Dimensions: 48 inches x 35 inches)

CONN 5

18

17

16

15

14

13

12

11

10

9

8

7

6

5

4

3

2 AG-C22 1552272 136-AG10 GN-16 200-AG17 BK-16 439-AG18 YL-18

+8V RETURN SIG A SIG B

L

RD-18 BK-18 GN-18 WH-18

1 2 3 4

CR-C2 1552272 709-CR2 OR-18 J764-CR5 BR-18 G997-CR9 PU-18 G998-CR10 WH-18

1 2 3 4

CR-C3 1552272 709-CR3 OR-18 J764-CR6 BR-18 G995-CR7 OR-18 G996-CR8 PK-18

RH REAR WHEEL SPEED SNSR 264-0148

(Dimensions: 48 inches x 35 inches)

+8V RETURN SIG A SIG B

36 Page,

RENR9764-04 VOL 1 of 2

LH REAR WHEEL SPEED SNSR 264-0148

RD-18 BK-18 GN-18 WH-18

CR-C1 1552273 709-CR1 OR-18 J764-CR4 BR-18 G995-CR7 OR-18 G996-CR8 PK-18 G997-CR9 PU-18 G998-CR10 WH-18

G995-CR7 OR-18 G996-CR8 PK-18 G997-CR9 PU-18 G998-CR10 WH-18

1 2 3 4 5 6

CJ-C18 1552273

CJ-C15 3E3382 709-CJ61 OR-18 J764-CJ46 BR-18 G995-CJ72 OR-18 G996-CJ73 PK-18 G997-CJ74 PU-18 G998-CJ75 WH-18

1 2 3 4 5 6

321-CJ7 BR-18 447-CJ48 PK-18 604-CJ15 OR-16 605-CJ16 YL-16 606-CJ17 GY-16 614-CJ12 PU-16 617-CJ19 BR-16 618-CJ45 YL-16 709-CJ61 OR-18 G995-CJ72 OR-18 G996-CJ73 PK-18 G997-CJ74 PU-18 G998-CJ75 WH-18 J764-CJ38 BR-18

CONN 7

J764-CR4 BR-18 J764-CR5 BR-18 J764-CR6 BR-18

200-CJ39 BK-16 200-CJ40 BK-16 200-CJ148 BK-16 200-CJ41 BK-16 200-CJ42 BK-16 200-CJ43 BK-16 200-CJ149 BK-16

AUTO DIFF LOCK (REAR)

J764-CJ47 J764-CJ63 J814-CJ22 J854-CJ10

321-CJ7 BR-18 397-CJ54 OR-14 398-CJ55 BU-14 447-CJ48 PK-18

YL-18 WH-18

1 2

CJ-C9 1552269 605-CJ16 YL-16 200-CJ42 BK-16

A B C

CJ-C19 1552267 604-CJ49 OR-16 200-CJ43 BK-16 617-CJ19 BR-16

BULB 9X-4493 RD-18 BK-18 BU-18

S T

K

STOP/TAIL

FUEL LEVEL SENDER 363-8627 PK-18 BK-18

1 2

J764-CJ47 J764-CJ63 J764-CJ38 J764-CJ44 J764-CJ46

LICENSE PLATE LAMP 2 125-4439

614-CU4 PU-16 200-CU3 BK-16

1 2

CJ-C4 1552269 614-CJ12 PU-16 200-CJ41 BK-16

BR-18 BR-18 BK-18 YL-18

200-CJ147 BK-14 200-CJ146 BK-14 200-CJ149 BK-16 200-CJ148 BK-16

LH FRAME GND

BR-18 BR-18 BR-18 BR-18 BR-18

H21

397-CJ54 OR-14 398-CJ55 BU-14

CV-C4 1552267 C216-CV15 BK-18 417-CV14 GY-18 484-CV13 YL-18

A B C

CV-C5 1552267 C216-CV12 BK-18 453-CV8 PK-18 416-CV11 OR-18

A B C

TURN

J

1 2

YL-18 WH-18

BULB 9X-4493 S T

RD-18 BK-18 BU-18

A B C

STOP/TAIL

1 2

604-CJ49 OR-16 604-CJ50 OR-16 605-CJ16 YL-16 606-CJ17 GY-16 614-CJ12 PU-16 617-CJ19 BR-16 618-CJ45 YL-16 J814-CJ22 BK-18

CJ-C23 1552269 606-CJ17 GY-16 200-CJ40 BK-16

1 2

CA-C1 CA-C2 2304011 1552269 J854-CA3 YL-18 J764-CA4 BR-18

CJ-C22 3E3364 1 2

CBL-EE1 RD-00

CBL-WW1 RD-00 J854-CJ10 YL-18 J764-CJ38 BR-18

POS

T

NEG

RR AXLE OIL TEMP SNDR 256-6453

CBL-HH1 BK-00

CBL-GG1 BK-00 POS

12V BATTERY 1 263-9574

CJ-C8 1552267 604-CJ50 OR-16 200-CJ39 BK-16 618-CJ45 YL-16

727-CV10 GN-16 727-CV1 GN-16

SEC STRG ARC SUPPR 218-4935

DISCONNECT SW 7N-0718

NEG

CBL-WW1 RD-00

BULB 9X-4492

BK-16

G

109-CH66 RD-4

B+

1

R B-

1

MOT BTRY

1

STARTER 288-7980

ALTERNATOR 235-7132 (65A STD) 235-7133 (80A ATCH)

CONNECT TO C-C36 SH2 LOC I-3

CONN 15

CV-C2 3E5179

200-CH45 BK-4

200-CH45 BK-4

1

200-CV6 BK-16 453-CV8 PK-18 416-CV11 OR-18 484-CV13 YL-18 417-CV14 GY-18 C216-CV16 BK-18

CJ-C12 1552252

1 2 3 4 5 6 7 8 9 10 11 12

1 2 3 4 5 6 7 8 9 10 11 12

727-CV2 GN-16

727-CV2 GN-16

CJ-C13 3E5179

727-CJ20 GN-16

200-CJ28 BK-16 453-CJ13 PK-18 416-CJ9 OR-18 484-CJ14 YL-18 417-CJ11 GY-18 C216-CJ29 BK-18

XMSN OIL TEMP SENDER 145-7028 1 2

CONVERTER OUTPUT SPEED SNSR 196-1185

BK-18 WH-18

FRAME GROUND S

200-CV6 BK-16

G

BTRY MOT

CBL-MM1 RD-00

CBL-MM1 RD-00

BATTERY

SEC STRG MOT 313-5855

SECONDARY STEERING GND

SECONDARY STEERING

BK-18 BK-18

I

1 2

CJ-C11 1552269 321-CJ7 BR-18 J814-CJ22 BK-18

CL 1 (FWD LOW) SOL 244-3114

1 2

CL 3 (REVERSE) SOL 244-3114

1 2

AT-C5 1552269 751-AT3 GN-18 J808-AT18 BK-18

J807-AT17 BK-18 J807-AT20 BK-18 J807-AT22 BK-18 J807-AT27 BK-18

1 2

AT-C7 1552269 755-AT12 OR-18 J807-AT17 BK-18

J808-AT1 BK-18 J808-AT18 BK-18

CL 6 (SPEED 1) SOL 244-3114

1 2

AT-C8 1552269 901-AT14 WH-18 J807-AT20 BK-18

J809-AT21 BK-18

CL 5 (SPEED 3) SOL 244-3114

1 2

AT-C6 1552269 900-AT13 PU-18 J807-AT22 BK-18

1

CBL-RR1 BK-00

LEFT SIDE ENGINE

BK-18 WH-18

RD

HOOD ACTUATOR MOTOR 305-8958

1

MOTOR

CBL-JJ1 BK-00

1

397-CJ54 OR-14

ENGINE BLOCK GND

BK

1

OUTPUT SPEED SNSR LEADING 196-1185

LH FRAME STARTER GND

CJ-C20 1297163

CJ-C16 1552273 397-CJ54 OR-14 A300-CJ58 GN-16 200-CJ60 BK-14 398-CJ55 BU-14 175-CJ51 RD-14 A301-CJ57 WH-16

109-CH66 RD-4

398-CJ55 BU-14

ENGINE APPLICATION

2 3 1

H

CH-C22 3E3364 BK-18

1 2

BK-18

A/C PRESSURE SWITCH IS NORMALLY OPEN BEFORE REFRIGERANT CHARGE

CJ-C21 1552267 A301-CJ57 WH-16 199-CJ3 RD-16 A300-CJ58 GN-16

1 2

CH-C18 1552269 513-CH71 OR-14-GXL 521-CH17 YL-14-GXL

521-CH17 YL-14-GXL

HVAC ARC SUPPRESSOR 218-4935 AC CLUTCH SOL 183-5106 GN-14 GN-14

1 2

UNSWITCHED BUSS BRKR (CAB) 171-2205

522-CH73 WH-14-GXL 522-CH72 WH-14-GXL

BK-16 BK-16

MAIN BREAKER 171-2210

522-CH24 WH-14-GXL BUSS BAR 267-2265

MAIN RELAY 241-8368

308-CJ5 YL-16 200-CJ59 BK-16

1 2

178-XX1 GN-6

80A

GLOWPLUG 4 361-9875

398-CJ55 BU-14 J766-CJ23 PU-18 X918-CJ35 PU-18 X919-CJ36 WH-18

125-CH50 OR-8

GLOWPLUG 6 361-9875

MOTOR

1 2

CH-C25 1552269 A893-CH76 OR-16-GXL 200-CH37 BK-16-GXL

BK-18 BK-18

FUEL PRIMING PUMP 212-3657

G

FUEL PRIMING PUMP SW 260-5864 BK-18 RD-18 WH-18

MOM

BK-18 BK-18

1 2

A B C

BK-18 RD-18 WH-18

2

AR-C2 AR-C1 1552269 3E3364 P739-AR1 BU-16 200-AR2 BK-16

A B C

1 2

BUSS BAR 267-2265

149-CJ129 PU-16 R941-CJ27 GY-16

106-GP1 RD-8

40A

112-CJ18 PU-4 125-CJ37 OR-8 149-CJ129 PU-16 177-CJ1 RD-8

101-WE1 RD-4

200-CJ59 BK-16 308-CJ5 YL-16 R941-CJ27 GY-16

CH-C13 1552269 P739-CH51 BU-16-GXL 200-CH52 BK-16-GXL

VS GROUND SIGNAL

FAN PUMP 321-8191

FAN VALVE 331-3257

1 2

RF-C2 1552269 H704-RF3 PK-18 200-RF4 BK-18

1 2

RF-C3 1552269 H704-RF5 PK-18 200-RF6 BK-18

H704-RF3 PK-18 H704-RF5 PK-18 200-RF4 BK-18 200-RF6 BK-18

+BATTERY GROUND SIGNAL

OR-18 BK-18 YL-18

A B C

1 2

CH-C10 1552269 F762-CH55 GY-18-GXL E748-CH56 BK-18-GXL

ENGINE APPLICATION

P989-CH11 GN-18-GXL

110-CH3 RD-18-GXL 110-CH6 RD-18-GXL 110-CH1 RD-18-GXL 110-CH2 RD-18-GXL

110-CH19 RD-14-GXL 110-CH18 RD-14-GXL 110-CH18 RD-14-GXL 110-CH19 RD-14-GXL 125-CH50 OR-8 150-CH29 OR-18-GXL 200-CH65 BK-16-GXL 229-CH20 BK-14-GXL 229-CH21 BK-14-GXL 326-CH23 PU-16-GXL 403-CH43 GN-18-GXL 521-CH17 YL-14-GXL 522-CH24 WH-14-GXL 944-CH26 OR-18-GXL 945-CH28 BR-18-GXL A307-CH41 GY-18-GXL A982-CH32 BR-18-GXL

125-CH50 OR-8 150-CH29 OR-18-GXL

CRANK SPEED SNSR PE-C4 238-0120 2388247 V+ 1 996-PE69 GN-18 SIG 2 E965-PE52 BU-18-GXL CAM SPEED SNSR 311-3858 V+ SIG

E

1 2

994-PE56 GY-18-GXL 995-PE43 BU-18-GXL 996-PE37 339-5434-GXL 996-PE69 GN-18 996-PE70 GN-18

PE-C3 2388247 996-PE70 GN-18 P920-PE53 BR-18-GXL

C211-PE44 C967-PE42 E965-PE52 L730-PE47

COOLANT TEMP SNSR PE-C10 278-5307 2304011 V+ 1 995-PE43 BU-18-GXL GND 2 L731-PE66 BR-18

L731-PE10 BR-18-GXL L731-PE66 BR-18 L731-PE68 BR-18

INTAKE MANIFOLD TEMP SNSR PE-C8 278-5272 2304011 V+ 1 C967-PE42 BU-18-GXL GND 2 L731-PE68 BR-18

M795-PE17 P920-PE53 R997-PE48 T993-PE38 T997-PE46 X731-PE55 Y946-PE51 Y947-PE39 Y948-PE40 Y950-PE25 Y951-PE26

INTAKE MANIFOLD PRESS SNSR PE-C7 278-5273 2370227 +V A T997-PE46 OR-18-GXL B GROUND T993-PE38 BR-18-GXL C SIGNAL X731-PE55 BU-18-GXL FUEL RAIL PRESS SNSR PE-C6 311-6342 2304013 +V A R997-PE48 OR-18-GXL GROUND B Y948-PE40 BR-18-GXL SIGNAL C Y946-PE51 BU-18-GXL OIL PRESS SNSR PE-C5 278-5225 2304013 +V A L730-PE47 OR-18-GXL GROUND B Y947-PE39 BR-18-GXL SIGNAL C 994-PE56 GY-18-GXL FUEL PUMP SOL 312-5621 1 2

D SMART WASTGATE

1 2

PE-C2 1549646 Y950-PE25 YL-18-GXL Y951-PE26 PU-18-GXL PE-C15 2388245 C211-PE44 BK-18-GXL M795-PE17 WH-18-GXL

BK-18-GXL BU-18-GXL BU-18-GXL OR-18-GXL

INJ 1 320-0690

T951-PH1 T957-PH2 T952-PH3 T958-PH4

INJ 2 320-0690

WH-18-GXL BR-18-GXL OR-18-GXL BR-18-GXL OR-18-GXL BU-18-GXL BU-18-GXL BR-18-GXL BR-18-GXL YL-18-GXL PU-18-GXL

PH-C1 PE-C12 1134630 1552272 4 X920-PE34 BK-16 3 X926-PE58 BK-16 2 X921-PE35 BK-16 1 X927-PE57 BK-16

BR-18-GXL GY-18-GXL PK-18-GXL YL-18-GXL

CONN 3

INJ 3 320-0690

T953-PG1 T959-PG2 T954-PG3 T960-PG4

INJ 4 320-0690

PG-C1 PE-C13 1134630 1552272 4 BK-16 X922-PE8 WH-18-GXL 3 BK-16 X928-PE64 GN-18-GXL 2 BK-16 X923-PE33 OR-18-GXL 1 BK-16 X929-PE59 BU-18-GXL

CONN 2

INJ 5 320-0690

T955-PF1 T961-PF2 T956-PF3 T962-PF4

INJ 6 320-0690

PF-C1 PE-C14 1134630 1552272 4 X924-PE6 BR-18-GXL BK-16 3 X930-PE62 GY-18-GXL BK-16 2 X925-PE7 PK-18-GXL BK-16 1 X931-PE63 YL-18-GXL BK-16

X931-PE63 YL-18-GXL X930-PE62 GY-18-GXL X929-PE59 BU-18-GXL 996-PE37 GN-18-GXL

M795-PE17 WH-18-GXL C211-PE44 BK-18-GXL

Y950-PE25 YL-18-GXL Y951-PE26 PU-18-GXL

X928-PE64 GN-18-GXL X927-PE57 YL-18-GXL X926-PE58 GY-18-GXL L731-PE10 T993-PE38 Y947-PE39 Y948-PE40

BR-18-GXL BR-18-GXL BR-18-GXL BR-18-GXL

C967-PE42 BU-18-GXL 995-PE43 BU-18-GXL T997-PE46 OR-18-GXL L730-PE47 OR-18-GXL R997-PE48 OR-18-GXL Y946-PE51 BU-18-GXL E965-PE52 BU-18-GXL P920-PE53 BR-18-GXL X731-PE55 BU-18-GXL 994-PE56 GY-18-GXL X920-PE34 BR-18-GXL X921-PE35 PK-18-GXL X922-PE8 WH-18-GXL X925-PE7 PK-18-GXL X924-PE6 BR-18-GXL X923-PE33 OR-18-GXL

ENGINE ECM 331-7539 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 56 57 58 59 60 61 62 63 64

- BATTERY - BATTERY - BATTERY

INJECTOR 6 DRIVER RETURN INJECTOR 5 DRIVER RETURN INJECTOR 4 DRIVER RETURN SPEED SENSOR SUPPLY

+ + -

BATTERY BATTERY BATTERY BATTERY

+ BATTERY + BATTERY SMART WASTEGATE PWM SIGNAL SMART WASTEGATE GROUND CAN DATALINK + CAN DATALINK -

FUEL PUMP SOLENOID SIGNAL FUEL PUMP SOLENOID RETURN

CAT DATALINK + CAT DATALINK DEMAND FAN SOL RETURN START AID SOLENOID RETURN

START AID SOLENOID

INJECTOR 3 DRIVER RETURN INJECTOR 2 DRIVER RETURN INJECTOR 1 DRIVER RETURN COMMON SENSOR GROUND INT MAN AIR PRESSURE GROUND OIL PRESSURE GROUND FUEL RAIL PRESSURE GROUND INTAKE MAN AIR TEMP SIGNAL COOLANT TEMPERATURE SIGNAL

INT MAN AIR PRESS PWR SUPPLY OIL PRESSURE POWER SUPPLY FUEL RAIL PRESS POWER SUPPLY

FUEL RAIL PRESSURE SIGNAL CRANK SPEED SIGNAL CAM SPEED SIGNAL INTAKE MAN PRESSURE SIGNAL OIL PRESSURE SIGNAL INJECTOR 1 HIGH SIDE DRIVER INJECTOR 2 HIGH SIDE DRIVER INJECTOR 3 HIGH SIDE DRIVER

INJECTOR 6 HIGH SIDE DRIVER INJECTOR 5 HIGH SIDE DRIVER INJECTOR 4 HIGH SIDE DRIVER

DEMAND FAN SOLENOID SENSOR RETURN SWG RETURN

KEY SWITCH ON 5V SENSOR SUPPLY THROTTLE SENSOR POWER GROUND LEVEL SHUTDOWN (N/O) GROUND LEVEL SHUTDOWN (N/C)

AUX GND LVL SHUTDOWN

THROTTLE POSITION SENSOR

AMBIENT AIR TEMP SENSOR GLOWPLUG RELAY

REVERSING FAN RELAY

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 56 57 58 59 60 61 62 63 64

CH-C2 2451042 229-CH8 BK-18-GXL 229-CH9 BK-18-GXL 229-CH4 BK-18-GXL

110-CH2 110-CH1 229-CH7 229-CH5

RD-18-GXL RD-18-GXL BK-18-GXL BK-18-GXL

110-CH3 RD-18-GXL 110-CH6 RD-18-GXL

Y794-CH22 OR-18-GXL Y795-CH25 GN-18-GXL 944-CH26 OR-18-GXL 945-CH28 BR-18-GXL H747-CH15 BR-18-GXL E748-CH56 BK-18-GXL F762-CH55 GY-18-GXL U703-CH13 YL-18-GXL J765-CH30 BU-18-GXL J766-CH31 PU-18-GXL

200-CH37 BK-16-GXL 200-CH52 BK-16-GXL 200-CH68 BK-18-GXL 229-CH8 BK-18-GXL 229-CH4 BK-18-GXL 229-CH9 BK-18-GXL 229-CH5 BK-18-GXL 229-CH7 BK-18-GXL

J766-CH31 M739-CH61 P739-CH51 R941-CH48 U703-CH13 X918-CH58 X919-CH59 Y794-CH22 OR-18-GXL Y795-CH25 GN-18-GXL

150-CH29 OR-18-GXL T786-CH33 GY-18-GXL

200-CH65 BK-16-GXL

229-CH12 BK-18-GXL 229-CH14 BK-14-GXL 229-CH20 BK-14-GXL 229-CH21 BK-14-GXL

326-CH23 PU-16-GXL 403-CH43 GN-18-GXL 521-CH17 YL-14-GXL 522-CH24 WH-14-GXL 944-CH26 OR-18-GXL 945-CH28 BR-18-GXL A307-CH41 GY-18-GXL A982-CH32 BR-18-GXL E960-CH10 OR-18-GXL H704-CH74 PK-18-GXL H747-CH15 BR-18-GXL J765-CH35 BU-18-GXL J765-CH30 BU-18-GXL

H704-CH74 H747-CH15 J765-CH36 J766-CH31 M739-CH61 P739-CH51 R941-CH48 U703-CH13 X918-CH58 X919-CH59 Y794-CH16 Y795-CH27

J765-CH36 BU-18-GXL PU-18-GXL YL-18-GXL BU-16-GXL GY-18-GXL YL-18-GXL PU-18-GXL WH-18-GXL

Y794-CH16 OR-18-GXL Y794-CH42 OR-18-GXL

CH-C6 1552267 Y794-CH42 OR-18-GXL Y795-CH49 GN-18-GXL

Y795-CH27 GN-18-GXL Y795-CH49 GN-18-GXL

T786-CH33 GY-18-GXL Y772-CH34 GN-18-GXL

E960-CH10 OR-18-GXL

E748-CH56 BK-18-GXL F762-CH55 GY-18-GXL

200-CH65 BK-16-GXL 150-CH29 OR-18-GXL P739-CH51 BU-16-GXL J766-CH31 PU-18-GXL 326-CH23 PU-16-GXL M739-CH61 YL-18-GXL R941-CH48 GY-18-GXL X919-CH59 WH-18-GXL Y795-CH27 GN-18-GXL Y794-CH16 OR-18-GXL X918-CH58 PU-18-GXL

PK-18-GXL BR-18-GXL BU-18-GXL PU-18-GXL YL-18-GXL BU-16-GXL GY-18-GXL YL-18-GXL PU-18-GXL WH-18-GXL OR-18-GXL GN-18-GXL

CH-C3 2304011 E960-CH10 OR-18-GXL 229-CH12 BK-18-GXL

E748-CH56 BK-18-GXL F762-CH55 GY-18-GXL

A982-CH32 BR-18-GXL X918-CH58 PU-18-GXL X919-CH59 WH-18-GXL

H704-CH74 PK-18-GXL U703-CH13 YL-18-GXL H747-CH15 BR-18-GXL

945-CH28 BR-18-GXL 944-CH26 OR-18-GXL

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31

A B C

397-CJ54 OR-14 398-CJ55 BU-14

125-CH50 OR-8 521-CH17 YL-14-GXL 522-CH24 110-CH18 110-CH19 229-CH20 229-CH21 1 2

AUX GND LVL SHUTDOWN

WH-14-GXL RD-14-GXL RD-14-GXL BK-14-GXL BK-14-GXL

COAX CORE COAX SAFEGUARD RED WHITE

110-CJ115 RD-14 110-CJ116 RD-14 112-CJ18 PU-4 149-CJ129 PU-16 150-CJ117 OR-16 164-CJ62 WH-16 175-CJ51 RD-14 177-CJ1 RD-8 199-CJ3 RD-16

112-CJ18 PU-4 149-CJ129 PU-16 175-CJ51 RD-14 177-CJ1 RD-8 199-CJ3 RD-16 200-CJ59 BK-16 200-CJ60 BK-14 308-CJ5 YL-16

H20

125-CJ37 OR-8 J766-CJ23 PU-18

200-CJ59 BK-16 200-CJ60 BK-14 200-CJ146 BK-14 200-CJ69 BK-18 200-CJ71 BK-18

H20

H704-CJ150 PK-18 U703-CJ52 YL-18 H747-CJ56 BR-18 110-CJ115 RD-14 110-CJ116 RD-14 150-CJ117 OR-16 200-CJ141 BK-16 229-CJ21 BK-14 229-CJ24 BK-14 326-CJ133 PU-16 403-CJ90 GN-18 521-CJ113 YL-14 522-CJ114 WH-14 944-CJ102 OR-18 945-CJ103 BR-18 A307-CJ78 GY-18 A982-CJ30 BR-18

110-CJ115 RD-14 110-CJ116 RD-14 150-CJ117 OR-16 200-CJ141 BK-16 229-CJ21 BK-14 229-CJ24 BK-14 326-CJ133 PU-16 403-CJ90 GN-18 521-CJ113 YL-14

P739-CJ140 BU-16 J766-CJ23 PU-18 326-CJ133 PU-16 M739-CJ151 YL-18 R941-CJ27 GY-16 X919-CJ36 WH-18 Y795-CJ101 GN-18 Y794-CJ100 OR-18

522-CJ114 WH-14 944-CJ102 OR-18 945-CJ103 BR-18 A307-CJ78 GY-18 A982-CJ30 BR-18 H704-CJ150 PK-18 H747-CJ56 BR-18 J765-CJ53 BU-18 M739-CJ151 YL-18 P739-CJ140 BU-16 P989-CJ4 GN-18 U703-CJ52 YL-18 Y794-CJ100 OR-18 Y795-CJ101 GN-18

X918-CJ35 PU-18 945-CJ103 BR-18 944-CJ102 OR-18

CJ-C50 2736316 125-CJ37 OR-8 521-CJ113 YL-14

C216-CJ29 BK-18 C216-CJ26 BK-18 C216-CJ125 BK-18

H704-CJ150 PK-18 H747-CJ56 BR-18 J765-CJ53 BU-18 M739-CJ151 YL-18 P739-CJ140 BU-16 P989-CJ4 GN-18 U703-CJ52 YL-18 Y794-CJ100 OR-18 Y795-CJ101 GN-18

522-CJ114 WH-14 110-CJ115 RD-14 110-CJ116 RD-14 229-CJ21 BK-14 229-CJ24 BK-14

AK-C4 AK-C5 1552267 1552267 138-AK1 GN-18 251-AK2 BK-18 C530-AK11 BU-18

A B C

LIFT POSN SNSR 266-1484 OR-18 BK-18 WH-18

1 2

CL-C1 CL-C2 1552269 1552269 G485-CL1 BU-18 C216-CL2 BK-18

1 2

BK-18 BK-18 T

FRONT AXLE OIL MONITORING 155-8999

J

RH HI LO POSN TURN LAMP2 344-3455

200-M1 BK-14 606-M4 GY-16

611-M6 619-M5 618-M7 606-M4 200-M1

611-M6 PU-14 618-M7 YL-16 619-M5 GN-14

M-C2 1552273 PU-14 GN-14 YL-16 GY-16 BK-14

YL-18 BU-18 RD-18 WH-18

4 6 3 1 2 5

BK-18

CONN 20 1 2

IMPLEMENT PILOT SHUTOFF SOL 241-5895

GN-18 GN-18

CONNECT TO C-C14 SH2 LOC H-17

CONN 14

AG-C14 3E3382 709-AG20 OR-18 J764-AG21 BR-18 G993-AG22 GN-18 G994-AG24 GY-18 G991-AG25 BR-18 G992-AG26 BU-18

AG-C15 1552273 1 2 3 4 5 6

709-AN1 OR-18 709-AN7 OR-18 709-AN8 OR-18

AN-C1 1552273 709-AN1 OR-18 J764-AN2 BR-18 G993-AN3 GN-18 G994-AN4 GY-18 G991-AN5 BR-18 G992-AN6 BU-18

1 2 3 4 5 6

G991-AN5 G992-AN6 G993-AN3 G994-AN4

CONN 19

BR-18 BU-18 GN-18 GY-18

J764-AN2 BR-18 J764-AN9 BR-18 J764-AN10 BR-18

AG-C7 1552267 A B C

A B C

AM-C1 1552267 200-AM1 BK-18 779-AM2 WH-18

AE-C1 3E3364

AN-C2 1552272 709-AN7 OR-18 J764-AN9 BR-18 G993-AN3 GN-18 G994-AN4 GY-18

1 2 3 4

AN-C3 1552272 709-AN8 OR-18 J764-AN10 BR-18 G991-AN5 BR-18 G992-AN6 BU-18

1 2 3 4

LH FRONT WHEEL SPEED SNSR 264-0148 RD-18 BK-18 GN-18 WH-18

+8V RETURN SIG A SIG B

RH FRONT WHEEL SPEED SNSR 264-0148 RD-18 BK-18 GN-18 WH-18

I

+8V RETURN SIG A SIG B

200-AM1 BK-18

200-AM3 BK-18 200-AM6 BK-18

779-AM2 WH-18

779-AM4 WH-18 779-AM5 WH-18

AM-C2 1552269 779-AM4 WH-18 200-AM3 BK-18 AM-C3 1552269 779-AM5 WH-18 200-AM6 BK-18

QUICK COUPLER SOL 233-9585 1 2

BK-18 BK-18

QUICK CPLR ARC SUPPR 218-4935 1 2

RIDE CONTROL SOL 1 244-8686

AE-C2 1552269 976-AE1 OR-18 J815-AE2 BK-18

1 2

N936-AG9 YL-18 J815-AG7 BK-18

1 2

GN-18 GN-18

AE-C3 3E3364 1 2

N936-AE3 YL-18 J815-AE4 BK-18

H

RIDE CONTROL SOL 2 244-8686

AE-C4 1552269 1 2

GN-18 GN-18

CONN 16

Y794-CJ100 OR-18 Y795-CJ101 GN-18 944-CJ102 OR-18 945-CJ103 BR-18 199-CJ3 RD-16 149-CJ129 PU-16 326-CJ133 PU-16 A982-CJ30 BR-18 J765-CJ53 BU-18 A307-CJ78 GY-18 R732-CJ112 BR-18 H746-CJ153 YL-18 J808-CJ25 BK-18 M893-CJ76 GY-16 150-CJ117 OR-16 P739-CJ140 BU-16 E929-CJ124 GY-18 164-CJ62 WH-16 C495-CJ152 OR-18

C216-CJ32 BK-18

P988-CJ6 OR-18 J807-CJ2 BK-18 110-CJ116 RD-14 175-CJ51 RD-14

CJ-C47 8N1533 112-CJ18 PU-4 177-CJ1 RD-8 521-CJ113 YL-14 522-CJ114 WH-14 110-CJ115 RD-14

AC-C1 1010205

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 56 57 58 59 60 61 62 63 64 65 66 67 68 69 70

1 2 3 4 5 6 7

CONNECT TO C-C36 SH2 LOC I-3

CONN 15

CONNECT TO C-C15 SH2 LOC F-17

CONN 13

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40

AC-C10 1552267 J808-AC35 BK-18 F766-AC36 WH-18 761-AC17 GY-18

114-AC1 RD-16 200-AC38 BK-14 200-AC39 BK-14

114-AC1 RD-16 200-AC3 BK-14

200-AC9 BK-14 200-AC3 BK-14

322-AC5 GY-16 G485-AC48 BU-18

606-AC12 GY-18

606-AC42 GY-16 606-AC43 GY-16

610-AC30 OR-14

610-AC40 OR-14 610-AC51 OR-14

611-AC13 PU-14

611-AC44 PU-14 611-AC45 PU-14

709-AC10 OR-18 J764-AC19 BR-18 G993-AC21 GN-18 G994-AC22 GY-18 G991-AC27 BR-18 G992-AC28 BU-18 610-AC30 OR-14 M927-AC7 GN-16

F766-AC20 WH-18 G485-AC48 G991-AC27 G992-AC28 G993-AC21 G994-AC22 J764-AC19 J808-AC2 BK-18

J815-AC25 BK-18

GROUND + BATTERY SOLENOID

1 2

OR-14 BK-14 YL-16 BK-14 PU-14 BR-16 GY-16 GN-14

1 2 3 4 5 6 7 8 9 10 11 12

619-AC47 GN-14 619-AC46 GN-14

709-AC10 OR-18 761-AC17 GY-18 762-AC18 YL-18 779-AC4 WH-18 964-AC24 BU-18 976-AC26 OR-18 C216-AC23 BK-18

964-AC24 BU-18

BK-18 OR-18 BU-18

AC-C6 3E5179 610-AC40 200-AC39 605-AC11 200-AC38 611-AC44 617-AC14 606-AC43 619-AC47

617-AC14 BR-16 618-AC15 YL-16

619-AC16 GN-14

IT LIFT POSITION SW 3E-7844

IT FORWARD HORN 174-7875

114-AC1 RD-16 322-AC5 GY-16

322-AC5 GY-16 605-AC11 YL-16

605-AC11 YL-16 606-AC12 GY-18 611-AC13 PU-14 618-AC15 YL-16 617-AC14 BR-16 619-AC16 GN-14 761-AC17 GY-18 762-AC18 YL-18 779-AC4 WH-18 F766-AC20 WH-18 C216-AC23 BK-18 J808-AC2 BK-18 J815-AC25 BK-18 976-AC26 OR-18 N936-AC29 YL-18

A B C

AC-C11 1552269

200-AC37 BK-16 200-AC41 BK-14 200-AC6 BK-18 200-AC8 BK-16

F766-AC36 WH-18 F766-AC33 WH-18 F766-AC31 WH-18 BU-18 BR-18 BU-18 GN-18 GY-18 BR-18

+ BATTERY SOLENOID GROUND

IT FORK POSITION SW 3E-7844

AC-C8 3E3370 A F766-AC31 WH-18 B 762-AC18 YL-18 C J808-AC32 BK-18

OR-18 BU-18 BK-18

+ BATTERY SOLENOID GROUND

IT BUCKET POSITION SW 176-5459

1 2

G

CONN 23

OR-18 BU-18 BK-18

AC-C2 3E3364 G485-AC48 BU-18 C216-AC23 BK-18

J808-AC32 BK-18 J808-AC34 BK-18 J808-AC35 BK-18

LH FRONT LIGHTING (ROADING) CONNECT TO L-C1 SH1 LOC L-2 AY-C1 SH1 LOC D-4 FOR BUCKET TURN SIGNALS

AC-C9 3E3370 A F766-AC33 WH-18 B 964-AC24 BU-18 C J808-AC34 BK-18

AC-C3 1552269 FRONT AXLE MONITORING CONNECT TO CL-C2 SH1 LOC K-4

AC-C7 3E5179 610-AC51 200-AC41 606-AC42 200-AC37 611-AC45 618-AC15

J815-AC50 BK-18 J815-AC49 BK-18

M927-AC7 GN-16 N936-AC29 YL-18

OR-14 BK-14 GY-16 BK-16 PU-14 YL-16

1 2 3 4 5 6 7 8 9 10 11 12

619-AC46 GN-14

AC-C12 1552269 M927-AC7 GN-16 200-AC8 BK-16

1 2

F RH FRONT LIGHTING (ROADING) CONNECT TO M-C1 SH1 LOC J-2

IMPL PILOT SHUTOFF SOL IT38G 241-5895

GN-18 GN-18

AC-C14 AC-C15 3E3382 1552273 1 709-AC10 OR-18 2 J764-AC19 BR-18 3 G993-AC21 GN-18 FRONT AXLE SPEED SNSRS 4 G994-AC22 GY-18 CONNECT TO AN-C1 SH1 LOC I-2 5 G991-AC27 BR-18 6 G992-AC28 BU-18

CONNECT TO C-C16 SH2 LOC E-17

CONN 12

AC-C16 1552269 976-AC26 OR-18 J815-AC50 BK-18

1 2

RIDE CONTROL / 3RD & 4TH FUNCTION CONNECT TO AE-C1 SH1 LOC H-2

AC-C17 1552269 N936-AC29 YL-18 J815-AC49 BK-18

1 2

RIDE CONTROL / 3RD & 4TH FUNCTION CONNECT TO AE-C3 SH1 LOC H-2

E

AC-C5 1552267

AC-C4 3E3370 200-AC6 BK-18 779-AC4 WH-18

R732-CJ112 BR-18 J764-CJ63 BR-18

A B C

A B C

FOR QUICK COUPLER ATCH CONNECT TO AM-C1 SH1 LOC H-2

IT38H FRONT FRAME 1 2

LH HI LO POSN TURN LAMP 344-3456

T

AY-C2 1552273

HYD OIL TEMP SENDER 256-6453

PART NO

CHG

NOTE

DESCRIPTION HARNESS AS.

229-CJ21 BK-14 229-CJ24 BK-14 H747-CJ56 BR-18 U703-CJ52 YL-18

Y772-CH34 GN-18-GXL R941-CH48 GY-18-GXL

229-CJ21 BK-14 229-CJ24 BK-14 H747-CJ56 BR-18 U703-CJ52 YL-18

M739-CH61 YL-18-GXL

BK-18 BK-18

HC-C2 1552269 1 2

LOW BRAKE OIL PRESS SW 314-2405 BK-16

C

RD-16 BU-16

BK-18 BK-18

DIFF LOCK ACTUATION SOL 174-4916

REAR DIFF LOCK SOL 241-5895

E455-HC1 BR-18 C216-HC2 BK-18

HC-C3 1552267 A B C

HYD FILTER BYPASS SW 227-6744

C216-HC3 BK-18 X778-HC4 PU-18 A907-HC7 BU-18 A975-HC11 BU-18

HC-C4 1552269 1 2

N787-HC5 BU-18 C216-HC6 BK-18

1 2

HC-C5 1552269 A907-HC7 BU-18 J809-HC8 BK-18

1 2

HC-C6 1552269 J845-HC9 PU-18 J809-HC10 BK-18

C216-HC2 BK-18 C216-HC3 BK-18 C216-HC6 BK-18 C216-HC19 BK-18

VARIABLE SPEED FAN SOLENOID 313-7668

B

CASE DRAIN FILTER SW 337-4102 BK-18 BK-18

1 2

1 2

C216-HC14 BK-18

J809-HC10 BK-18 J809-HC8 BK-18 J809-HC12 BK-18

J809-HC13 BK-18

1 2 3 4 5 6 7 8 9 10 11 12

CJ-C29 3E5179 E455-CJ33 BR-18 C216-CJ26 BK-18 J809-CJ119 BK-18 X778-CJ34 PU-18 N787-CJ67 BU-18 H746-CJ153 YL-18 A907-CJ120 BU-18 J808-CJ25 BK-18 J845-CJ122 PU-18 C495-CJ152 OR-18 A975-CJ31 BU-18

CONN 10

J845-HC9 PU-18 N787-HC5 BU-18 X778-HC4 PU-18

A975-HC11 BU-18 J809-HC12 BK-18 HC-C10 1552269 J808-HC16 BK-18 H746-HC20 YL-18

HC-C11 1552269

WIRE AS 8Y-7833 BK-18

HC-C1 1552252 E455-HC1 BR-18 C216-HC14 BK-18 J809-HC13 BK-18 X778-HC4 PU-18 N787-HC5 BU-18 H746-HC20 YL-18 A907-HC7 BU-18 J808-HC16 BK-18 J845-HC9 PU-18 C495-HC18 OR-18 A975-HC11 BU-18

C495-HC18 OR-18 E455-HC1 BR-18 H746-HC20 YL-18 J808-HC16 BK-18

HC-C7 1552269 FRONT DIFF LOCK SOL 241-5895

1 2

C495-HC18 OR-18 C216-HC19 BK-18

HYD SERVICE CENTER

A C L M T U W AC AE AG AJ AK AM AN AP AR AT AW AX AY CA CE CG CH CJ CL CR CT CU CV HC HV PC PE PF PG PH PL RF

200-5728 344-7930 267-2999 267-2998 146-1892 115-5777 267-1106 307-3107 305-4381 300-6440 192-7805 305-4377 252-0040 300-6444 277-8271 282-9047 344-7928 305-4382 277-8272 286-9546 305-4374 266-8620 284-3283 364-5132 364-1971 305-4375 300-6446 214-5372 272-5749 307-3087 300-6451 276-4300 281-9481 260-5541 285-1975 285-1975 285-1975 281-9480 362-3341

02 02 02 02 01 01 00 02 00 04 00 00 01 00 02 00 00 00 02 01 00 07 02 02 00 00 01 00 01 01 02 00 02 03 02 02 02 01 00

J X Y CY FF FG FH FY GP GY JU KK WE

307-0543 160-9419 160-9419 304-6911 283-4960 235-5762 235-5762 304-6911 307-3894 307-0543 101-9161 283-4960 308-7489

00 01 01 01 02 01 01 01 00 00 01 02 00

AU CC EE GG HH JJ MM PP RR XX WW

305-4383 300-6448 307-3089 306-5399 306-5400 305-4384 307-3095 307-3093 306-5401 300-6449 306-5398

04 02 00 04 04 03 03 02 03 00 02

ENTERTAINMENT RADIO MAIN CAB LH FRONT LIGHTING (ROADING) RH FRONT LIGHTING (ROADING) STOP LAMP SW IN LH BRAKE PEDAL LH/RH BUCKET TURN CLEARANCE LAMP ENTERTAINMENT RADIO (JAPAN) IT38H FRONT FRAME RIDE CONTROL 938H FRONT FRAME SEAT - AIR SUSPENSION PCS JUMPER QUICK COUPLER AUTO DIFFERENTIAL LOCK (FRONT) AUTOLUBE PUMP AXLE OIL COOLER TRANSMISSION AUTOLUBE PUMP JUMPER AUTOLUBE PUMP ROADING LIGHTS (BUCKET TURN SIG) RR AXLE TEMP MONITORING ROOF WAVES DISPLAY ENGINE APPLICATION MAIN CHASSIS FR AXLE TEMP MONITORING AUTO DIFFERENTIAL LOCK (REAR) (EUROPE) TURN SIG LICENSE PLATE LAMP (GERMAN ROADING) SECONDARY STEERING HYDRAULIC SERVICE CENTER HVAC PCS SUBSYSTEM HARNESS TO ECM PERKINS BASIC ENGINE INJECTORS INJECTORS INJECTORS GATEWAY ECM VARIABLE PITCH FAN WIRE AS. RH REAR HID RH SPEAKER (JAPAN) LH SPEAKER (JAPAN) LH FRONT HID BUCKET FORK SELECT SWITCH JUMPER LH FRONT CAB FLOOD RH FRONT CAB FLOOD RH FRONT HID GLOWPLUG RELAY TO GLOWPLUG BUSSBAR LH REAR HID FNR JUMPER LEFT TILT KOUT SET SWITCH JUMPER BLOCK AS. TO GLOWPLUG BREAKER

ATCH ATCH ATCH ATCH ATCH ATCH ATCH ATCH ATCH

ATCH

ATCH ATCH ATCH

ATCH

ATCH ATCH

MATES TO AG-C4 SH1 LOC L-2 (938H) AC-C6 SH1 LOC G-2 (IT38H)

CONN 23

A IMPLEMENT PWR MANAGEMENT SOL 313-7668

12

11

10

9

1 2

CJ-C35 1552269 P988-CJ6 OR-18 J807-CJ2 BK-18

8

7

6

ATCH

ATCH ATCH

5

200-AY1 BK-14 200-AY10 BK-14

605-AY2 YL-16

611-AY6 619-AY5 617-AY7 605-AY4 200-AY1

605-AY3 YL-16 605-AY4 YL-16

PU-14 GN-14 BR-16 YL-16 BK-14

5 4 6 3 1 2

LH BKT TURN CLEARANCE LAMP 115-5774 617-U5 BR-14 605-U3 YL-14

BU-18 RD-18 WH-18 YL-18 BK-18

200-U7 BK-14

606-AY11 GY-16 611-AY6 PU-14 617-AY8 BR-16

AY-C3 U-C1 6C7157 1155776 54 617-U1 617-AY9 BR-16 58R 606-U2 606-AY11 GY-16 58L 605-U3 605-AY3 YL-16 31 200-U4 200-AY10 BK-14

617-AY9 BR-16 617-AY7 BR-16

619-AY5 GN-14

YL-18 PU-18

617-U5 617-U6 606-U2 605-U3 200-U7 200-U8

BR-14 GY-14 YL-14 BK-14

1

RH BKT TURN CLEARANCE LAMP 115-5774

BR-14 BR-14 GY-14 YL-14 BK-14 BK-14

606-U2 GY-14 617-U6 BR-14 200-U8 BK-14

D

YL-18 PU-18 1

BUCKET TURN LAMPS

SYMBOL

WIRE GROUP COLOR DESCRIPTIONS

DESCRIPTION CIRCUIT CONNECTED

GROUND CIRCUIT WIRES THAT HAVE SYSTEM VOLTAGE WHEN THE KEY SWITCH IS OFF

CIRCUIT NOT CONNECTED

WIRES THAT HAVE SYSTEM VOLTAGE WHEN THE KEY SWITCH IS ON

ELECTRICAL CONNECTION TO MACHINE STRUCTURE

VOLTAGE CONVERTER OUTPUT CIRCUIT

C

INTERNAL ELECTRICAL CONNECTION TO SURFACE OF COMPONENT

STARTING CIRCUIT START AID CIRCUIT

CONNECTOR

TRANSMISSION CONTROL CIRCUIT MACHINE SECURITY CONTROL CIRCUIT

H#

ENGINE CONTROL CIRCUIT HEATER AND AIR CONDITIONER CIRCUIT

CIRCUIT GROUPING DESIGNATION ATCH WIRE, CABLE, COMPONENT

TURN SIGNAL / WIPER WASHER CIRCUIT CAT DATA LINK

SPLICE

CAN DATA LINK

BLADE, SPADE, RING OR SCREW TERMINAL

RS-232 / RS-485 DATA LINK PAYLOAD CONTROL CIRCUIT

OTHER COLOR DESCRIPTIONS HIGHWAYS

WHL CHASSIS, FRONT FRAME AND EMISSIONS ENGINE WITH PILOT IMPLEMENT CONTROL,HMU STEERING AND ELECTRONIC ENGINE CONTROL WITH ELECTRO-HYDRAULIC CONTROLLED IMPLEMENTS COMMAND CONTROL STEERING AND ELECTRONIC ENGINE CONTROL COMPONENTS ARE SHOWN INSTALLED ON A FULLY OPERABLE MACHINE WITH THE KEY AND ENGINE OFF AND XMSN SHIFTER IN NEUTRAL DASHED FONT INDICATES AN ATTACHMENT COMPONENT OR HARNESS COMPONENTS IN THE FOLLOWING SYSTEMS ARE NOT OFFERED WITH OROPS CABS: HVAC, RADIO READY, WINDSHIELD WIPER AND WASHER

AUX START RECEPTACLE BLOCK AS. TO STARTER BTRY TERM BTRY1 NEG TO BTRY2 POS BTRY2 NEG TO DISC SW DISC SW TO FRAME GND ENGINE GROUND TO FRAME GROUND BLOCK AS. TO SECONDARY STRG RLY SEC STRG TO SEC STRG FRAME GROUND STARTER NEG TO LH FRAME GND MAIN RELAY TO MAIN BREAKER BTRY1 TO BLOCK AS

ATCH ATCH

1 2 3 4 5 6 7 8 9 10 11 12

AY-C1 1552252 619-AY5 GN-14 200-AY1 BK-14 605-AY2 YL-16 200-AY10 BK-14 611-AY6 PU-14 617-AY8 BR-16 606-AY11 GY-16

CONN 25

CABLE AS.

13

+BATTERY GROUND SIGNAL

M-C1 1552252

1 2 3 4 5 6 7 8 9 10 11 12

AG-C12 1552269 M927-AG53 GN-16 200-AG54 BK-16

IDENT

14

610-AG60 OR-14 200-AG5 BK-14 606-AG37 GY-16 200-AG49 BK-16 611-AG38 PU-14 618-AG39 YL-16

CJ-C32 2304011

CAN DATALINK RESISTOR ENG 134-2540

A307-CH41 GY-18-GXL

15

AG-C5 3E5179

J815-AG2 BK-18 J815-AG7 BK-18

976-AG29 OR-18 J815-AG2 BK-18

ENGINE APPLICATION

16

POWER GROUND SIGNAL

USED ON MACHINES WITH PCS (938H)} NOT AVAILABLE ON (IT38H)

AG-C3 1552269

AG-C17 1552269

CONN 1

17

OR-18 YL-18 GN-18

R732-CJ112 BR-18

CONN 8

XMSN FILTER BYPASS SW 227-6744

18

A B C

LIFT CYL HEAD END PRESS SNSR 221-3416

CONN 18

605-CJ16 YL-16 M739-CJ151 YL-18 H704-CJ150 PK-18

C495-CJ152 OR-18 E455-CJ33 BR-18 E929-CJ124 GY-18 G995-CJ72 OR-18 G996-CJ73 PK-18 G997-CJ74 PU-18 G998-CJ75 WH-18 H704-CJ150 PK-18 H746-CJ153 YL-18 J764-CJ47 BR-18 J765-CJ53 BU-18 J807-CJ2 BK-18 J808-CJ25 BK-18 J809-CJ119 BK-18 J814-CJ22 BK-18 J845-CJ122 PU-18 J854-CJ10 YL-18 M739-CJ151 YL-18 M893-CJ76 GY-16 N787-CJ67 BU-18 P739-CJ140 BU-16 P988-CJ6 OR-18 P989-CJ4 GN-18 X778-CJ34 PU-18 Y794-CJ100 OR-18 Y795-CJ101 GN-18

T786-CH33 GY-18-GXL Y772-CH34 GN-18-GXL

ENGINE

J808-AG41 BK-18 J808-AG42 BK-18

AG-C6 3E3370

506-CJ68 PU-18 507-CJ70 WH-18 J764-CJ47 BR-18 J854-CJ10 YL-18 447-CJ48 PK-18 709-CJ61 OR-18 G995-CJ72 OR-18 G996-CJ73 PK-18 G997-CJ74 PU-18 G998-CJ75 WH-18 J845-CJ122 PU-18

506-CJ68 PU-18 507-CJ70 WH-18 521-CJ113 YL-14 522-CJ114 WH-14 604-CJ15 OR-16 605-CJ16 YL-16 606-CJ17 GY-16 614-CJ12 PU-16 617-CJ19 BR-16 618-CJ45 YL-16 709-CJ61 OR-18 727-CJ20 GN-16 944-CJ102 OR-18 945-CJ103 BR-18 A307-CJ78 GY-18 A907-CJ120 BU-18 A975-CJ31 BU-18 A982-CJ30 BR-18

R941-CJ27 GY-16 X918-CJ35 PU-18 X919-CJ36 WH-18

200-CJ141 BK-16 150-CJ117 OR-16

A B C

K

CONN 21

200-AG45 BK-18 779-AG46 WH-18

416-CJ9 OR-18 606-CJ17 GY-16 417-CJ11 GY-18 614-CJ12 PU-16 453-CJ13 PK-18 484-CJ14 YL-18 604-CJ15 OR-16 617-CJ19 BR-16 403-CJ90 GN-18 A975-CJ31 BU-18 J814-CJ22 BK-18 618-CJ45 YL-16 C216-CJ32 BK-18 727-CJ20 GN-16 N787-CJ67 BU-18

H19

H20

+24V SIGNAL GROUND

AUTO DIFF LOCK (FRONT)

308-CJ5 YL-16 J809-CJ119 BK-18 A907-CJ120 BU-18 P989-CJ4 GN-18 E455-CJ33 BR-18 X778-CJ34 PU-18 321-CJ7 BR-18

X918-CJ35 PU-18 X919-CJ36 WH-18

OR-18 BU-18 BK-18

1 2

619-AG1 GN-14

CJ-C1 1607689

H19

BU-18 RD-18 WH-18 YL-18 BK-18

BUCKET/TILT POSITION SWITCH 176-5459

AG-C2 3E3364

CABLE AS CAM 251-8248

112-CJ18 PU-4 149-CJ129 PU-16 175-CJ51 RD-14 177-CJ1 RD-8 199-CJ3 RD-16

125-CJ37 OR-8 J766-CJ23 PU-18 R941-CJ27 GY-16

5 4 6 3 1 2

PU-14 GN-14 BR-16 YL-16 BK-14

CONNECTS TO BULKHEAD CONN LOC SH2 C-18

H21

H19

1 2

938H FRONT FRAME

308-CJ5 YL-16 321-CJ7 BR-18 326-CJ133 PU-16 403-CJ90 GN-18 416-CJ9 OR-18 417-CJ11 GY-18 447-CJ48 PK-18 453-CJ13 PK-18 484-CJ14 YL-18

CJ-C7 2253861 A982-CJ30 BR-18 P989-CJ4 GN-18 J765-CJ53 BU-18 403-CJ90 GN-18 A307-CJ78 GY-18

R S T U V W X Y Z

11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31

611-L6 PU-14 617-L7 BR-16

A B C

G485-AG52 BU-18 C216-AG51 BK-18

AT-C15 3E3370 171-AT30 GN-18 C216-AT31 BK-18 E796-AT32 GN-18

200-CJ77 BK-16 200-CJ28 BK-16 200-CJ147 BK-14 200-CJ141 BK-16

CONN 9 CH-C17 2736315

J815-AG28 BK-18

124-AX1 GN-16 103-AX2 YL-16

1 2

PAYLOAD CONTROL SYSTEM (ATCH)

BU-18 BR-18 BU-18 GN-18 GY-18

REAR VIEW CAMERA

C

START AID SOLENOID 239-1134

PE-C1 2451042

GN-18 BR-18 WH-18

ARTICULATION ANGLE SNSR 266-2337

CONN 4

F

J808-AG27 BK-18

AX-C1 1464073

619-L5 GN-14

CONN 22

J764-AG21 BR-18 439-AG18 YL-18 136-AG10 GN-16

611-L6 619-L5 617-L7 605-L4 200-L1

200-L1 BK-14 605-L4 YL-16

AG-C18 1552269

RF-C1 CH-C11 3E3370 1552267 A H704-RF1 PK-18 H704-CH74 PK-18-GXL B 200-CH68 BK-18-GXL 200-RF2 BK-18

CH-C1 2253854 A982-CH32 BR-18-GXL P989-CH11 GN-18-GXL J765-CH36 BU-18-GXL 403-CH43 GN-18-GXL A307-CH41 GY-18-GXL

G485-AG52 G991-AG25 G992-AG26 G993-AG22 G994-AG24

L

AX-C2 3E3364

L-C2 1552273

F766-AG35 WH-18 F766-AG36 WH-18

F766-AG48 WH-18

MOTOR

CONN 17

POWER DISTRIBUTION PANEL

AMBIENT AIR TEMP SENSOR CH-C4 177-0071 1552267 +5 VOLTS OR-18 A T786-CH33 GY-18-GXL GROUND BK-18 B J765-CH35 BU-18-GXL SIGNAL WH-18 C Y772-CH34 GN-18-GXL

709-AG20 OR-18 J764-AG21 BR-18 G993-AG22 GN-18 G994-AG24 GY-18 G991-AG25 BR-18 G992-AG26 BU-18 610-AG58 OR-14 M927-AG53 GN-16

439-AP5 YL-18 124-AP6 GN-16 103-AP7 YL-16

CONN 26

L-C1 1552252

AG-C11 AG-C24 3E3370 1552267 A 138-AG31 GN-18 B 251-AG55 BK-18 C C530-AG13 BU-18

709-AG20 OR-18 761-AG4 GY-18 762-AG23 YL-18 779-AG46 WH-18 976-AG29 OR-18 C216-AG51 BK-18 C529-AG12 GY-18 C530-AG13 BU-18

CJ-C30 1552267 164-CJ62 WH-16 C216-CJ125 BK-18 E929-CJ124 GY-18

CONN 5 VARIABLE PITCH FAN

619-AG1 GN-14 619-AG3 GN-14

TRANSMISSION

BK-18 RD-18 WH-18

200-CJ59 BK-16 200-CJ60 BK-14 308-CJ5 YL-16

125-CJ37 OR-8

GLOW PLUGS BREAKER 171-2205

CH-C26 1552267 A893-CH76 OR-16-GXL 326-CH23 PU-16-GXL

CJ-C2 1552269 1 2

AT-C1 1552269 E901-AT9 GN-18 E900-AT5 WH-18

XMSN PUMP PRESS SNSR AT-C16 221-3412 1552267

1 3

GROUND LEVEL SHUTDOWN SW 301-2979 1 2 3 4

1 2

619-AG14 GN-14

AUTOLUBE PUMP 341-8583 1 2 3 4 5 6 7 8

LH HI LO POSN TURN LAMP1 344-3456

AG-C16 1552267

AG-C10 3E3370 138-AG34 GN-18 251-AG47 BK-18 C529-AG12 GY-18

TORQ CONV OIL TEMP SNSRAT-C14 8T8731 131-0427 RD-18 A +V 709-AT16 OR-18 BK-18 B GROUND J764-AT19 BR-18 C SIGNAL YL-18 763-AT29 BU-18

XMSN PUMP FLOW BYPASS SOL 251-3268 CJ-C31 1552269 1 M893-CJ76 GY-16 2 200-CJ77 BK-16

HOOD ACTUATOR SW 301-2980

E906-AT6 OR-18 E907-AT10 GY-18 E908-AT7 BR-18 E909-AT11 WH-18 J809-AT21 BK-18 J807-AT27 BK-18 J808-AT28 BK-18 709-AT16 OR-18 J764-AT19 BR-18 763-AT29 BU-18 171-AT30 GN-18 C216-AT31 BK-18 E796-AT32 GN-18

J808-AT28 BK-18

1 2

611-AG11 PU-14 611-AG38 PU-14

617-AG32 BR-16 618-AG39 YL-16

AT-C3 2253854 1 G732-AT2 WH-18 2 751-AT3 GN-18 3 754-AT8 BU-18 4 752-AT4 YL-18 5 900-AT13 PU-18 6 755-AT12 OR-18 7 901-AT14 WH-18 8 J764-AT15 BR-18 9 E900-AT5 WH-18 10 E901-AT9 GN-18

751-AT3 GN-18 752-AT4 YL-18 754-AT8 BU-18 755-AT12 OR-18

AT-C9 1552269 E907-AT10 GY-18 E906-AT6 OR-18

611-AG43 PU-14

AP-C1 1464055 136-AP1 GN-18 200-AP2 BK-18 136-AP3 GN-18 A447-AP4 PK-16

CONN 23

610-AG59 OR-14 610-AG60 OR-14

610-AG58 OR-14

AW-C3 1552269 124-AW3 GN-18 103-AW2 YL-18

GROUND + BATTERY SOLENOID

1 2

AG-C9 3E3370 A F766-AG36 WH-18 B 762-AG23 YL-18 C J808-AG41 BK-18

606-AG6 GY-16 606-AG37 GY-16

606-AG16 GY-16

AP-C2 3E3388 1 2 3 4 5 6 7 8

CONN 27

FORWARD HORN 174-7875

1 2 3 4 5 6 7 8 9 10 11 12

251-AG47 BK-18 251-AG55 BK-18

CAMERA 347-1668

175-CJ51 RD-14 199-CJ3 RD-16 200-CJ60 BK-14 397-CJ54 OR-14

GLOWPLUG 5 361-9875

AXLE OIL COOLER CLUTCH 297-1860

FAN BRAKE LOAD BYPASS SOL 251-3268 CJ-C6 1552269 1 U703-CJ52 YL-18 2 H747-CJ56 BR-18

MOTOR LOWER LOWER HOOD GROUND MOTOR RAISE +28V RAISE HOOD

112-CJ18 PU-4

GLOWPLUG RELAY 209-5582 GLOWPLUG 3 361-9875

OR-14 GN-18 BK-14 BU-14 RD-14 WH-18

VIDEO SIG VIDEO GND + 12 VDC FEED GND

1

GLOWPLUG 2 361-9875

CJ-C5 1552272 X918-CJ35 PU-18 J766-CJ23 PU-18 X919-CJ36 WH-18

CJ-C3 3E3364

CH-C20 1552269 513-CH69 OR-14-GXL 522-CH73 WH-14-GXL

GLOWPLUG BUSS BAR 316-9073

GLOWPLUG 1 361-9875

1 2 3 4 5 6

177-CJ1 RD-8

177-CJ1 RD-8

40A

513-CH69 OR-14-GXL 513-CH70 OR-14-GXL 513-CH71 OR-14-GXL

CH-C19 1552269 513-CH70 OR-14-GXL 522-CH72 WH-14-GXL

BK-18 WH-18

HOOD RAISE/LOWER MOTOR CONTROL 149-2612

403-CH43 GN-18-GXL

AC PRESS SW 114-5333

200-AG5 BK-14 200-AG49 BK-16 200-AG45 BK-18 200-AG54 BK-16

M927-AG53 GN-16 N936-AG9 YL-18

900-AT13 PU-18 901-AT14 WH-18

OUTPUT SPEED SNSR TRAILING 196-1185 CJ-C17 1297164

AT-C11 1552269 E909-AT11 WH-18 E908-AT7 BR-18

AT-C4 1552269 752-AT4 YL-18 J808-AT1 BK-18

CL 4 (SPEED 2) SOL 244-3114

1

1 2

1 2

CBL-PP1 BK-00

101-WE1 RD-4

109-CH66 RD-4

AT-C10 1552269 G732-AT2 WH-18 J764-AT15 BR-18

AT-C2 1552269 754-AT8 BU-18 J809-AT21 BK-18

CL 2 (FWD HIGH) SOL 244-3114

MOTOR

CBL-CC1 RD-00

1

MOTOR

507-CJ70 WH-18 200-CJ71 BK-18

200-CV7 BK-16

101-WE1 RD-4

P989-CH11 GN-18-GXL

S1

CJ-C54 7T5957 1 2

MOTOR

RD-16 BU-16

506-CJ68 PU-18 200-CJ69 BK-18

114-AG33 RD-16 138-AG19 GN-18 200-AG8 BK-14 251-AG30 BK-18 322-AG44 GY-16 G485-AG52 BU-18 C529-AG12 GY-18 C530-AG13 BU-18 605-AG15 YL-16 606-AG16 GY-16 611-AG43 PU-14 618-AG39 YL-16 617-AG32 BR-16 619-AG14 GN-14 761-AG4 GY-18 762-AG23 YL-18 779-AG46 WH-18 F766-AG48 WH-18 C216-AG51 BK-18 J808-AG27 BK-18 J815-AG28 BK-18 976-AG29 OR-18 N936-AG9 YL-18

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40

610-AG59 OR-14 200-AG40 BK-14 605-AG15 YL-16 200-AG50 BK-14 611-AG11 PU-14 617-AG32 BR-16 606-AG6 GY-16 619-AG3 GN-14

322-AG44 GY-16 439-AG18 YL-18 605-AG15 YL-16

AG-C1 1010205

T

CBL-MM1 RD-00

CBL-CC1 RD-00

BACKUP ALARM 220-0229

AW-C2 1552264 136-AW6 GN-16 200-AW1 BK-18 136-AW7 GN-16 439-AW4 YL-18 124-AW3 GN-18 103-AW2 YL-18

BK-18 OR-18 BU-18

AG-C4 3E5179

200-AG17 BK-16 200-AG40 BK-14 200-AG50 BK-14

200-AG8 BK-14

CONN 11

CBL-AU2 BK-00 AU-C1 2 1 2672276 AUX START RECEPTACLE

CBL-AU1 RD-00

BLOCK AS 8C-6358

REAR WASHER PUMP 7T-8890

SECONDARY STEERING PRESS SW 313-5104

12V BATTERY 2 263-9574

CBL-AU1 RD-00

403-CH43 GN-18-GXL

138-AG34 GN-18 138-AG31 GN-18

200-AG56 BK-14

CJ-C53 7T5957 1 2

MOTOR

RD-16 BU-16

CV-C1 1552269 727-CV10 GN-16 200-CV7 BK-16

727-CV1 GN-16

RH STOP TAIL TURN LAMP 145-6929

BK-16

C216-CV12 BK-18 C216-CV15 BK-18 C216-CV16 BK-18

200-CJ39 BK-16 200-CJ40 BK-16 200-CJ41 BK-16 200-CJ42 BK-16 200-CJ43 BK-16 321-CJ7 BR-18 397-CJ54 OR-14 398-CJ55 BU-14

CONN 6

FRONT WASHER PUMP 7T-8890

PRIMARY STEERING PRESS SW 313-5104

416-CV11 OR-18 417-CV14 GY-18 453-CV8 PK-18 484-CV13 YL-18

J814-CJ22 BK-18

614-CU6 PU-16 200-CU5 BK-16

138-AG19 GN-18

709-CJ61 OR-18 G995-CJ72 OR-18 G996-CJ73 PK-18 G997-CJ74 PU-18 G998-CJ75 WH-18 J764-CJ47 BR-18 J764-CJ63 BR-18 J814-CJ22 BK-18 J854-CJ10 YL-18

H21 CU-C1 3E3364 614-CU1 PU-16 200-CU2 BK-16

AW-C1 3E3376 136-AW5 GN-16

LIFT POSITION SWITCH 3E-7844

A B C

AG-C19 1552269 114-AG33 RD-16 322-AG44 GY-16

114-AG33 RD-16 136-AG10 GN-16

251-AG30 BK-18

605-CJ16 YL-16 606-CJ17 GY-16 614-CJ12 PU-16 617-CJ19 BR-16 618-CJ45 YL-16 709-CJ61 OR-18 G995-CJ72 OR-18 G996-CJ73 PK-18 G997-CJ74 PU-18 G998-CJ75 WH-18

LH STOP TAIL TURN LAMP 145-6929

AG-C8 1552267 J808-AG42 BK-18 F766-AG35 WH-18 761-AG4 GY-18

200-CJ146 BK-14 200-CJ147 BK-14 229-CJ21 BK-14 229-CJ24 BK-14 321-CJ7 BR-18 447-CJ48 PK-18 604-CJ15 OR-16 605-CJ16 YL-16 606-CJ17 GY-16 614-CJ12 PU-16 617-CJ19 BR-16 618-CJ45 YL-16

200-CJ146 BK-14 200-CJ147 BK-14 229-CJ21 BK-14 229-CJ24 BK-14

604-CJ49 OR-16 604-CJ50 OR-16 604-CJ15 OR-16

CJ-C14 1552269 447-CJ48 PK-18 J764-CJ44 BR-18

BULB 9X-4492

LICENSE PLATE LAMP 1 125-4439

1 2 3 4

CONN 24

709-CR1 OR-18 709-CR2 OR-18 709-CR3 OR-18

TURN

AG-C13 3E3376 1 2 3 4

1

ABBREV

COLOR

RD WH OR YL PK BK GY PU BR GN BU

RED WHITE ORANGE YELLOW PINK BLACK GRAY PURPLE BROWN GREEN BLUE

THIS SCHEMATIC IS FOR THE 938H & IT938H WHEEL LOADER ELECTRICAL SYSTEM VOLUME 1 of 2: ENGINE & CHASSIS MEDIA NUMBER: RENR9764-04 SCHEMATIC PART NUMBER: 264-5848, CHANGE: 02, VERSION: Components are shown installed on a fully operable machine with the key and engine off, transmission shifter in neutral and with parking brake set. Refer to the appropriate Service Manual for Troubleshooting, Specifications and Systems Operations. 4

3

2

1

B

A

Component Identifiers (CID¹) Module Identifier (MID²) Payload Control System (MID No. 074)

Harness And Wire Electrical Schematic Symbols

Electrical System Voltage

0254

Payload Electronic Control Module

0350

Lift Linkage Position Sensor

0364

Head End Lift Cylinder Pressure Sensor

0769

Rod End Lift Cylinder Pressure Sensor

0817

Internal Backup Battery

0820

Keypad Data Link

T

Pressure Symbol

Temperature Symbol

Fuse - A component in an electrical circuit that will open the circuit if too much current flows through it.

Component

0070

Parking Brake Switch

0149

Ride Control Solenoid 2

0168

Electrical System Voltage

0190

Engine Speed Sensor

0248

CAT Data Link

0356

Tilt Dump Solenoid 1

0363

Ride Control Solenoid 1

0367

Ride Control Switch

0368

Transmission Auto/Manual Switch

0596

Implement ECM

0621

Downshift Switch

0622

Upshift Switch

0623

Directional Switch

0631

Transmission Clutch 1 Solenoid

0632

Transmission Clutch 2 Solenoid

0633

Transmission Clutch 3 Solenoid

0634

Transmission Clutch 4 Solenoid

0635

Transmission Clutch 5 Solenoid

0636

Transmission Clutch 6 Solenoid

0638

Starter Solenoid

0650

Harness Code

0671

Transmission Output Speed Sensor

0687

Options ID Code

1521

Part-Throttle Autoshift Selector Switch

Switch (Normally Open): A switch that will close at a specified point (temp, press, etc.). The circle indicates that the component has screw terminals and a wire can be disconnected from it. Switch (Normally Closed): A switch that will open at a specified point (temp, press, etc.). No circle indicates that the wire cannot be disconnected from the component.

FMI No. 0

Component

0001

Cylinder #1 Injector

0002

Cylinder #2 Injector

0003

Cylinder #3 Injector

0004

Cylinder #4 Injector

0005

Cylinder #5 Injector

0006

Cylinder #6 Injector

0041

8 Volt DC Supply

0091

Throttle Position Sensr

0100

Engine Oil Press Sensr

0110

Eng coolant temp sensr

0168

Battery Voltage

0172

Intake Air Temp Sensor

0190

Engine Speed Sensor

0253

Personality Module

0261

Engine Timing Cal

Ground (Wired): This indicates that the component is connected to a grounded wire. The grounded wire is fastened to the machine.

Failure Mode Identifiers (FMI)¹

Engine Control System (MID No. 036) CID

Circuit Breaker Symbol

Flow Symbol

Symbols and Definitions

Electronic Transmission Control System (MID No. 081) CID

Level Symbol

Failure Description Data valid but above normal operational range.

1

Data valid but below normal operational range.

2

Data erratic, intermittent, or incorrect.

3

Voltage above normal or shorted high.

4

Voltage below normal or shorted low.

5

Current below normal or open circuit.

6

Current above normal or grounded circuit.

7

Mechanical system not responding properly.

8

Abnormal frequency, pulse width, or period.

9

Abnormal update.

10

Abnormal rate of change.

11

Failure mode not identifiable.

12

Bad device or component.

13

Out of calibration.

14

Parameter failures.

15

Parameter failures.

16

Parameter not available.

17

Module not responding.

18

Sensor supply fault.

19

Condition not met.

20

Parameter failures.

Ground (Case): This indicates that the component does not have a wire connected to ground. It is grounded by being fastened to the machine. Reed Switch: A switch whose contacts are controlled by a magnet. A magnet closes the contacts of a normally open reed switch; it opens the contacts of a normally closed reed switch.

T

105

Relay (Magnetic Switch): A relay is an electrical component that is activated by electricity. It has a coil that makes an electromagnet when current flows through it. The electromagnet can open or close the switch part of the relay.

120

MAGNETIC LATCH SOLENOID - A magnetic latch solenoid is an electrical component that is activated by electricity and held latched by a permanent magnet. It has two coils (latch and unlatch) that make electromagnet when current flows through them. It also has an internal switch that places the latch coil circuit open at the time the coil latches.

CONN 30

1 2

Deutsch connector: Typical representation of a Deutsch connector. The plug contains all sockets and the receptacle contains all pins.

CONN 33

Harness Connector Serialization Code: The "C" stands for "Connector" and the number indicates which connector in the harness. (C1, C2, C3, .....)

Part Number for Connector Plug

C-C4 AG-C3 130-6795 130-6795

L-C12 3E-5179

AG-C4 111-7898 1

325-AG135 PK-14

5A

Receptacle Pin or Socket Number

Single Wire Connector

123

0268

Programd Param. Fault

0291

Eng Cooling Fan Sol.

0296

Transmission Control

0342

Sec Eng Spd Sensor

0526

Turbo Wastegate Act.

1639

Mach Sec System ECM

1779

Fuel Rail Pres Val Sol

1785

Intake Manifold Pres Sensr

1797

Fuel Rail Pres Sensr

1834

Ignition Key Swtich

Part Number For Connector Recepticle

Socket

Pin

Remote shutdown input

Sure-Seal connector: Typical representation of a Sure-Seal connector. The plug and receptacle contain both pins and sockets. Harness Identification Letter(s): (A, B, C, ..., AA, AB, AC, ...)

Wire, Cable, or Harness Assembly Identification: Includes Harness Identification Letters and Harness Connector Serialization Codes

CONN 29

5 VDC Sensor Supply

IT38H: JNJ1-UP

Harness and Wire Symbols 1 2

0267

938H: MCC1-UP MJC1-UP JKM1-UP LKM1-UP

Solenoid: A solenoid is an electrical component that is activated by electricity. It has a coil that makes an electromagnet when current flows through it. The electromagnet can open or close a valve or move a piece of metal that can do work.

¹The FMI is a diagnostic code that indicates what type of failure has occurred.

0262

938H & IT38H Wheel Loader Electrical System

Sender: A component that is used with a temperature or pressure gauge. The sender measures the temperature or pressure. Its resistance changes to give an indication to the gauge of the temperature or pressure.

9X-1123

Component Part Number

Plug

104

200-L32 BK-14

2

Harness identification code: This example indicates wire 135 in harness "AG".

Fuse (5 Amps)

Ground Connection

Circuit Identification Number

Wire Color

Wire Gauge

Volume 1 of 2: Cab Wiring

(PC) HARNESS - PAYLOAD HARNESS & (PL) HARNESS - PRODUCT LINK HARNESS

© 2011 Caterpillar, All Rights Reserved

Printed in U.S.A.

2246 Glow Plug Start Aid Relay ¹ The CID is a diagnostic code that indicates which circuit is faulty. ² The MID is a diagnostic code that indicates which electronic control module diagnosed the fault.

144 117

114 97

115 CONN 32

148

Event Codes Engine Control Event Code 0194

110

133

0265

User Defined Shutdown Low Engine Oil Pressure

0361

High Engine Coolant Temperature

0362

Engine Overspeed

0396

High Fuel Rail Pressure

0398

Low Fuel Rail Pressure

0441

Idle Elevated to Increase Batt Voltage

0539

High Intake Manifold Air Temperature

1044

High Intake Manifold Pressure

1045

Low Intake Manffold Pressure

142

103 137

158

CONN 14

Coasting in Neutral Warning

0284

Low Brake Accumulator Pressure

0329

Transmission Filter Plugged

0454

Hydraulic Case Drain Filter Plugged

0490

Park Brake On - Not In Neutral

0627

Parking Brake On - Machine In Motion

0861

Clock Manual Alignment Required

0878

High Hydraulic Oil Temp

0879

Hydraulic Tank Oil Filter Plugged

2129

High Front Axle Temp

2130

High Rear Axle Temp

0643

Zero Timer Expired Lift Pressure Change During Weigh

0783

Machine Pitched or Bucket Tilted

0784

Weight too heavy to zero

1027

Lift Too Slow To Weigh

1028

Lift Stopped During Weigh

1042

Excessive Lift Speed Change

1043

Lift Too Jerky During Weigh

2083

Payload Memory Low

2138

Payload Memory Full

100 119

139 102

NOT SHOWN

155

157

116

NOT SHOWN

152

154

128

113

122

NOT SHOWN

C

118

98

134

125

B

131

151 99 149

135 147

140

Event Codes Product Link Control 0861

141

CONN 12

Event Codes Payload Control 0782

108

150

CONN 13

D

130

126

156

CONN 35

Event Codes Machine Control 0049

136

146

145

138

CONN 38

111

CONN 28

NOT SHOWN

NOT SHOWN

107

CONN 37

High Exhaust Temperature

153

121

CONN 36

Condition

0360

109

132

127

124

101

129

112

Manual Clock Alignment Required

CONN 31

VIEW OF AREA (A)

VIEW OF AREA (D)

CONN 15

CONN 34

106

143

VIEW OF AREA (C)

VIEW OF AREA (B) (C) HARNESS - MAIN CAB HARNESS

Component Location (Volume 2) Component

Volume 1 - Resistor, Sender and Solenoid Specifications Part No.

Component Description

Resistance (Ohms)¹

134-2540

Resistor:

Engine CAN Data Link

120 ± 10

148-3551

Solenoid:

Demand Fan Shutoff

32.6 ± 1.6

174-4916

Solenoid:

Differential Lock Actuation

183-5106

Solenoid:

A/C Clutch

239-1134

Solenoid:

Start Aid Rear Differential Lock Front Differential Lock Implement Pilot Shutoff Transmission Clutch #1 (Forward High) Transmission Clutch #1 (Forward Low) Transmission Clutch #1 (Reverse) Transmission Clutch #1 (Speed #1) Transmission Clutch #1 (Speed #2) Transmission Clutch #1 (Speed #3) Ride Control #1 Ride Control #1

241-5895

244-3114

Solenoid:

Solenoid:

244-8686

Solenoid:

266-0298

Sender:

285-5730 297-1860

Solenoid: Solenoid:

Fuel Level

8.7 ± 0.4 @ 25°C (77°F) 17.6 ± 0.6 20

Volume 2 - Off Machine Switch Specification 8.7 ± 0.4

25 ± 5°C (77 ± 41°F) Empty: 240 - 250 Full: 28 - 33

Variable Fan Speed Implement Power Management

5 ± 0.3 @ 25°C (77°F)

Axle Oil Cooler

9.4 ± 5 @ 20°C (68°F)

¹ At room temperature unless otherwise noted.

3E-5464

Function Thermostat

Actuate -1.1 ± 0.8 °C (30 ± 1.4 °F)

Deactuate 2.2 ± 0.8 °C (36 ± 1.4 °F)

Contact Position Normally Closed

Component

Schematic Location

Machine Location

12V Accessory Outlet

D-11

97

Switch - Beacon

J-6

128

G-8

98

Switch - Bucket Fork Select (IT38H)

E-9

129

12V Convertor

D-11

99

Switch - Dimmer

C-3

130

Alarm - Action

J-7

100

Switch - Downshift

I-10

131

Block - Fuse

D-7

101

Switch - Forward Horn

D-3

132

Cluster - Instrument

G-3

102

Switch - Forward Horn (Implement Console)

H-10

133

Connector Location (Volume 2) Connector Number

Schematic Location

Control - A/C Temperature

B-9

103

Switch - Hazard Lamps

J-6

134

CONN 12

Control - Payload

L-14

104

Switch - Heater Mirror

J-7

135

CONN 13

F-17

Control - Product Link

J-10

105

Switch - HID Lamp

J-6

136

CONN 14

H-17

Control - XMSN

G-14

106

Switch - HVAC Blower Fan Speed

C-9

137

CONN 15

I-3

E-2

107

Switch - HVAC Select

C-9

138

CONN 28

J-16

C-11

108

Switch - Hydraulic Metering Unit

I-6

139

CONN 29

J-15

Display - Autolube

Part No.

Machine Location

12V Cigar Lighter

Diodes - Turn Signal

35 ± 0.5

Schematic Location

E-17

Flasher Module

E-2

109

Switch - Implement Lock Out

F-9

140

CONN 30 PCS Printer Connector

H-14

Ground - Cab #1

H-13

110

Switch - Keystart

D-3

141

CONN 31 Autolube Service Connector

C-11

Ground - Cab #2

H-13

111

Switch - Lift Tilt Kickout On/Off

E-9

142

CONN 32

E-11

B-9

112

Switch - Manual Differential Lock

C-11

143

CONN 33

Joystick - FNR

H-10

113

Switch - Parking Brake Limit

D-11

144

CONN 34 Service Tool Connector

Messenger

G-3

114

Switch - Payload Zero

C-9

145

CONN 35

Motor - Air Seat Compressor

E-11

115

Switch - PCS Clear

I-10

146

CONN 36

K-7

CONN 37

L-7

Horn - Quick Coupler

Motor - Blower

I-18

116

Switch - Quick Coupler

D-9

147

Motor - Operator Seat Heater Compressor

E-11

117

Switch - Remote FNR

H-10

148

Motor - Wiper (Front)

H-6

118

Switch - Ride Control

F-9

149

Motor - Wiper (Rear)

L-16

119

Switch - Running Lamp

K-6

150

Radio - Product Link

L-10

120

Switch - Stop Lamp

I-6

151

Resistor - CAN Datalink (Cab)

H-13

121

Switch - Thermostat

J-18

152 153

Resistor - Blower

J-18

122

Switch - Turn Signal

E-2

Resistor - CAN Datalink (Payload)

H-14

123

Switch - Wiper Washer (Front)

H-6

154

Sensor - Brake Pedal (LH)

I-6

124

Switch - Wiper Washer (Rear)

G-6

155

Sensor - Throttle Position

D-3

125

Switch - Worklamp

K-6

156

Shifter - XMSN

H-3

126

Valve - Implement Pilot

J-8

157

Suppressor - Arc

E-2

127

Valve - Water

J-18

158

Related Electrical Service Manuals Title Alternator:

Form Number 235-7132 (65A) Std 235-7133 (80A) Atch

SENR4130

Engine Control System:

KENR5392

J-12

Machine Control System:

RENR8999

H-8

Machine Monitoring System:

RENR6319

K-7

Payload Control System:

SENR6614

CONN 38 E-3 The connectors shown in this chart are for harness to harness connectors. Connectors that join a harness to a component are generally located at or near the component. See the Component Location Chart.

36 Page,

0168

(Dimensions: 48 inches x 35 inches)

Symbols

Component

RENR9764-04 VOL 2 of 2

CID

RENR9764-04 August 2011

17

16

15

14

13

12

11

10

9

8

7

6

H7

AUX 12V POWER CONNECTOR

1 2

L

651-GY1 PK-14 200-GY2 BK-14

H

P

B+

REAR WIPER MOTOR 155-5784

608-CE31 GN-14 200-CE21 BK-14

WH-18 BK-18

GND

MOTOR T

PASS THROUGH STUDS 6V-7357

L

GN-16 BK-16 GY-16 BR-16 OR-16

4 1 2 6 3 5

(Dimensions: 48 inches x 35 inches)

H2 200-CE5 BK-14 200-CE21 BK-14 200-CE22 BK-14 200-CE36 BK-14 200-CE37 BK-14 603-CE13 PK-14

CE-C3 7T5957

LH REAR BEACON 140-3668

603-CE13 PK-14 200-CE5 BK-14

1 2

608-CE16 GN-14 608-CE31 GN-14

LH REAR SOCKET AS. 9R-7941

651-CE12 PK-14 651-CE14 PK-14

200-C310 118-C362 503-C132 505-C123

H8

H8 H9

BK-18-GXL GY-18-GXL BR-18-GXL BU-18-GXL

118-C362 200-C310 200-C315 200-C394 503-C132

GY-18-GXL BK-18-GXL BK-16-GXL BK-14-GXL BR-18-GXL

504-C133 505-C123 592-C395 592-C396 A513-C95

YL-18-GXL BU-18-GXL BU-16-GXL BU-14-GXL PK-16-GXL

138-PC1 GN-16

104-PL29 YL-18

104-PL16 YL-18 104-PL23 YL-18

105-PL27 RD-16

105-PL14 RD-16 105-PL24 RD-16

200-C394 BK-14-GXL 508-C410 PU-18-GXL

201-PL28 BK-16

201-PL15 BK-16 201-PL25 BK-16

509-C424 WH-18-GXL 592-C396 BU-14-GXL A513-C95 PK-16-GXL

403-PL30 GN-18

403-PL17 GN-18 403-PL26 GN-18

944-PC2 OR-18 251-PC4 BK-18

105-PL14 RD-16 201-PL15 BK-16 104-PL16 YL-18 403-PL17 GN-18 N957-PL18 PK-18 N960-PL19 N979-PL20 N970-PL21 N973-PL22

1 2 3 4 5 6 7 8 9 10 11 12

OR-18 GN-18 YL-18 BR-18

N957-PL18 PK-18 N960-PL19 OR-18

945-PC3 BR-18

104-PL23 105-PL24 201-PL25 403-PL26

H7 608-CE3 GN-14 651-CE15 PK-14

200-CE22 BK-14 200-CE36 BK-14 608-CE16 GN-14 651-CE14 PK-14

H2 H2

H4

516-C385 GN-14-GXL 517-C393 BU-14-GXL 522-C156 WH-14-GXL A524-C218 BR-16-GXL

200-HV9 BK-16

A B C

BLOWER RES 204-9921

MOTOR

517-HV3 BU-14 516-HV2 GN-14 515-HV1 OR-14 515-HV11 OR-14

HV-C1 3E3388 515-HV1 OR-14 516-HV2 GN-14 522-HV5 WH-16 A524-HV7 PU-16 200-HV6 BK-14 517-HV3 BU-14 592-HV8 BR-16

BLOWER 275-6706 HV-C40 1552269 BK-12 2 515-HV11 OR-14 RD-12 1 200-HV10 BK-14

1 2 3 4 5 6 7 8

944-C467 OR-18-GXL 945-C468 BR-18-GXL 251-C523 BK-18-GXL C529-C291 GY-18-GXL C530-C292 BU-18-GXL 251-C151 BK-18-GXL 138-C194 GN-16-GXL

CONN 28

102-C130 RD-18-GXL 102-C75 RD-14-GXL 102-C176 RD-14-GXL 102-C197 RD-14-GXL 102-C527 RD-14-GXL

I

104-C382 YL-16-GXL 104-C278 YL-18-GXL 104-C280 YL-16-GXL 105-C279 105-C281 105-C307 105-C469 110-C328 110-C329 112-C415 149-C322 150-C381 164-C217 171-C261 175-C475 177-C183 199-C323

200-C35 BK-16-GXL 200-C195 BK-16-GXL 200-C398 BK-16-GXL 200-C93 BK-14-GXL 200-C264 BK-14-GXL 200-C270 BK-14-GXL 200-C257 BK-16-GXL

H G732-C349 WH-18-GXL 751-C350 GN-18-GXL 754-C351 BU-18-GXL 752-C352 YL-18-GXL 900-C353 PU-18-GXL 755-C354 OR-18-GXL 901-C355 WH-18-GXL J764-C356 BR-18-GXL E900-C203 WH-18-GXL E901-C63 GN-18-GXL

201-C267 201-C268 201-C309 201-C416 201-C417

BK-16-GXL BK-16-GXL BK-16-GXL BK-16-GXL BK-16-GXL

251-C151 251-C520 251-C521 251-C523

BK-18-GXL BK-18-GXL BK-18-GXL BK-18-GXL

308-C199 YL-16-GXL 321-C378 BR-18-GXL 326-C200 PU-16-GXL 403-C420 GN-18-GXL

403-C172 GN-18-GXL 403-C419 GN-18-GXL

416-C55 OR-18-GXL 417-C81 GY-18-GXL CONNECT TO AT-C3 VOL. 1 LOC I-6

CONN 14

E906-C204 OR-18-GXL E907-C205 GY-18-GXL E908-C236 BR-18-GXL E909-C380 WH-18-GXL J809-C186 BK-18-GXL J807-C524 BK-18-GXL J808-C66 BK-18-GXL 709-C25 OR-18-GXL J764-C149 BR-18-GXL 763-C58 BU-18-GXL 171-C261 GN-18-GXL C216-C276 BK-18-GXL E796-C275 GN-18-GXL

439-C242 439-C411 439-C412 439-C413

604-C108 OR-16-GXL

614-C154 PU-16-GXL

CONN 13

506-C340 PU-18-GXL 507-C341 WH-18-GXL J764-C348 BR-18-GXL J854-C342 YL-18-GXL 447-C59 PK-18-GXL 709-C347 OR-18-GXL G995-C76 OR-18-GXL G996-C77 PK-18-GXL G997-C67 PU-18-GXL G998-C73 WH-18-GXL J845-C331 PU-18-GXL 605-C306 YL-16-GXL M739-C471 YL-18-GXL H704-C470 PK-18-GXL

944-C158 OR-18-GXL 945-C159 BR-18-GXL 199-C323 RD-16-GXL 149-C322 PU-16-GXL 326-C200 PU-16-GXL A982-C180 BR-18-GXL J765-C237 BU-18-GXL A307-C238 GY-18-GXL R732-C326 BR-18-GXL H746-C243 YL-18-GXL J808-C90 BK-18-GXL M893-C249 GY-16-GXL 150-C381 OR-16-GXL P739-C201 BU-16-GXL E929-C374 GY-18-GXL 164-C217 WH-16-GXL C495-C528 OR-18-GXL

E

BR-18-GXL BR-18-GXL BR-18-GXL BR-18-GXL BR-18-GXL

J809-C186 BK-18-GXL J809-C107 BK-18-GXL

J809-C330 BK-18-GXL

J814-C282 BK-18-GXL

J814-C336 BK-18-GXL J814-C289 BK-18-GXL

J845-C331 J854-C342 M739-C471 M893-C249 N787-C339 P739-C201 P988-C526 P989-C241 R732-C326 X778-C335

112-C415 PU-4 177-C183 RD-8 521-C327 YL-14-GXL 522-C156 WH-14-GXL 110-C329 RD-14-GXL

PU-18-GXL YL-18-GXL YL-18-GXL GY-16-GXL BU-18-GXL BU-16-GXL OR-18-GXL GN-18-GXL BR-18-GXL PU-18-GXL

Y794-C94 OR-18-GXL Y795-C321 GN-18-GXL

Y795-C226 GN-18-GXL Y795-C271 GN-18-GXL

A513-C95 PK-16-GXL A524-C218 BR-16-GXL C216-C39 BK-18-GXL C216-C404 BK-18-GXL C529-C291 GY-18-GXL C530-C292 BU-18-GXL C542-C423 GN-14-GXL E746-C53 GN-18-GXL G746-C358 WH-18-GXL G787-C406 GN-18-GXL G788-C409 YL-18-GXL G948-C99 BR-18-GXL H728-C359 GN-18-GXL J808-C167 BK-18-GXL J808-C365 BK-18-GXL J815-C245 BK-18-GXL J815-C247 BK-18-GXL P915-C408 PK-18-GXL T971-C515 OR-18-GXL T973-C511 WH-18-GXL T974-C512 BR-18-GXL Y794-C312 OR-18-GXL Y794-C318 OR-18-GXL Y795-C313 GN-18-GXL Y795-C319 GN-18-GXL

REAR VISION 113-CG1 RD-18 200-CG2 BK-16

113-CG3 RD-18 113-CG4 RD-18

CONECTS TO CABLE AS CAM VOL. 1 J-7

H2

H1 H1

651-J1 PK-14 200-J2 BK-14

651-CE14 PK-14 200-CE36 BK-14 PASS THROUGH STUDS 6V-7357

WH-18 BK-18

A513-C95 PK-16-GXL A524-C218 BR-16-GXL C216-C39 BK-18-GXL C216-C404 BK-18-GXL C529-C291 GY-18-GXL C530-C292 BU-18-GXL C542-C423 GN-14-GXL E746-C53 GN-18-GXL G746-C358 WH-18-GXL G787-C406 GN-18-GXL G788-C409 YL-18-GXL G948-C99 BR-18-GXL H728-C359 GN-18-GXL J808-C167 BK-18-GXL J808-C365 BK-18-GXL J815-C245 BK-18-GXL J815-C247 BK-18-GXL P915-C408 PK-18-GXL T971-C515 OR-18-GXL T973-C511 WH-18-GXL T974-C512 BR-18-GXL Y794-C312 OR-18-GXL Y794-C318 OR-18-GXL Y795-C313 GN-18-GXL Y795-C319 GN-18-GXL

H1

608-CE16 GN-14 200-CE22 BK-14

LH RR CAB FLOOD 109-7041

251-PC13 251-PC12 251-PC16 251-PC14

Y795-PL33 GN-18

PK-18 OR-18 YL-18 BR-18 GN-18

Y794-PL34 OR-18 105-PL24 RD-16 403-PL26 GN-18

BK-18 BK-18 BK-18 BK-18 T971-PC11 OR-18

251-PC4 BK-18 944-PC2 OR-18 945-PC3 BR-18 C529-PC6 GY-18 C530-PC7 BU-18

201-PL25 BK-16

P769-PC23 YL-18 C529-PC6 GY-18

T971-PC11 OR-18 T973-PC9 WH-18 T974-PC10 BR-18

104-PL23 YL-18

C530-PC7 BU-18

200-C426 BK-14-GXL 200-C264 BK-14-GXL

592-C126 BU-16-GXL

C-C111 3E3370

P769-PC23 YL-18

YL-18 BR-18 BK-18

201-C267 BK-16-GXL J2

C216-C404 BK-18-GXL

202-C10 BK-14-GXL

CAB GND 2

H5

RS-232 PORT 1 RXD RS-232 PORT 1 DTR

251-C65 BK-18-GXL 251-C520 BK-18-GXL

Y787-PC19 OR-18 Y788-PC21 GN-18

CAB GND 138-PC8 GN-18 251-PC16 BK-18 Y787-PC20 OR-18 Y788-PC22 GN-18 P769-PC23 YL-18

H4

PCS PRINTER

CONN 30

127-C246 OR-14-GXL 130-C357 RD-16-GXL 134-C250 YL-14-GXL 141-C377 PK-16-GXL 147-C308 RD-16-GXL 164-C265 WH-16-GXL 200-C28 BK-14-GXL 200-C93 BK-14-GXL 200-C257 BK-16-GXL 200-C264 BK-14-GXL

RS-232 PORT 1 DCD RS-232 PO

H6

H5

XMSN ECM A4:M1 304-5687

BACKUP ALARM BTRY- (1)

CAT DATA LINK XMSN OIL TEMP BTRY- (2) RH BRAKE PEDAL

FUEL LEVEL SENDER HYD TEMP SENDER BTRY+ (1) HMU 2-4 AUTO 4 AUTO/MANUAL SW - MANUAL HMU 1-4 AUTO 1-4

HMU HMU HMU 3 HMU 4

C216-C52 BK-18-GXL C216-C221 BK-18-GXL

XMSN ECM GND

KEYSWITCH ON XMSN OUTPUT SP SENSOR (A) + XMSN OUTPUT SP SENSOR (A) XMSN OUTPUT SP SENSOR (B) + XMSN OUTPUT SP SENSOR (B) XMSN INTER. SPEED SNSR (A) + XMSN INTER. SPEED SNSR (A) XMSN INTER. SPEED SNSR (B) + XMSN INTER. SPEED SNSR (B) CAT DATA LINK +

BTRY+ (2) 1 OR UPSHIFT SW(N/C) 2 OR UPSHIFT SW(N/O) OR DOWNSHIFT SW(N/C) OR DOWNSHIFT SW(N/O) 8V SENSOR SUPPLY 8V SENSOR RET

BTRY+ (3) CLUTCH 6 (SPEED1) CLUTCH 5 (SPEED3) RET FOR SP CLUTCHES #1-3 CLUTCH 4 (SPEED2) IMPL PWR MGMT SOL REAR AXLE OIL TEMP SENDER SOLENOID RETURN BTRY- (3) DIFF LOCK ACT. SOL FRONT DIFF LOCK SOL RETURN FOR FORWARD RR DIFF LOCK SOL CLUTCH 2 (FORWARD HIGH) IMPL POD DOWN SHIFT N/O XMSN OIL FILTER BYPASS SW CLUTCH 3 (REVERSE) CLUTCH 1 (FWD LOW) LIFT/TILT DETENT SOL DEMAND FAN SOL DRIVETRAIN SWG RETURN KEYSWITCH START AXLE COOLER RELAY AUX/FLOAT DETENT SOL RIDE CONT/AXLE COOLER RET RIDE CONT SOL ON/OFF #1 RIDE CONT SOL ON/OFF #2 START RELAY START RELAY/BACKUP ALM RET SEC STEER INTERMEDIATE RELAY HEATED MIRROR RELAY COLD START RELAY ALTERNATOR R TERMINAL LEFT FRONT WHEEL SPEED A LEFT FRONT WHEEL SPEED B LEFT PEDAL POSITION SENSOR

DIRECTION SW (NEUTRAL) RIGHT FRONT WHEEL SPEED B RIGHT FRONT WHEEL SPEED A RIGHT REAR WHEEL SPEED B RIGHT REAR WHEEL SPEED A DIRECTION SW (REVERSE) HEATED MIRROR SWITCH XMSN PUMP PRESSURE SNSR LEFT REAR WHEEL SPEED A LEFT REAR WHEEL SPEED B PRIM. STRG PRESSURE SW (N/O) PRIM. STRG PRESSURE SW (N/C) IMPL DETENT ENABLE SW SEC STEERING PRESS SW (N/O) HYD FILTER BYPASS SW RIDE CONTROL SW (AUTO) RIDE CONTROL SW (ON) LOW BRAKE OIL PRESSURE SW ARTICULATION ANGLE SNSR DIRECTION SW (FORWARD) FRONT AXLE OIL TEMP SW TORQUE CONVERTER TEMP SNSR PARK BRAKE SW-ENGAGED PARK BRAKE SW-DISENGAGED DIFF LOCK SW (N/O) REMOTE FNR INPUT 6 REMOTE FNR INPUT 4 REMOTE FNR INPUT 1 SEC STEERING PRESS SW (N/C) CASE DRAIN OIL FILTER SW

CAN DATA LINK + CAN DATA LINK -

C-C22 J1 1471445 1 150-C3 OR-16-GXL 2 E900-C203 WH-18-GXL 3 E901-C63 GN-18-GXL 4 E906-C204 OR-18-GXL 5 E907-C205 GY-18-GXL 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 56 57 58 59 60 61 62 63 64 65 66 67 68 69 70 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 56 57 58 59 60 61 62 63 64 65 66 67 68 69 70

200-C254 BK-14-GXL 200-C428 BK-14-GXL

200-C255 BK-12-GXL

200-C426 BK-14-GXL 200-C427 BK-14-GXL

201-C309 201-C417 410-C240 506-C340 507-C341 518-C190 537-C191 538-C192 592-C118 592-C126

BK-16-GXL BK-16-GXL WH-16-GXL PU-18-GXL WH-18-GXL OR-16-GXL GN-16-GXL BR-16-GXL BU-16-GXL BU-16-GXL

G787-C406 GN-18-GXL

G787-C79 GN-18-GXL G787-C489 GN-18-GXL

G788-C409 YL-18-GXL

G788-C87 YL-18-GXL G788-C493 YL-18-GXL

P915-C408 PK-18-GXL

P915-C89 PK-18-GXL P915-C491 PK-18-GXL

503-C132 BR-18-GXL 504-C133 YL-18-GXL 505-C123 BU-18-GXL

1 3

2 4

503-C132 BR-18-GXL 504-C133 YL-18-GXL 505-C123 BU-18-GXL

DOWNSHIFT SW 263-1493

603-C196 PK-14-GXL 651-C27 PK-14-GXL A629-C47 BU-14-GXL

944-C157 OR-18-GXL 321-C378 BR-18-GXL 202-C62 BK-14-GXL E908-C236 BR-18-GXL E909-C380 WH-18-GXL

945-C160 BR-18-GXL G732-C349 WH-18-GXL 202-C61 BK-14-GXL 604-C198 OR-16-GXL

447-C59 PK-18-GXL R732-C326 BR-18-GXL 170-C64 RD-14-GXL

150-C3 OR-16-GXL 321-C378 BR-18-GXL 403-C419 GN-18-GXL 416-C55 OR-18-GXL 417-C81 GY-18-GXL 447-C59 PK-18-GXL 453-C54 PK-18-GXL 484-C82 YL-18-GXL 604-C198 OR-16-GXL 751-C350 GN-18-GXL 752-C352 YL-18-GXL 754-C351 BU-18-GXL 755-C354 OR-18-GXL 763-C58 BU-18-GXL 900-C353 PU-18-GXL 901-C355 WH-18-GXL 944-C157 OR-18-GXL 945-C160 BR-18-GXL 973-C51 BR-18-GXL 977-C40 YL-18-GXL A907-C332 BU-18-GXL A975-C337 BU-18-GXL C495-C528 OR-18-GXL E455-C334 BR-18-GXL E746-C53 GN-18-GXL E796-C275 GN-18-GXL E900-C203 WH-18-GXL E901-C63 GN-18-GXL E906-C204 OR-18-GXL E907-C205 GY-18-GXL E908-C236 BR-18-GXL E909-C380 WH-18-GXL E929-C374 GY-18-GXL G732-C349 WH-18-GXL

977-C40 YL-18-GXL 973-C51 BR-18-GXL H728-C359 GN-18-GXL

170-C72 RD-14-GXL G768-C187 GN-18-GXL G760-C42 WH-18-GXL G761-C43 YL-18-GXL G762-C44 BR-18-GXL 709-C346 OR-18-GXL J764-C345 BR-18-GXL 170-C68 RD-14-GXL 901-C355 WH-18-GXL 900-C353 PU-18-GXL J807-C2 BK-18-GXL 755-C354 OR-18-GXL P988-C526 OR-18-GXL J854-C342 YL-18-GXL J808-C167 BK-18-GXL 202-C60 BK-14-GXL A907-C332 BU-18-GXL A975-C337 BU-18-GXL J809-C330 BK-18-GXL J845-C331 PU-18-GXL 754-C351 BU-18-GXL E746-C53 GN-18-GXL E455-C334 BR-18-GXL 751-C350 GN-18-GXL 752-C352 YL-18-GXL F766-C379 WH-18-GXL H746-C243 YL-18-GXL

G746-C358 WH-18-GXL G787-C406 GN-18-GXL G788-C409 YL-18-GXL G948-C99 BR-18-GXL G995-C76 OR-18-GXL G996-C77 PK-18-GXL G997-C67 PU-18-GXL G998-C73 WH-18-GXL H728-C359 GN-18-GXL H746-C243 YL-18-GXL J807-C2 BK-18-GXL J808-C167 BK-18-GXL J809-C330 BK-18-GXL J814-C336 BK-18-GXL J845-C331 PU-18-GXL J854-C342 YL-18-GXL N787-C339 BU-18-GXL P915-C408 PK-18-GXL P988-C526 OR-18-GXL R732-C326 BR-18-GXL X778-C335 PU-18-GXL

C216-C52 BK-18-GXL 307-C57 OR-16-GXL J887-C202 PU-18-GXL G948-C99 BR-18-GXL J815-C206 BK-18-GXL 976-C368 OR-18-GXL N936-C367 YL-18-GXL 306-C333 GN-18-GXL J814-C336 BK-18-GXL 728-C78 BU-18-GXL C543-C80 GY-16-GXL A764-C248 GN-18-GXL 403-C419 GN-18-GXL G993-C370 GN-18-GXL G994-C371 GY-18-GXL G746-C358 WH-18-GXL

150-C3 OR-16-GXL 321-C378 BR-18-GXL 403-C419 GN-18-GXL 416-C55 OR-18-GXL 417-C81 GY-18-GXL 447-C59 PK-18-GXL 453-C54 PK-18-GXL 484-C82 YL-18-GXL 604-C198 OR-16-GXL 751-C350 GN-18-GXL 752-C352 YL-18-GXL 754-C351 BU-18-GXL 755-C354 OR-18-GXL 763-C58 BU-18-GXL 900-C353 PU-18-GXL 901-C355 WH-18-GXL 944-C157 OR-18-GXL 945-C160 BR-18-GXL 973-C51 BR-18-GXL 977-C40 YL-18-GXL A907-C332 BU-18-GXL A975-C337 BU-18-GXL C495-C528 OR-18-GXL E455-C334 BR-18-GXL E746-C53 GN-18-GXL E796-C275 GN-18-GXL E900-C203 WH-18-GXL E901-C63 GN-18-GXL E906-C204 OR-18-GXL E907-C205 GY-18-GXL E908-C236 BR-18-GXL E909-C380 WH-18-GXL E929-C374 GY-18-GXL G732-C349 WH-18-GXL

G763-C45 PU-18-GXL G992-C373 BU-18-GXL G991-C372 BR-18-GXL G996-C77 PK-18-GXL G995-C76 OR-18-GXL G755-C188 GY-18-GXL C583-C29 GN-18-GXL

E796-C275 GN-18-GXL G997-C67 PU-18-GXL G998-C73 WH-18-GXL 417-C81 484-C82 700-C85 453-C54

GY-18-GXL YL-18-GXL PK-18-GXL PK-18-GXL

N787-C339 BU-18-GXL G767-C24 WH-18-GXL G766-C414 GN-18-GXL X778-C335 PU-18-GXL E929-C374 GY-18-GXL G750-C46 BU-18-GXL G485-C288 BU-18-GXL 763-C58 BU-18-GXL G764-C338 PK-18-GXL 419-C163 YL-18-GXL A900-C421 OR-18-GXL

G746-C358 WH-18-GXL G787-C406 GN-18-GXL G788-C409 YL-18-GXL G948-C99 BR-18-GXL G995-C76 OR-18-GXL G996-C77 PK-18-GXL G997-C67 PU-18-GXL G998-C73 WH-18-GXL H728-C359 GN-18-GXL H746-C243 YL-18-GXL J807-C2 BK-18-GXL J808-C167 BK-18-GXL J809-C330 BK-18-GXL J814-C336 BK-18-GXL J845-C331 PU-18-GXL J854-C342 YL-18-GXL N787-C339 BU-18-GXL P915-C408 PK-18-GXL P988-C526 OR-18-GXL R732-C326 BR-18-GXL X778-C335 PU-18-GXL

G788-C409 YL-18-GXL P915-C408 PK-18-GXL G787-C406 GN-18-GXL 416-C55 OR-18-GXL C495-C528 OR-18-GXL

Y794-C227 OR-18-GXL Y795-C228 GN-18-GXL

102-C527 RD-14-GXL 104-C280 YL-16-GXL 105-C281 RD-16-GXL 110-C328 RD-14-GXL 110-C329 RD-14-GXL 112-C415 PU-4 118-C131 GY-14-GXL 124-C88 GN-16-GXL 127-C246 OR-14-GXL 130-C357 RD-16-GXL 134-C250 YL-14-GXL 141-C377 PK-16-GXL 149-C322 PU-16-GXL 171-C261 GN-18-GXL 175-C475 RD-14-GXL 177-C183 RD-8 199-C323 RD-16-GXL 200-C28 BK-14-GXL 200-C35 BK-16-GXL 200-C92 BK-14-GXL 200-C255 BK-12-GXL 200-C270 BK-14-GXL 200-C392 BK-14-GXL 200-C398 BK-16-GXL 201-C267 BK-16-GXL 251-C520 BK-18-GXL 439-C411 YL-18-GXL 439-C412 YL-18-GXL 439-C413 YL-18-GXL 515-C384 GY-14-GXL 516-C385 GN-14-GXL 517-C393 BU-14-GXL 521-C327 YL-14-GXL 592-C100 BU-16-GXL 592-C115 BU-16-GXL 608-C263 GN-14-GXL 614-C34 PU-18-GXL 614-C239 PU-18-GXL 614-C397 PU-18-GXL 615-C259 YL-14-GXL 646-C253 OR-16-GXL 647-C251 GN-16-GXL 699-C456 PU-18-GXL 709-C347 OR-18-GXL 727-C16 GN-16-GXL 961-C101 BR-18-GXL A513-C95 PK-16-GXL A524-C218 BR-16-GXL C216-C39 BK-18-GXL C216-C276 BK-18-GXL C216-C360 BK-18-GXL C216-C404 BK-18-GXL C542-C423 GN-14-GXL H704-C470 PK-18-GXL J764-C348 BR-18-GXL J764-C356 BR-18-GXL J814-C289 BK-18-GXL M739-C471 YL-18-GXL M893-C249 GY-16-GXL P739-C201 BU-16-GXL P989-C241 GN-18-GXL T973-C511 WH-18-GXL T974-C512 BR-18-GXL Y794-C312 OR-18-GXL Y795-C313 GN-18-GXL

108-C1 BU-14-GXL 115-C125 PK-16-GXL 120-C124 RD-16-GXL 136-C225 GN-16-GXL 157-C324 RD-16-GXL 108-C1 BU-14-GXL 115-C125 PK-16-GXL 120-C124 RD-16-GXL 136-C225 GN-16-GXL 157-C324 RD-16-GXL

320-C287 OR-16-GXL 200-C494 BK-16-GXL

1 3

2 4

J808-C96 BK-18-GXL J808-C97 BK-18-GXL

C-C21 1552264 J815-C245 BK-18-GXL G948-C164 BR-18-GXL 961-C101 BR-18-GXL J808-C96 BK-18-GXL J808-C97 BK-18-GXL 761-C4 GY-18-GXL G948-C150 BR-18-GXL J815-C247 BK-18-GXL

200-C441 BK-18-GXL

4 5 3 6 2 7 1 8

102-C429 RD-14-GXL 699-C456 PU-18-GXL

RD RD

1 2 3 4 5 6 7 8 9 10

WORKLIGHT SW 251-1195

1 2 3 4 5 6 7 8 9 10

RUNNING LAMP SW 251-2031

200-C442 BK-18-GXL

C-C95 1552269 410-C240 WH-16-GXL 201-C417 BK-16-GXL

CAN DATALINK RESISTOR CAB 134-2540

102-C176 RD-14-GXL 102-C197 RD-14-GXL 118-C376 GY-14-GXL 127-C246 OR-14-GXL 130-C357 RD-16-GXL 134-C250 YL-14-GXL 141-C377 PK-16-GXL 164-C265 WH-16-GXL 200-C93 BK-14-GXL 200-C257 BK-16-GXL 201-C417 BK-16-GXL 410-C240 WH-16-GXL 503-C132 BR-18-GXL 504-C133 YL-18-GXL 505-C123 BU-18-GXL 506-C340 PU-18-GXL 507-C341 WH-18-GXL 518-C190 OR-16-GXL 537-C191 GN-16-GXL 538-C192 BR-16-GXL 592-C118 BU-16-GXL

102-C429 RD-14-GXL 102-C430 RD-14-GXL

102-C197 518-C190 614-C461 200-C444 200-C443 538-C454

118-C432 118-C431 118-C434 118-C435 118-C433

614-C455 PU-18-GXL 200-C440 BK-18-GXL

IDENT

200-C438 200-C439 200-C440 200-C441 200-C442 200-C443 200-C444

BACKLIGHT 8 115-1748

1

2

1 2 3 4 5 6

BK-18-GXL BK-18-GXL BK-18-GXL BK-18-GXL BK-18-GXL BK-18-GXL BK-18-GXL

BK-16 BK-16 BK-16 BK-16

114-C283 RD-16-GXL 138-C284 GN-16-GXL 200-C364 BK-14-GXL 251-C41 BK-18-GXL 322-C14 GY-16-GXL G485-C288 BU-18-GXL C529-C291 GY-18-GXL C530-C292 BU-18-GXL 605-C293 YL-18-GXL 606-C294 GY-18-GXL 611-C295 PU-14-GXL 618-C301 YL-16-GXL 617-C155 BR-16-GXL 619-C297 GN-14-GXL 761-C4 GY-18-GXL 762-C50 YL-18-GXL 779-C139 WH-16-GXL F766-C379 WH-18-GXL C216-C244 BK-18-GXL J808-C365 BK-18-GXL J815-C366 BK-18-GXL 976-C368 OR-18-GXL N936-C367 YL-18-GXL

MANUAL

2

2-4

1

3 4

1-4

HMU SW 185-6335

164-C265 WH-16-GXL C216-C465 BK-18-GXL G746-C358 WH-18-GXL

RD-18 BK-18

+V RETURN SIGNAL

YL-18

LH BRAKE PEDAL SENSOR 269-1982

COM

C-C88 T-C1 3E3364 1552269 1 102-T1 RD-16 130-C357 RD-16-GXL 2 604-T2 OR-16 604-C193 OR-16-GXL

NC

500-C450 BR-18-GXL 501-C451 GN-18-GXL 502-C452 OR-18-GXL 503-C132 504-C133 505-C123 506-C340 507-C341 518-C190 537-C191

A B C D E F G H J

592-C118 603-C196 604-C193 610-C127

200-C447 118-C433 500-C450 502-C452

614-C455 PU-18-GXL 614-C17 PU-18-GXL 614-C457 PU-18-GXL 614-C460 614-C462 614-C461 614-C459 614-C463

118-C432 118-C434 200-C439 502-C452 501-C451 500-C450 506-C340

PU-18-GXL PU-18-GXL PU-18-GXL PU-18-GXL PU-18-GXL

646-C253 OR-16-GXL 647-C251 GN-16-GXL 651-C27 PK-14-GXL 699-C456 PU-18-GXL 973-C51 BR-18-GXL 977-C40 YL-18-GXL A629-C47 BU-14-GXL

1 2 3 4 5 6 7 8 9 10 11 12

MOTOR T

BK-16 GY-16 BR-16 OR-16

B+

H

439-C242 YL-18-GXL 136-C185 GN-16-GXL

FRONT WIPER MOTOR 155-5783

P

C-C91 1552264 GY-14-GXL GY-14-GXL BK-18-GXL OR-18-GXL GN-18-GXL BR-18-GXL PU-18-GXL

C216-C464 BK-18-GXL C216-C465 BK-18-GXL

2

1 2 3 4 5 6 7 8

118-C435 118-C431 200-C449 505-C123 504-C133 503-C132 507-C341

G746-C358 WH-18-GXL H728-C359 GN-18-GXL

C-C93 1552264 GY-14-GXL GY-14-GXL BK-18-GXL BU-18-GXL YL-18-GXL BR-18-GXL WH-18-GXL

C-C57 1552273 164-C290 WH-16-GXL C216-C320 BK-18-GXL

BACKLIGHT 3 115-1748

1

C-C92 1135183 614-C463 PU-18-GXL 200-C448 BK-18-GXL

C216-C39 BK-18-GXL

GND

WIPER B+ WASHER B+ GROUND HIGH LOW PARK WASH

RD-16 RD-16 BK-16 WH-16 YL-16 BU-16 BR-16

2

H 1 2 3 4 5 6 7 8

102-C75 RD-14-GXL 104-C382 YL-16-GXL 105-C307 RD-16-GXL 114-C283 RD-16-GXL 136-C185 GN-16-GXL

L

REAR WIPER SW (ATCH) 275-7741

B B

RD-16 RD-16 WH-16 YL-16 BU-16 BR-16

RD-16 RD-16 BK-16 WH-16 YL-16 BU-16 BR-16

RR WIPER WASHER SW 112-6174 P W

WIPER B+ WASHER B+ GROUND HIGH LOW PARK WASH

138-C9 GN-16-GXL 138-C194 GN-16-GXL

138-C284 GN-16-GXL

147-C214 RD-16-GXL 147-C308 RD-16-GXL

147-C215 RD-16-GXL 147-C216 RD-16-GXL

150-C3 OR-16-GXL 150-C212 OR-16-GXL 150-C381 OR-16-GXL

150-C211 OR-16-GXL 150-C210 OR-16-GXL

164-C37 WH-16-GXL 164-C217 WH-16-GXL 164-C265 WH-16-GXL

164-C290 WH-16-GXL

200-C169 BK-18-GXL 200-C171 BK-18-GXL 200-C364 BK-14-GXL

12V CIGAR LIGHTER1 198-6570 HEATER ELEMENT 198-6571

1 2

201-C119 BK-16-GXL 201-C116 BK-16-GXL 201-C168 BK-16-GXL

201-C416 BK-16-GXL 251-C65 BK-18-GXL 251-C522 BK-18-GXL

102-C527 RD-14-GXL 104-C280 YL-16-GXL 105-C281 RD-16-GXL 108-C1 BU-14-GXL 110-C328 RD-14-GXL 110-C329 RD-14-GXL 112-C415 PU-4 115-C125 PK-16-GXL 118-C131 GY-14-GXL 120-C124 RD-16-GXL 124-C88 GN-16-GXL 127-C246 OR-14-GXL 130-C357 RD-16-GXL 134-C250 YL-14-GXL 136-C225 GN-16-GXL 141-C377 PK-16-GXL 149-C322 PU-16-GXL 157-C324 RD-16-GXL 170-C64 RD-14-GXL 170-C68 RD-14-GXL 170-C72 RD-14-GXL 171-C261 GN-18-GXL 175-C475 RD-14-GXL 177-C183 RD-8 199-C323 RD-16-GXL

251-C41 BK-18-GXL

320-C285 OR-16-GXL 320-C287 OR-16-GXL 320-C529 OR-16-GXL

H16 H14 112-C415 PU-4

M927-C170 GN-16-GXL 168-C173 GN-16-GXL IMPL LOCK OUT SW 284-3623

700-C85 PK-18-GXL H766-C86 YL-18-GXL 614-C397 PU-18-GXL 200-C35 BK-16-GXL 200-C398 BK-16-GXL 614-C34 PU-18-GXL

200-C35 BK-16-GXL 200-C256 BK-16-GXL 200-C398 BK-16-GXL 306-C333 GN-18-GXL 515-C384 GY-14-GXL 516-C385 GN-14-GXL 517-C393 BU-14-GXL 521-C327 YL-14-GXL 608-C263 GN-14-GXL 614-C34 PU-18-GXL 614-C239 PU-18-GXL 614-C397 PU-18-GXL 615-C259 YL-14-GXL 646-C253 OR-16-GXL 647-C251 GN-16-GXL 699-C456 PU-18-GXL 700-C85 PK-18-GXL 727-C16 GN-16-GXL 728-C78 BU-18-GXL 961-C101 BR-18-GXL A524-C218 BR-16-GXL A764-C248 GN-18-GXL C216-C222 BK-18-GXL C542-C423 GN-14-GXL C543-C80 GY-16-GXL C583-C29 GN-18-GXL G766-C414 GN-18-GXL G767-C24 WH-18-GXL H704-C470 PK-18-GXL J814-C289 BK-18-GXL J887-C202 PU-18-GXL M739-C471 YL-18-GXL M893-C249 GY-16-GXL P739-C201 BU-16-GXL P989-C241 GN-18-GXL T973-C511 WH-18-GXL T974-C512 BR-18-GXL

ON OFF

RIDE CONTROL SW 236-4612

HEATED MIR SW 236-4630

C-C7 1552269 108-C1 BU-14-GXL 200-C83 BK-14-GXL

AJ-C1 3E3364

1 2

MOTOR

RD-16 BK-16

1 2 3 4 5 6 7 8 9 10

AUTO

619-FF1 OR-14-GXL

OPERATOR SEAT HEATER COMPRESSOR 257-9838

MOTOR

614-C19 200-C22 200-C23 614-C20

C-C61 2234778 C216-C7 BK-18-GXL C583-C29 GN-18-GXL

614-C31 PU-18-GXL 200-C266 BK-18-GXL 200-C30 BK-18-GXL C542-C425 GN-16-GXL

C-C34 2234778 762-C50 YL-18-GXL 961-C101 BR-18-GXL 964-C182 BU-18-GXL

1 2 3 4 5 6 7 8 9 10

BKT FORK SEL SW (IT38) 236-4625 NOTE: ADD JUMPER (HARN: 283-4960) TO PIN 1 (762-YL) AND PIN 2 (961-BR) ON MACHINES NOT EQUIPPED WITH BUCKET FORK SEL SW. (C-C34)

614-C105 200-C112 200-C113 614-C114

HEATER COMPRESSOR (SEAT) 619-KK1 OR-14-GXL

200-C28 BK-14-GXL 200-C92 BK-14-GXL 200-C255 BK-12-GXL 200-C270 BK-14-GXL 200-C392 BK-14-GXL 201-C267 BK-16-GXL 251-C520 BK-18-GXL C216-C39 BK-18-GXL C216-C276 BK-18-GXL C216-C360 BK-18-GXL C216-C404 BK-18-GXL 200-C28 BK-14-GXL 200-C92 BK-14-GXL 200-C255 BK-12-GXL 200-C270 BK-14-GXL 200-C392 BK-14-GXL 201-C267 BK-16-GXL 251-C520 BK-18-GXL C216-C39 BK-18-GXL C216-C276 BK-18-GXL C216-C360 BK-18-GXL C216-C404 BK-18-GXL 108-C1 BU-14-GXL 115-C125 PK-16-GXL 120-C124 RD-16-GXL 136-C225 GN-16-GXL 157-C324 RD-16-GXL

120-C124 115-C125 200-C120 A513-C95 592-C115 200-C121

C-C11 1552273 RD-16-GXL PK-16-GXL BK-16-GXL PK-16-GXL BU-16-GXL BK-16-GXL

1 2 3 4 5 6

+24 V BATTERY IN +24 V SWITCHED IN GROUND +12 V MEMORY OUT +12 V SWITCHED OUT GROUND

C-C9 1237615 1 592-C100 BU-16-GXL 2 200-C122 BK-16-GXL

LFT TLT KOUT ON OFF SW 236-4624

12V CONVERTOR 209-0381

NOTE: ADD JUMPER (HARN: 283-4960) TO PIN 1 (H766-YL) AND PIN 2 (C216-BK) ON MACHINES NOT EQUIPPED WITH LIFT TILT KOUT SET SW (C-C28)

12 VOLT ACCESSORY OUTLET 117-2311

614-C33 PU-18-GXL 200-C36 BK-18-GXL

C-C32 2234778

1 2 3 4 5 6 7 8 9 10

QCPLR SW 280-4244

168-C375 GN-16-GXL 779-C139 WH-16-GXL 168-C137 GN-16-GXL P976-C305 BR-16-GXL 614-C134 PU-18-GXL 200-C135 BK-18-GXL

C216-C129 BK-18-GXL HIGH MED

419-C163 YL-18-GXL G764-C338 PK-18-GXL

BK-14-GXL BK-14-GXL BK-14-GXL BK-14-GXL

419-C163 YL-18-GXL 439-C411 YL-18-GXL 439-C412 YL-18-GXL 439-C413 YL-18-GXL 592-C100 BU-16-GXL 592-C115 BU-16-GXL A513-C95 PK-16-GXL A900-C421 OR-18-GXL C216-C129 BK-18-GXL C216-C422 BK-18-GXL G764-C338 PK-18-GXL

C-C67 1552269 C216-C422 BK-18-GXL A900-C421 OR-18-GXL

HVAC BLOWER FAN SP SW 236-4611

567-C387 515-C384 614-C388 200-C390 200-C391 614-C389

WH-14-GXL GY-14-GXL PU-18-GXL BK-18-GXL BK-18-GXL PU-18-GXL

200-C142 200-C143 200-C147 200-C390 200-C391 200-C135 200-C140

124-C13 GN-14-GXL 124-C88 GN-16-GXL 168-C138 GN-16-GXL

BK-18-GXL BK-18-GXL BK-18-GXL BK-18-GXL BK-18-GXL BK-18-GXL BK-16-GXL

200-C30 BK-18-GXL 200-C266 BK-18-GXL 200-C509 BK-18-GXL 200-C510 BK-18-GXL 200-C22 BK-18-GXL 200-C23 BK-18-GXL

HEAT

HVAC SELECT SW 236-4610

A/C

A B C

124-C162 521-C327 614-C145 200-C142 200-C143 614-C144

110-C49 RD-12-GXL 136-C185 GN-16-GXL 200-C169 BK-18-GXL 200-C171 BK-18-GXL

200-C84 BK-16-GXL 200-C153 BK-16-GXL

136-C185 GN-16-GXL 200-C169 BK-18-GXL 200-C171 BK-18-GXL

124-C13 GN-14-GXL 124-C88 GN-16-GXL 168-C138 GN-16-GXL 200-C35 BK-16-GXL 200-C153 BK-16-GXL 200-C398 BK-16-GXL 251-C522 BK-18-GXL 515-C384 GY-14-GXL 516-C385 GN-14-GXL 517-C393 BU-14-GXL 521-C327 YL-14-GXL 614-C34 PU-18-GXL 614-C231 PU-18-GXL 614-C397 PU-18-GXL

136-C136 GN-16-GXL H704-C470 PK-18-GXL 108-C1 BU-14-GXL 118-C131 GY-14-GXL 727-C16 GN-16-GXL

200-C165 BK-18-GXL 200-C112 BK-18-GXL 200-C113 BK-18-GXL 200-C36 BK-18-GXL 200-C181 BK-16-GXL

149-C322 PU-16-GXL

200-C35 BK-16-GXL 200-C398 BK-16-GXL 251-C522 BK-18-GXL 515-C384 GY-14-GXL 516-C385 GN-14-GXL 517-C393 BU-14-GXL 521-C327 YL-14-GXL

H14

614-C34 PU-18-GXL 614-C397 PU-18-GXL

614-C105 614-C114 614-C128 614-C134 614-C145

PU-18-GXL PU-18-GXL PU-18-GXL PU-18-GXL PU-18-GXL

M739-C471 YL-18-GXL 728-C78 BU-18-GXL J815-C304 BK-18-GXL

614-C231 PU-18-GXL 614-C262 PU-18-GXL

H14

C216-C222 BK-18-GXL

H13

C542-C104 GN-16-GXL C542-C423 GN-14-GXL

C583-C29 GN-18-GXL G766-C414 GN-18-GXL G767-C24 WH-18-GXL H766-C86 YL-18-GXL

P976-C305 BR-16-GXL T973-C511 WH-18-GXL T974-C512 BR-18-GXL 177-C183 RD-8 608-C263 GN-14-GXL 114-C283 RD-16-GXL 614-C260 PU-18-GXL 617-C302 BR-16-GXL 618-C303 YL-16-GXL 102-C527 RD-14-GXL

647-C251 GN-16-GXL 134-C250 YL-14-GXL 175-C475 RD-14-GXL 322-C14 GY-16-GXL 127-C246 OR-14-GXL 120-C124 RD-16-GXL

1 2 3 4

AUTOLUBE SERVICE CONNECTOR

CONN 31

200-C364 BK-14-GXL 251-C65 BK-18-GXL 307-C57 OR-16-GXL 709-C346 OR-18-GXL 709-C347 OR-18-GXL 976-C368 OR-18-GXL C216-C102 BK-18-GXL F766-C379 WH-18-GXL G485-C288 BU-18-GXL G750-C46 BU-18-GXL G755-C188 GY-18-GXL G760-C42 WH-18-GXL G761-C43 YL-18-GXL G762-C44 BR-18-GXL G763-C45 PU-18-GXL G768-C187 GN-18-GXL G991-C372 BR-18-GXL G992-C373 BU-18-GXL G993-C370 GN-18-GXL G994-C371 GY-18-GXL J764-C345 BR-18-GXL J764-C348 BR-18-GXL J764-C356 BR-18-GXL J815-C206 BK-18-GXL N936-C367 YL-18-GXL

614-C507 200-C509 200-C510 614-C508

H12 BACKLIGHT 1 115-1748

1

2

110-C49 RD-12-GXL 105-C281 RD-16-GXL 130-C357 RD-16-GXL

RD-14 BK-14 BR-14

A B C

C-C24 1552267 124-C148 GN-14-GXL A524-C218 BR-16-GXL 200-C181 BK-16-GXL

1 2

C-C60 1552269 P976-C305 BR-16-GXL 200-C140 BK-16-GXL

RD-16 BK-16

Y795-C300 GN-18-GXL Y795-C228 GN-18-GXL Y795-C313 GN-18-GXL

H12

320-C285 OR-16-GXL 615-C259 YL-14-GXL 157-C324 RD-16-GXL 199-C323 RD-16-GXL 306-C333 GN-18-GXL J814-C289 BK-18-GXL

H13

511-C466 BR-18-GXL 512-C399 GN-18-GXL

C-C79 1552264 508-C410 PU-18-GXL 509-C424 WH-18-GXL 200-C394 BK-14-GXL A513-C95 592-C396 512-C399 511-C466

PK-16-GXL BU-14-GXL GN-18-GXL BR-18-GXL

1 2 3 4 5 6 7 8

ANTENNA LEFT SPEAKER LEFT SPEAKER + GROUND

WH/BK GN/BK BK YL RD GY/BK VI/BK

3A

ENTERTAINMENT RADIO 331-5292 331-5291

1 2 3 4 5 6 7 8

W-C1 3E3388 512-W6 GN-16 508-W2 PU-16 200-W3 BK-16 120-W4 YL-16 A513-W7 RD-18 509-W1 WH-16 511-W5 BR-16

W-C2 7Y3968 508-W2 PU-16 511-W5 BR-16 120-W4 YL-16 512-W6 GN-16 509-W1 WH-16 200-W3 BK-16 A513-W7 RD-18 BATTERY BACKUP 123-9972

511-C466 BR-18-GXL 512-C399 GN-18-GXL

H2

H2

+ BATTERY (MEMORY) + BATTERY (12V) RIGHT SPEAKER RIGHT SPEAKER +

ADD WIRE AS TO EXTEND 508 CIRCUIT FOR JAPAN RADIO SPEAKERS

WHEN USED, CONNECT TO C-C79 LOC A-10

+ -

RH SPEAKER 168-8772

AM/FM RADIO (JAPAN) 266-9651 1 2 3 4 5 6 7 8 9

WIRE AS. 163-3479

SPEAKER LEFT (+) SPEAKER RIGHT (+) ACC 12V-28V

UPPER CAB GND

SPEAKER LEFT (-) SPEAKER RIGHT (-) GROUND BACKUP +B 12V-24V

GN-18-GXL BR-18-GXL BU-18-GXL GN-18-GXL GY-18-GXL BR-18-GXL BR-18-GXL BR-18-GXL BK-18-GXL YL-18-GXL OR-18-GXL GN-18-GXL

102-C75 RD-14-GXL 104-C382 YL-16-GXL 105-C307 RD-16-GXL 138-C194 GN-16-GXL 147-C308 RD-16-GXL 150-C3 OR-16-GXL 150-C381 OR-16-GXL 164-C217 WH-16-GXL 164-C265 WH-16-GXL 201-C416 BK-16-GXL 308-C199 YL-16-GXL 320-C287 OR-16-GXL 320-C529 OR-16-GXL 326-C200 PU-16-GXL 410-C240 WH-16-GXL 439-C242 YL-18-GXL 518-C190 OR-16-GXL 537-C191 GN-16-GXL 538-C192 BR-16-GXL

177-C183 RD-8 200-C474 BK-16-GXL

H11

H11

BK-14-GXL PU-18-GXL WH-18-GXL BU-14-GXL PK-16-GXL

614-C184 PU-18-GXL 614-C209 PU-18-GXL 614-C213 PU-18-GXL

617-C298 BR-16-GXL 617-C302 BR-16-GXL

617-C155 BR-16-GXL

618-C110 YL-16-GXL 618-C303 YL-16-GXL

618-C301 YL-16-GXL

17

16

15

14

13

12

11

10

9

8

509-Y1 WH-16

ADD WIRE AS TO EXTEND 512 CIRCUIT FOR JAPAN RADIO SPEAKERS 509-X1 WH-16

BK-18 BK-18

1 2 3 4

G787 GN-18 G788 YL-18 P916 OR-18 202 BK-18

JU-C1 3E3376

C-C48 1552264 147-C215 RD-16-GXL 201-C116 BK-16-GXL 150-C210 OR-16-GXL 614-C213 PU-18-GXL 945-C402 BR-18-GXL 944-C403 OR-18-GXL Y794-C177 OR-18-GXL Y795-C220 GN-18-GXL

XMSN SHIFTER 299-5841

MESSENGER 239-5025 1 2 3 4 5 6 7 8

+ BATTERY - BATTERY KEYSWITCH ON DIMMER CONTROL CAT DATA LINK CAT DATA LINK + CAN DATA LINK + CAN DATA LINK -

147-C216 RD-16-GXL 201-C119 BK-16-GXL

NOTE

DESCRIPTION

633-C117 BU-18-GXL

611-C74 PU-14-GXL 614-C209 PU-18-GXL Y794-C219 OR-18-GXL Y795-C174 GN-18-GXL 410-C240 WH-16-GXL 150-C211 OR-16-GXL

02 02 02 02 01 01 00 02 00 04 00 00 01 00 02 00 00 00 02 01 00 07 02 02 00 00 01 00 01 01 02 00 02 03 02 02 02 01 00

J X Y CY FF FG FH FY GP GY JU KK WE

307-0543 160-9419 160-9419 304-6911 283-4960 235-5762 235-5762 304-6911 307-3894 307-0543 101-9161 283-4960 308-7489

00 01 01 01 02 01 01 01 00 00 01 02 00

AU CC EE GG HH JJ MM PP RR XX WW

305-4383 300-6448 307-3089 306-5399 306-5400 305-4384 307-3095 307-3093 306-5401 300-6449 306-5398

04 02 00 04 04 03 03 02 03 00 02

INSTRUMENT CLUSTER 311-0038

BUCKET LIGHTS

LH TURN SIGNAL RH TURN SIGNAL

HIGH BEAM PARK LAMPS

H16

633-C117 BU-18-GXL T901-C235 YL-18-GXL T902-C234 PK-18-GXL 539-C106 BU-18-GXL 540-C111 WH-18-GXL 619-C297 GN-14-GXL

H15

ATCH ATCH ATCH

ATCH

ATCH ATCH ATCH

ATCH

ATCH ATCH

J

I

H

ATCH

G

AUX START RECEPTACLE BLOCK AS. TO STARTER BTRY TERM BTRY1 NEG TO BTRY2 POS BTRY2 NEG TO DISC SW DISC SW TO FRAME GND ENGINE GROUND TO FRAME GROUND BLOCK AS. TO SECONDARY STRG RLY SEC STRG TO SEC STRG FRAME GROUND STARTER NEG TO LH FRAME GND MAIN RELAY TO MAIN BREAKER BTRY1 TO BLOCK AS

ATCH ATCH ATCH ATCH

F

537-CT11 GN-18 605-CT13 YL-18

C-C53 1552252 102-C75 RD-14-GXL 691-C48 GY-18-GXL 200-C169 BK-18-GXL 518-C190 OR-16-GXL 537-C191 GN-16-GXL 538-C192 BR-16-GXL 539-C106 BU-18-GXL 540-C111 WH-18-GXL 605-C70 YL-18-GXL 606-C71 GY-18-GXL 633-C117 BU-18-GXL

606-CT15 GY-18 691-CT14 GY-18 A541-CT12 PU-18

CT-C1 3E5179

1 2 3 4 5 6 7 8 9 10 11 12

131-CT1 BR-18 200-CT2 BK-18 518-CT3 OR-18 537-CT4 GN-18 538-CT5 BR-18 539-CT6 BU-18 540-CT7 WH-18 605-CT8 YL-18 606-CT9 GY-18 633-CT10 BU-18

131-CT1 200-CT2 518-CT3 537-CT4

BR-18 BK-18 OR-18 GN-18

538-CT5 BR-18 539-CT6 BU-18 540-CT7 WH-18 605-CT8 YL-18 606-CT9 GY-18 633-CT10 BU-18

CONN 38

606-CT9 GY-18 606-CT15 GY-18

2 3

605-CT8 YL-18 605-CT13 YL-18

6

539-CT6 BU-18 540-CT7 WH-18

5 4 1

A541-CT12 PU-18 537-CT4 GN-18 537-CT11 GN-18 CT-C3 1552273 518-CT3 OR-18 537-CT11 GN-18 691-CT14 GY-18 A541-CT12 PU-18 633-CT10 BU-18 200-CT2 BK-18

24V FLASHER 217-8166

1 2 3 4 5 6

HAZARD INPUT CHASSIS LIGHTS KEY SW INPUT DASH TURN IND BUCKET IND GROUND

CT-C2 1552272

C216-C244 BK-18-GXL C216-C320 BK-18-GXL

E

691-CT14 GY-18 131-CT1 BR-18

606-CT15 GY-18 538-CT5 BR-18 605-CT13 YL-18

C529-C291 GY-18-GXL C530-C292 BU-18-GXL F766-C379 WH-18-GXL G485-C288 BU-18-GXL G750-C46 BU-18-GXL G755-C188 GY-18-GXL G760-C42 WH-18-GXL G761-C43 YL-18-GXL G762-C44 BR-18-GXL G763-C45 PU-18-GXL G768-C187 GN-18-GXL G991-C372 BR-18-GXL G992-C373 BU-18-GXL G993-C370 GN-18-GXL G994-C371 GY-18-GXL

TURN SIGNAL DIODES 172-9200

1 2 3 4

TURN SIGNAL H18

RH HEATED MIR 200-1173

CE-C7 1552269 C542-CE26 GN-14 200-CE29 BK-14

BR-18-GXL BR-18-GXL BR-18-GXL BR-18-GXL

J764-C344 BR-18-GXL

J765-C237 BU-18-GXL J808-C365 BK-18-GXL J815-C304 J815-C247 J815-C245 J815-C206

ATCH ATCH ATCH ATCH

ACTION ALARM DRIVER KEYSWITCH INPUT

A307-C238 GY-18-GXL A982-C180 BR-18-GXL

J764-C149 J764-C345 J764-C348 J764-C356

ATCH

TURN SIGNAL SW 134-9569

633-C117 BU-18-GXL T901-C235 YL-18-GXL T902-C234 PK-18-GXL

C216-C102 BK-18-GXL

ATCH

CAN HIGH CAN LOW

537-CT11 GN-18 605-CT13 YL-18

539-C106 BU-18-GXL 540-C111 WH-18-GXL 619-C297 GN-14-GXL

ENTERTAINMENT RADIO MAIN CAB LH FRONT LIGHTING (ROADING) RH FRONT LIGHTING (ROADING) STOP LAMP SW IN LH BRAKE PEDAL LH/RH BUCKET TURN CLEARANCE LAMP ENTERTAINMENT RADIO (JAPAN) IT38H FRONT FRAME RIDE CONTROL 938H FRONT FRAME SEAT - AIR SUSPENSION PCS JUMPER QUICK COUPLER AUTO DIFFERENTIAL LOCK (FRONT) AUTOLUBE PUMP AXLE OIL COOLER TRANSMISSION AUTOLUBE PUMP JUMPER AUTOLUBE PUMP ROADING LIGHTS (BUCKET TURN SIG) RR AXLE TEMP MONITORING ROOF WAVES DISPLAY ENGINE APPLICATION MAIN CHASSIS FR AXLE TEMP MONITORING AUTO DIFFERENTIAL LOCK (REAR) (EUROPE) TURN SIG LICENSE PLATE LAMP (GERMAN ROADING) SECONDARY STEERING HYDRAULIC SERVICE CENTER HVAC PCS SUBSYSTEM HARNESS TO ECM PERKINS BASIC ENGINE INJECTORS INJECTORS INJECTORS GATEWAY ECM VARIABLE PITCH FAN WIRE AS. RH REAR HID RH SPEAKER (JAPAN) LH SPEAKER (JAPAN) LH FRONT HID BUCKET FORK SELECT SWITCH JUMPER LH FRONT CAB FLOOD RH FRONT CAB FLOOD RH FRONT HID GLOWPLUG RELAY TO GLOWPLUG BUSSBAR LH REAR HID FNR JUMPER LEFT TILT KOUT SET SWITCH JUMPER BLOCK AS. TO GLOWPLUG BREAKER CABLE AS.

+24V BATTERY GROUND

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24

200-5728 344-7930 267-2999 267-2998 146-1892 115-5777 267-1106 307-3107 305-4381 300-6440 192-7805 305-4377 252-0040 300-6444 277-8271 282-9047 344-7928 305-4382 277-8272 286-9546 305-4374 266-8620 284-3283 364-5132 364-1971 305-4375 300-6446 214-5372 272-5749 307-3087 300-6451 276-4300 281-9481 260-5541 285-1975 285-1975 285-1975 281-9480 362-3341

606-CT15 GY-18 691-CT14 GY-18 A541-CT12 PU-18

A982-C180 BR-18-GXL J765-C237 BU-18-GXL A307-C238 GY-18-GXL

RD-18 BK-18

J815-C366 BK-18-GXL

M927-C170 GN-16-GXL N936-C367 YL-18-GXL Y794-C318 OR-18-GXL Y794-C229 OR-18-GXL

Y794-C219 OR-18-GXL

Y794-C175 OR-18-GXL

Y794-C232 OR-18-GXL

Y794-C299 OR-18-GXL

Y794-C177 OR-18-GXL

Y795-C319 GN-18-GXL

Y795-C174 GN-18-GXL

Y795-C230 GN-18-GXL

Y795-C233 GN-18-GXL

Y795-C224 GN-18-GXL Y795-C300 GN-18-GXL

Y795-C220 GN-18-GXL

320-C286 OR-16-GXL

+V GROUND SIGNAL

YL-18

C-C59 1552269

BK-18-GXL BK-18-GXL BK-18-GXL BK-18-GXL

THROTTLE POSN SNSR 269-1983

RECEPTACLE AS. 3E3364 1 2

H18

1 2

BK-18 BK-18

D

615-CE17 YL-14 615-CE11 YL-14 200-CE6 BK-14 200-CE23 BK-14

615-FH1 YL-16 200-FH2 BK-16

FORWARD HORN SW 322-8568

GY-18

A629-CE34 BU-14 C-C51 1552272 308-C199 YL-16-GXL 326-C200 PU-16-GXL 307-C57 OR-16-GXL 105-C307 RD-16-GXL C-C26 2234778 619-C297 GN-14-GXL 610-C152 OR-14-GXL 611-C69 PU-14-GXL

614-C184 PU-18-GXL 200-C171 BK-18-GXL

C-C58 1552264 104-C382 YL-16-GXL 201-C168 BK-16-GXL Y794-C232 OR-18-GXL Y795-C233 GN-18-GXL T901-C235 YL-18-GXL T902-C234 PK-18-GXL

SYMBOL

DESCRIPTION

R YL-16

1 2 3 4

C S B

PU-16 OR-16 BR-16

OFF ON ST

KEY START SW 110-7887

GROUND(200) PASS THROUGH STUD SHARED BETWEEN ALL LIGHTS. POWER TO FLOODS (615) STUD SHARED BETWEEN STANDARD AND ATTACHMENT FLOODS

PASS THROUGH STUDS 6V-7357 615-CE17 YL-14 200-CE23 BK-14

WH-18 BK-18

A629-FY1 BU-14 200-FY2 BK-14

RH FRONT CAB FLOOD 109-7041

1 2 3 4 5 6 7 8 9 10

C

MSS KEY READER 218-0404 1 2 3 4 5 6 7 8

KEY SW IN GROUND CAN+ CANTIRIS INTERFACE SIGNAL LINE TIRIS GND RETURN

WIRE GROUP COLOR DESCRIPTIONS GROUND CIRCUIT WIRES THAT HAVE SYSTEM VOLTAGE WHEN THE KEY SWITCH IS OFF

CIRCUIT CONNECTED C-C63 1552269 T901-C235 YL-18-GXL T902-C234 PK-18-GXL

CIRCUIT NOT CONNECTED

MSS EXCITER COIL 205-8257 1 2

BK BK

WIRES THAT HAVE SYSTEM VOLTAGE WHEN THE KEY SWITCH IS ON VOLTAGE CONVERTER OUTPUT CIRCUIT STARTING CIRCUIT

ELECTRICAL CONNECTION TO MACHINE STRUCTURE

START AID CIRCUIT

INTERNAL ELECTRICAL CONNECTION TO SURFACE OF COMPONENT

TRANSMISSION CONTROL CIRCUIT

CONNECTOR

ENGINE CONTROL CIRCUIT

MACHINE SECURITY CONTROL CIRCUIT HEATER AND AIR CONDITIONER CIRCUIT

H#

CIRCUIT GROUPING DESIGNATION

TURN SIGNAL / WIPER WASHER CIRCUIT CAT DATA LINK

B

RS-232 / RS-485 DATA LINK

605-C306 YL-16-GXL 606-C296 GY-16-GXL 610-C127 OR-14-GXL 614-C383 PU-18-GXL 617-C298 BR-16-GXL 618-C110 YL-16-GXL 709-C25 OR-18-GXL 761-C4 GY-18-GXL 944-C403 OR-18-GXL 945-C402 BR-18-GXL A307-C238 GY-18-GXL A982-C180 BR-18-GXL C529-C291 GY-18-GXL C530-C292 BU-18-GXL J764-C149 BR-18-GXL J765-C237 BU-18-GXL J808-C365 BK-18-GXL J815-C245 BK-18-GXL J815-C247 BK-18-GXL Y794-C318 OR-18-GXL Y795-C319 GN-18-GXL

PAYLOAD CONTROL CIRCUIT

BLADE, SPADE, RING OR SCREW TERMINAL

OTHER COLOR DESCRIPTIONS HIGHWAYS

ABBREV

COLOR

RD WH OR YL PK BK GY PU BR GN BU

RED WHITE ORANGE YELLOW PINK BLACK GRAY PURPLE BROWN GREEN BLUE

THIS SCHEMATIC IS FOR THE 938H & IT938H WHEEL LOADER ELECTRICAL SYSTEM VOLUME 2 of 2: CAB MEDIA NUMBER: RENR9764-04 SCHEMATIC PART NUMBER: 264-5848, CHANGE: 02, VERSION: Components are shown installed on a fully operable machine with the key and engine off, transmission shifter in neutral and with parking brake set. Refer to the appropriate Service Manual for Troubleshooting, Specifications and Systems Operations.

BATTERY BACKUP (+) BATTERY BACKUP (-)

7

FORWARD SW IP REVERSE SW IP NEUTRAL SW IP GROUND

5 6 7 8

709-C369 OR-18-GXL

AM/FM RADIO (JAPAN STANDARD)

18

CHG

CAN DATA LINK

H12

200-C394 508-C410 509-C424 592-C396 A513-C95

614-C231 PU-18-GXL 614-C260 PU-18-GXL 614-C383 PU-18-GXL

FIRST GEAR SECOND GEAR THIRD GEAR FOURTH GEAR START RELAY NEUTRAL OUT REVERSE OUT FORWARD OUT

SPLICE

H12

CABLE AS. 109-8981

610-C152 OR-14-GXL 610-C189 OR-14-GXL

KEY SW IP BACKUP ALARM OUTPUT

ATCH WIRE, CABLE, COMPONENT

H13

ANTENNA 1 (AM/FM RADIO) 8E-1118

200-C364 BK-14-GXL 251-C65 BK-18-GXL 307-C57 OR-16-GXL 709-C346 OR-18-GXL 709-C347 OR-18-GXL 976-C368 OR-18-GXL C216-C102 BK-18-GXL F766-C379 WH-18-GXL G485-C288 BU-18-GXL G750-C46 BU-18-GXL G755-C188 GY-18-GXL G760-C42 WH-18-GXL G761-C43 YL-18-GXL G762-C44 BR-18-GXL G763-C45 PU-18-GXL G768-C187 G991-C372 G992-C373 G993-C370 G994-C371 J764-C345 J764-C348 J764-C356 J815-C206 N936-C367 Y794-C299 Y795-C300

P989-C241 GN-18-GXL

QUICK COUPLER HORN 132-1829

H18

DIMMER SWITCH 249-5479

AC TEMP CONT 291-2165

Y794-C299 OR-18-GXL Y794-C227 OR-18-GXL Y794-C312 OR-18-GXL

610-C127 OR-14-GXL

H15

PU-18-GXL BK-18-GXL BK-18-GXL PU-18-GXL

C-C45 1135183 614-C128 PU-18-GXL 200-C147 BK-18-GXL

606-C71 GY-18-GXL 606-C294 GY-18-GXL

200-C256 BK-16-GXL

114-C283 RD-16-GXL 136-C185 GN-16-GXL 138-C9 GN-16-GXL 147-C214 RD-16-GXL 150-C212 OR-16-GXL 164-C37 WH-16-GXL 200-C169 BK-18-GXL 200-C171 BK-18-GXL 251-C522 BK-18-GXL 320-C285 OR-16-GXL 322-C14 GY-16-GXL 614-C231 PU-18-GXL 614-C260 PU-18-GXL 617-C302 BR-16-GXL 618-C303 YL-16-GXL 691-C48 GY-18-GXL 762-C50 YL-18-GXL 779-C139 WH-16-GXL 964-C182 BU-18-GXL J815-C304 BK-18-GXL M927-C170 GN-16-GXL

171-C178 GN-16-GXL 171-C179 GN-18-GXL A764-C248 GN-18-GXL M893-C249 GY-16-GXL

646-C253 OR-16-GXL 170-C98 RD-12-GXL

T974-C512 BR-18-GXL 251-C522 BK-18-GXL T973-C511 WH-18-GXL

606-C296 GY-16-GXL

307 OR-18 321 BR-18

761-C4 GY-18-GXL 762-C50 YL-18-GXL 779-C139 WH-16-GXL 944-C403 OR-18-GXL 945-C402 BR-18-GXL 964-C182 BU-18-GXL 976-C368 OR-18-GXL

171-C261 GN-18-GXL

124-C13 GN-14-GXL 168-C138 GN-16-GXL C542-C104 GN-16-GXL

C-C54 3E3376 439-C412 YL-18-GXL 439-C413 YL-18-GXL 200-C32 BK-16-GXL 157-C324 RD-16-GXL

BK-18-GXL BK-18-GXL BK-16-GXL BK-16-GXL

605-C70 YL-18-GXL 605-C293 YL-18-GXL

709-C25 OR-18-GXL 709-C346 OR-18-GXL 709-C347 OR-18-GXL

124-C13 GN-14-GXL 168-C138 GN-16-GXL C542-C104 GN-16-GXL

168-C138 GN-16-GXL 170-C98 RD-12-GXL 171-C252 GN-16-GXL 175-C475 RD-14-GXL 199-C323 RD-16-GXL 306-C333 GN-18-GXL 320-C285 OR-16-GXL 322-C14 GY-16-GXL 608-C263 GN-14-GXL 614-C239 PU-18-GXL 614-C260 PU-18-GXL 615-C259 YL-14-GXL 617-C302 BR-16-GXL 618-C303 YL-16-GXL 646-C253 OR-16-GXL 647-C251 GN-16-GXL 691-C48 GY-18-GXL 699-C456 PU-18-GXL 727-C16 GN-16-GXL 728-C78 BU-18-GXL C542-C104 GN-16-GXL C543-C80 GY-16-GXL H704-C470 PK-18-GXL J814-C289 BK-18-GXL J815-C304 BK-18-GXL J887-C202 PU-18-GXL M739-C471 YL-18-GXL P739-C201 BU-16-GXL P989-C241 GN-18-GXL

M927-C170 GN-16-GXL

GN-14-GXL YL-14-GXL PU-18-GXL BK-18-GXL BK-18-GXL PU-18-GXL

PART NO

A C L M T U W AC AE AG AJ AK AM AN AP AR AT AW AX AY CA CE CG CH CJ CL CR CT CU CV HC HV PC PE PF PG PH PL RF

691-C48 GY-18-GXL

170-C64 RD-14-GXL 170-C68 RD-14-GXL 170-C72 RD-14-GXL

200-C398 BK-16-GXL 306-C333 GN-18-GXL 515-C384 GY-14-GXL 516-C385 GN-14-GXL 517-C393 BU-14-GXL 521-C327 YL-14-GXL 608-C263 GN-14-GXL 614-C34 PU-18-GXL 614-C239 PU-18-GXL 614-C397 PU-18-GXL 615-C259 YL-14-GXL 646-C253 OR-16-GXL 647-C251 GN-16-GXL 699-C456 PU-18-GXL 700-C85 PK-18-GXL 727-C16 GN-16-GXL 728-C78 BU-18-GXL 961-C101 BR-18-GXL A524-C218 BR-16-GXL A764-C248 GN-18-GXL C216-C222 BK-18-GXL C542-C423 GN-14-GXL C543-C80 GY-16-GXL C583-C29 GN-18-GXL G766-C414 GN-18-GXL G767-C24 WH-18-GXL H704-C470 PK-18-GXL J814-C289 BK-18-GXL J887-C202 PU-18-GXL M739-C471 YL-18-GXL M893-C249 GY-16-GXL P739-C201 BU-16-GXL P989-C241 GN-18-GXL T973-C511 WH-18-GXL T974-C512 BR-18-GXL

102-C527 RD-14-GXL 104-C280 YL-16-GXL 105-C281 RD-16-GXL 108-C1 BU-14-GXL 110-C49 RD-12-GXL 112-C415 PU-4 114-C283 RD-16-GXL 115-C125 PK-16-GXL 118-C131 GY-14-GXL 120-C124 RD-16-GXL 124-C13 GN-14-GXL 127-C246 OR-14-GXL 130-C357 RD-16-GXL 134-C250 YL-14-GXL 136-C136 GN-16-GXL 138-C9 GN-16-GXL 141-C377 PK-16-GXL 147-C214 RD-16-GXL 149-C322 PU-16-GXL 150-C212 OR-16-GXL 157-C324 RD-16-GXL 164-C37 WH-16-GXL

200-C474 BK-16-GXL

700-C85 PK-18-GXL 762-C50 YL-18-GXL 779-C139 WH-16-GXL 961-C101 BR-18-GXL 964-C182 BU-18-GXL A524-C218 BR-16-GXL

C542-C425 GN-16-GXL

200-C171 200-C169 200-C153 200-C474

104-C280 YL-16-GXL 168-C138 GN-16-GXL C542-C104 GN-16-GXL 147-C214 RD-16-GXL 138-C9 GN-16-GXL

614-C18 PU-18-GXL

136-C225 GN-16-GXL

175-C475 RD-14-GXL 177-C183 RD-8 199-C323 RD-16-GXL 200-C35 BK-16-GXL

614-C239 PU-18-GXL

614-C166 PU-18-GXL 614-C20 PU-18-GXL 614-C31 PU-18-GXL 614-C33 PU-18-GXL 614-C388 PU-18-GXL

C216-C7 BK-18-GXL C216-C12 BK-18-GXL C216-C26 BK-18-GXL C216-C418 BK-18-GXL

171-C178 GN-16-GXL 171-C252 GN-16-GXL 171-C179 GN-18-GXL

699-C456 PU-18-GXL 150-C212 OR-16-GXL 115-C125 PK-16-GXL

614-C144 PU-18-GXL 614-C389 PU-18-GXL 614-C507 PU-18-GXL 614-C19 PU-18-GXL 614-C508 PU-18-GXL

170-C98 RD-12-GXL

605-C306 YL-16-GXL

+BATTERY GROUND

G763-C45 PU-18-GXL G755-C188 GY-18-GXL G750-C46 BU-18-GXL

540-C111 WH-18-GXL 539-C106 BU-18-GXL

611-C69 PU-14-GXL 611-C74 PU-14-GXL 611-C295 PU-14-GXL

141-C377 PK-16-GXL 149-C322 PU-16-GXL 157-C324 RD-16-GXL

700-C85 PK-18-GXL 762-C50 YL-18-GXL 779-C139 WH-16-GXL 961-C101 BR-18-GXL 964-C182 BU-18-GXL A524-C218 BR-16-GXL C216-C222 BK-18-GXL C542-C104 GN-16-GXL C542-C423 GN-14-GXL C583-C29 GN-18-GXL G766-C414 GN-18-GXL G767-C24 WH-18-GXL M927-C170 GN-16-GXL T973-C511 WH-18-GXL T974-C512 BR-18-GXL

567-C386 WH-14-GXL 567-C141 WH-14-GXL 567-C5 WH-14-GXL 567-C387 WH-14-GXL

110-C328 RD-14-GXL 110-C329 RD-14-GXL

112-C415 PU-4 115-C125 PK-16-GXL 118-C131 GY-14-GXL 120-C124 RD-16-GXL 124-C88 GN-16-GXL 127-C246 OR-14-GXL 130-C357 RD-16-GXL 134-C250 YL-14-GXL 136-C185 GN-16-GXL 136-C136 GN-16-GXL

C-C17 2234778 567-C5 WH-14-GXL 124-C161 GN-14-GXL 567-C141 WH-14-GXL

1 2 3 4 5 6 7 8 9 10

102-C527 RD-14-GXL 104-C280 YL-16-GXL 105-C281 RD-16-GXL 108-C1 BU-14-GXL

124-C13 GN-14-GXL 691-C48 GY-18-GXL P739-C201 BU-16-GXL J887-C202 PU-18-GXL 171-C252 GN-16-GXL 164-C37 WH-16-GXL 141-C377 PK-16-GXL C543-C80 GY-16-GXL

1 2

MANUAL DIFF LOCK SW 147-1380 C-C46 1552267 136-C225 GN-16-GXL 200-C38 BK-16-GXL 439-C411 YL-18-GXL

C-C30 2234778 517-C393 BU-14-GXL 567-C386 WH-14-GXL 516-C385 GN-14-GXL

1 2 3 4 5 6 7 8 9 10

LOW

PU-18-GXL BK-18-GXL BK-18-GXL PU-18-GXL

C-C28 2234778 H766-C86 YL-18-GXL C216-C12 BK-18-GXL

1 2 3 4 5 6 7 8 9 10

PARK BRAKE LIMIT SW 6G-4195

200-C146 BK-12-GXL 200-C38 BK-16-GXL 200-C83 BK-14-GXL 200-C122 BK-16-GXL 200-C32 BK-16-GXL 200-C120 BK-16-GXL 200-C121 BK-16-GXL

PU-18-GXL BK-18-GXL BK-18-GXL PU-18-GXL

AIR SEAT COMPRESSOR 199-5725

CONN 32

OR-16 BK-16

C216-C418 BK-18-GXL G767-C24 WH-18-GXL G766-C414 GN-18-GXL C216-C26 BK-18-GXL

1 2 3 4 5 6 7 8 9 10

MOM

168-C173 GN-16-GXL 168-C137 GN-16-GXL 168-C375 GN-16-GXL

C-C33 2234778

H16

124-C161 GN-14-GXL 124-C148 GN-14-GXL 124-C162 GN-14-GXL

320-C286 OR-16-GXL

322-C14 GY-16-GXL 326-C200 PU-16-GXL 410-C240 WH-16-GXL 439-C242 YL-18-GXL 518-C190 OR-16-GXL 537-C191 GN-16-GXL 538-C192 BR-16-GXL

126 PK-18 202 BK-18

G768 GN-18 G760 WH-18 G761 YL-18 G762 BR-18 306 GN-18 G763 PU-18 G755 GY-18 G750 BU-18

C-C52 7X6222

307-C57 OR-16-GXL 308-C199 YL-16-GXL

H14

1 2 3 4 5 6

C-C4 3E3388 1 G768-C187 GN-18-GXL 2 G760-C42 WH-18-GXL 3 G761-C43 YL-18-GXL 4 G762-C44 BR-18-GXL

FRONT INTER WIPER WASHER SW 275-7741

BACKLIGHT 4 115-1748

1

CONN 15

964-C182 BU-18-GXL

L GN-16

4 1 2 6 3 5

C-C90 1135183 614-C459 PU-18-GXL 200-C438 BK-18-GXL

BU-16-GXL PK-14-GXL OR-16-GXL OR-14-GXL

CONN 34

C-C114 1552252

BK-18-GXL GY-14-GXL BR-18-GXL OR-18-GXL

538-C453 BR-16-GXL 538-C454 BR-16-GXL

614-C109 PU-18-GXL 614-C239 PU-18-GXL 614-C458 PU-18-GXL

SERVICE TOOL CONNECTOR

C-C89 1552273 501-C451 GN-18-GXL

BR-18-GXL YL-18-GXL BU-18-GXL PU-18-GXL WH-18-GXL OR-16-GXL GN-16-GXL

CONNECT TO AG-C1 VOL. 1 LOC G-4, K-4

709-C369 OR-18-GXL J764-C344 BR-18-GXL G993-C370 GN-18-GXL G994-C371 GY-18-GXL G991-C372 BR-18-GXL G992-C373 BU-18-GXL 610-C189 OR-14-GXL M927-C170 GN-16-GXL

STOP LAMP SW 105-6117

500-C450 BR-18-GXL 501-C451 GN-18-GXL 502-C452 OR-18-GXL

538-C192 BR-16-GXL

944-C400 OR-18-GXL 945-C401 BR-18-GXL Y795-C317 GN-18-GXL Y794-C316 OR-18-GXL

HAZARD LAMPS SW 256-7823

C-C86 1552273 C216-C464 BK-18-GXL 973-C51 BR-18-GXL 977-C40 YL-18-GXL H728-C359 GN-18-GXL

200-C446 BK-18-GXL 200-C447 BK-18-GXL 200-C21 BK-18-GXL 200-C448 BK-18-GXL 200-C449 BK-18-GXL

603-C196 PK-14-GXL 604-C193 OR-16-GXL 610-C127 OR-14-GXL 614-C109 PU-18-GXL 614-C239 PU-18-GXL 646-C253 OR-16-GXL 647-C251 GN-16-GXL 651-C27 PK-14-GXL 699-C456 PU-18-GXL 973-C51 BR-18-GXL 977-C40 YL-18-GXL A629-C47 BU-14-GXL C216-C39 BK-18-GXL G746-C358 WH-18-GXL H728-C359 GN-18-GXL

C-C19 9W1951 147-C308 RD-16-GXL 201-C309 BK-16-GXL

RD-14-GXL OR-16-GXL PU-18-GXL BK-18-GXL BK-18-GXL BR-16-GXL

C-C94 1237615 592-C118 BU-16-GXL 200-C257 BK-16-GXL

202-C10 202-C60 202-C61 202-C62

A629-CE34 BU-14 C542-CE26 GN-14

C-C85 1135183

134-C11 YL-14-GXL 134-C15 YL-14-GXL

200-C93 BK-14-GXL 200-C445 BK-14-GXL

BK-18 BK-18

GROUND(200) PASS THROUGH STUD SHARED BETWEEN ALL LIGHTS. POWER TO FLOODS (615) STUD SHARED BETWEEN STANDARD AND ATTACHMENT FLOODS

200-CE6 BK-14 200-CE29 BK-14 615-CE11 YL-14

BEACON SW 237-9736

141-C377 PK-16-GXL 164-C265 WH-16-GXL 200-C257 BK-16-GXL

Y794-C316 OR-18-GXL

Y795-C317 GN-18-GXL

GY-14-GXL GY-14-GXL GY-14-GXL GY-14-GXL GY-14-GXL

130-C357 RD-16-GXL 134-C250 YL-14-GXL

1 2

HARNESS AS.

1 2 3 4 5 6 7 8 9 10

537-C191 GN-16-GXL 538-C453 BR-16-GXL

PK BK

127-C6 OR-14-GXL 127-C8 OR-14-GXL

127-C246 OR-14-GXL

CE-C6 1552269 C542-CE27 GN-14 200-CE28 BK-14

L

LH HEATED MIR 200-1173

H17

C-C84 2234778

ACTION ALARM HORN 3E-6328 1 2

LH FRONT CAB FLOOD 109-7041

WH-18 BK-18

K

1 2 3 4 5 6 7 8 9 10

141-C377 PK-16-GXL 603-C196 PK-14-GXL

ELECTRO-MAGNET 145-8428 (4)

A B C

A629-CY1 BU-14 200-CY2 BK-14

615-CE18 YL-14 200-CE10 BK-14

A629-CE33 BU-14 A629-CE34 BU-14

C542-CE26 GN-14 C542-CE27 GN-14

C-C83 2234778

RD RD

614-C460 PU-18-GXL

C-C6 1552267 Y794-C318 OR-18-GXL Y795-C319 GN-18-GXL

615-CE32 YL-14 615-CE11 YL-14

A629-CE19 BU-14

200-C21 BK-18-GXL

FLOAT ELECTRO-MAGNET

RD RD

A629-CE33 BU-14

615-CE4 YL-14

H7

134-C15 YL-14-GXL 651-C27 PK-14-GXL 614-C17 PU-18-GXL

POSITIONER ELECTRO-MAGNET

RD RD

PASS THROUGH STUDS 6V-7357

C-C82 2234778

LIFT

J815-C245 BK-18-GXL J815-C247 BK-18-GXL

FORWARD HORN SW STD 265-8171

H11

H11

G948-C150 BR-18-GXL G948-C164 BR-18-GXL

Y795-C319 GN-18-GXL YL-18 BR-18 BK-18

H17

127-C8 OR-14-GXL A629-C47 BU-14-GXL

118-C376 GY-14-GXL

Y795-C226 GN-18-GXL Y795-C313 GN-18-GXL

A B C

134-C11 YL-14-GXL 647-C251 GN-16-GXL 614-C462 PU-18-GXL

A629-CE19 BU-14 651-CE15 PK-14 200-CE35 BK-14

PILOT VALVE GROUP 261-8656 IMPLEMENT DETENTS

TILT POSITIONER ELECTRO-MAGNET

102-C176 RD-14-GXL

Y794-C318 OR-18-GXL

C-C113 1552267

127-C6 OR-14-GXL 646-C253 OR-16-GXL

IMPLEMENT POD

C216-C422 BK-18-GXL C216-C39 BK-18-GXL C216-C222 BK-18-GXL C216-C360 BK-18-GXL C216-C276 BK-18-GXL

C543-C80 GY-16-GXL C583-C29 GN-18-GXL F766-C379 WH-18-GXL G485-C288 BU-18-GXL G750-C46 BU-18-GXL G755-C188 GY-18-GXL G760-C42 WH-18-GXL G761-C43 YL-18-GXL G762-C44 BR-18-GXL G763-C45 PU-18-GXL G764-C338 PK-18-GXL G766-C414 GN-18-GXL G767-C24 WH-18-GXL G768-C187 GN-18-GXL G991-C372 BR-18-GXL G992-C373 BU-18-GXL G993-C370 GN-18-GXL G994-C371 GY-18-GXL J764-C345 BR-18-GXL J815-C206 BK-18-GXL J887-C202 PU-18-GXL N936-C367 YL-18-GXL Y794-C227 OR-18-GXL Y795-C228 GN-18-GXL

H10

H11

E746-C476 GN-18-GXL E746-C477 GN-18-GXL

H17

615-FG1 YL-16 200-FG2 BK-16

C-C81 2234778

102-C197 RD-14-GXL

604-C193 OR-16-GXL 608-C263 GN-14-GXL 610-C127 OR-14-GXL 614-C109 PU-18-GXL 614-C239 PU-18-GXL 615-C259 YL-14-GXL 646-C253 OR-16-GXL 647-C251 GN-16-GXL 699-C456 PU-18-GXL 761-C4 GY-18-GXL 944-C400 OR-18-GXL 945-C401 BR-18-GXL 961-C101 BR-18-GXL 973-C51 BR-18-GXL 977-C40 YL-18-GXL

BK-18-GXL YL-18-GXL PK-18-GXL GN-18-GXL

200-C497 BK-16-GXL 320-C529 OR-16-GXL C216-C503 BK-18-GXL G788-C493 YL-18-GXL P915-C491 PK-18-GXL E746-C476 GN-18-GXL G787-C489 GN-18-GXL C216-C504 BK-18-GXL

C216-C404 BK-18-GXL C216-C129 BK-18-GXL C216-C102 BK-18-GXL

H10

102-C75 RD-14-GXL 104-C382 YL-16-GXL 105-C307 RD-16-GXL 138-C194 GN-16-GXL 147-C308 RD-16-GXL 150-C3 OR-16-GXL 150-C381 OR-16-GXL 164-C217 WH-16-GXL 164-C265 WH-16-GXL 201-C416 BK-16-GXL 308-C199 YL-16-GXL 320-C287 OR-16-GXL 320-C529 OR-16-GXL 326-C200 PU-16-GXL 410-C240 WH-16-GXL 439-C242 YL-18-GXL 518-C190 OR-16-GXL 537-C191 GN-16-GXL 538-C192 BR-16-GXL

E746-C53 GN-18-GXL

170-C64 RD-14-GXL 170-C68 RD-14-GXL 170-C72 RD-14-GXL 202-C60 BK-14-GXL 202-C61 BK-14-GXL 202-C62 BK-14-GXL 306-C333 GN-18-GXL 307-C57 OR-16-GXL 419-C163 YL-18-GXL 700-C85 PK-18-GXL 709-C346 OR-18-GXL 728-C78 BU-18-GXL 976-C368 OR-18-GXL A764-C248 GN-18-GXL A900-C421 OR-18-GXL

H6

H10

200-C92 BK-14-GXL

Y794-C223 OR-18-GXL Y794-C312 OR-18-GXL

T971-C515 OR-18-GXL H4

H5

118-C362 GY-18-GXL 118-C376 GY-14-GXL

118-C131 GY-14-GXL

STANDARD WITH SAL IMPLEMENT CONTROL NOT PRESENT WITH JOYSTICK IMPLEMENT CONTROL

C216-C56 G788-C87 P915-C89 G787-C79

615-CE18 YL-14 615-CE32 YL-14 200-CE7 BK-14 200-CE10 BK-14

615-CE4 YL-14 A629-CE19 BU-14 C542-CE26 GN-14 C542-CE27 GN-14

C542-CE26 GN-14 C542-CE27 GN-14

C542-CE25 GN-14

CONN 35

AUXILLARY ELECTRO-MAGNET

1

200-CE6 BK-14 200-CE7 BK-14 200-CE28 BK-14 200-CE29 BK-14

200-CE6 BK-14 200-CE7 BK-14 200-CE28 BK-14 200-CE29 BK-14

603-CE13 PK-14 608-CE3 GN-14 615-CE4 YL-14 651-CE15 PK-14 A629-CE19 BU-14

CONN 36 A629-C47 BU-14-GXL 651-C27 PK-14-GXL 200-C28 BK-14-GXL

200-CE22 BK-14 200-CE6 BK-14

603-CE13 PK-14 608-CE3 GN-14 651-CE15 PK-14

200-CE28 BK-14 200-CE29 BK-14

200-CE30 BK-14

603-CE13 PK-14 200-CE1 BK-14 608-CE3 GN-14 615-CE4 YL-14

C-C74 CE-C13 3E3376 1552272 1 200-C254 BK-14-GXL 200-CE5 BK-14 2 200-C427 BK-14-GXL 200-CE2 BK-14 3 C542-C423 GN-14-GXL C542-CE25 GN-14 4 200-C314 BK-14-GXL 200-CE30 BK-14

592-C395 BU-16-GXL 592-C396 BU-14-GXL

102-C130 RD-18-GXL 102-C176 RD-14-GXL 102-C197 RD-14-GXL

J808-C66 BK-18-GXL J808-C167 BK-18-GXL J808-C90 BK-18-GXL J808-C365 BK-18-GXL

C216-C503 BK-18-GXL C216-C56 BK-18-GXL C216-C500 BK-18-GXL C216-C504 BK-18-GXL

CE-C1 3E3376

200-CE37 BK-14 200-CE36 BK-14

200-CE5 BK-14 200-CE21 BK-14 200-CE22 BK-14 200-CE36 BK-14 200-CE37 BK-14

200-C446 BK-18-GXL

G948-C99 BR-18-GXL

251-C521 BK-18-GXL 320-C287 OR-16-GXL 320-C529 OR-16-GXL

200-CE2 BK-14

1 2 3 4

2

261-8654 STANDARD

A513-C95 PK-16-GXL C216-C39 BK-18-GXL C542-C423 GN-14-GXL G746-C358 WH-18-GXL

200-C494 BK-16-GXL 200-C497 BK-16-GXL

200-C195 BK-16-GXL

C-C73 1552272 PK-14-GXL BK-14-GXL GN-14-GXL YL-14-GXL

200-CE35 BK-14

RS-232 PORT 1 TXD

H728-C359 GN-18-GXL

200-C28 BK-14-GXL 200-C270 BK-14-GXL

Y787-PC17 OR-18 Y788-PC18 GN-18

603-C196 200-C428 608-C263 615-C259

200-CE5 BK-14

H9

3

200-CE7 BK-14 200-CE21 BK-14

102-C430 RD-14-GXL 610-C127 OR-14-GXL 614-C457 PU-18-GXL

T971-C515 OR-18-GXL 251-C521 BK-18-GXL

200-C92 BK-14-GXL 200-C255 BK-12-GXL

BR-18-GXL YL-18-GXL BU-18-GXL BU-16-GXL BU-14-GXL PK-16-GXL

CAT DATA LINK + CAT DATA LINK -

STANDARD WITH SAL IMPLEMENT CONTROL NOT PRESENT WITH JOYSTICK IMPLEMENT CONTROL

CAB GND 1

251-PC12 BK-18

503-C132 504-C133 505-C123 592-C395 592-C396 A513-C95

200-CE1 BK-14

102-C130 RD-18-GXL 200-C311 BK-18-GXL

200-C392 BK-14-GXL 200-C364 BK-14-GXL

C-C23 J2 1471446

605-C306 YL-16-GXL 606-C296 GY-16-GXL 610-C127 OR-14-GXL 614-C383 PU-18-GXL 617-C298 BR-16-GXL 618-C110 YL-16-GXL 709-C25 OR-18-GXL 761-C4 GY-18-GXL 944-C403 OR-18-GXL 945-C402 BR-18-GXL A307-C238 GY-18-GXL A982-C180 BR-18-GXL C529-C291 GY-18-GXL C530-C292 BU-18-GXL J764-C149 BR-18-GXL J765-C237 BU-18-GXL J808-C365 BK-18-GXL J815-C245 BK-18-GXL J815-C247 BK-18-GXL Y794-C318 OR-18-GXL Y795-C319 GN-18-GXL

A B C

E746-C477 GN-18-GXL C216-C500 BK-18-GXL

GY-18-GXL BK-18-GXL BK-16-GXL BK-14-GXL

DOME LAMP 107-6032

603-C196 PK-14-GXL 651-C27 PK-14-GXL A629-C47 BU-14-GXL

T974-PC10 BR-18 T973-PC9 WH-18

200-C256 BK-16-GXL 200-C146 BK-12-GXL

102-C527 RD-14-GXL 104-C280 YL-16-GXL 105-C281 RD-16-GXL 110-C328 RD-14-GXL 110-C329 RD-14-GXL 112-C415 PU-4 118-C131 GY-14-GXL 124-C88 GN-16-GXL 127-C246 OR-14-GXL 130-C357 RD-16-GXL 134-C250 YL-14-GXL 141-C377 PK-16-GXL 149-C322 PU-16-GXL 150-C3 OR-16-GXL 171-C261 GN-18-GXL 175-C475 RD-14-GXL 177-C183 RD-8 199-C323 RD-16-GXL 200-C28 BK-14-GXL 200-C35 BK-16-GXL 200-C92 BK-14-GXL 200-C255 BK-12-GXL 200-C270 BK-14-GXL 200-C392 BK-14-GXL 200-C398 BK-16-GXL 201-C267 BK-16-GXL 251-C520 BK-18-GXL 321-C378 BR-18-GXL 403-C419 GN-18-GXL 416-C55 OR-18-GXL 417-C81 GY-18-GXL 439-C411 YL-18-GXL 439-C412 YL-18-GXL 439-C413 YL-18-GXL 447-C59 PK-18-GXL 453-C54 PK-18-GXL 484-C82 YL-18-GXL 515-C384 GY-14-GXL 516-C385 GN-14-GXL 517-C393 BU-14-GXL 521-C327 YL-14-GXL 592-C100 BU-16-GXL 592-C115 BU-16-GXL 604-C198 OR-16-GXL 608-C263 GN-14-GXL 614-C34 PU-18-GXL 614-C239 PU-18-GXL 614-C397 PU-18-GXL 615-C259 YL-14-GXL 646-C253 OR-16-GXL 647-C251 GN-16-GXL 699-C456 PU-18-GXL 709-C347 OR-18-GXL 727-C16 GN-16-GXL 751-C350 GN-18-GXL 752-C352 YL-18-GXL 754-C351 BU-18-GXL 755-C354 OR-18-GXL 763-C58 BU-18-GXL 900-C353 PU-18-GXL 901-C355 WH-18-GXL 944-C157 OR-18-GXL 945-C160 BR-18-GXL 961-C101 BR-18-GXL 973-C51 BR-18-GXL 977-C40 YL-18-GXL A513-C95 PK-16-GXL A524-C218 BR-16-GXL A907-C332 BU-18-GXL A975-C337 BU-18-GXL C216-C39 BK-18-GXL C216-C276 BK-18-GXL C216-C360 BK-18-GXL C216-C404 BK-18-GXL C495-C528 OR-18-GXL C542-C423 GN-14-GXL E455-C334 BR-18-GXL E746-C53 GN-18-GXL E796-C275 GN-18-GXL E900-C203 WH-18-GXL E901-C63 GN-18-GXL E906-C204 OR-18-GXL E907-C205 GY-18-GXL E908-C236 BR-18-GXL E909-C380 WH-18-GXL E929-C374 GY-18-GXL G732-C349 WH-18-GXL G746-C358 WH-18-GXL G787-C406 GN-18-GXL G788-C409 YL-18-GXL G948-C99 BR-18-GXL G995-C76 OR-18-GXL G996-C77 PK-18-GXL G997-C67 PU-18-GXL G998-C73 WH-18-GXL H704-C470 PK-18-GXL H728-C359 GN-18-GXL H746-C243 YL-18-GXL J764-C348 BR-18-GXL J764-C356 BR-18-GXL J807-C2 BK-18-GXL J808-C167 BK-18-GXL J809-C330 BK-18-GXL J814-C289 BK-18-GXL J814-C336 BK-18-GXL J845-C331 PU-18-GXL J854-C342 YL-18-GXL M739-C471 YL-18-GXL M893-C249 GY-16-GXL N787-C339 BU-18-GXL P739-C201 BU-16-GXL P915-C408 PK-18-GXL P988-C526 OR-18-GXL P989-C241 GN-18-GXL R732-C326 BR-18-GXL T973-C511 WH-18-GXL T974-C512 BR-18-GXL X778-C335 PU-18-GXL Y794-C312 OR-18-GXL Y795-C313 GN-18-GXL

PRODUCT LINK (PL300) ECM 262-1421

118-C362 200-C310 200-C315 200-C394

4

H7

LH SPEAKER 168-8772

CONN 37

200-C315 BK-16-GXL 200-C394 BK-14-GXL

603-C196 PK-14-GXL 608-C263 GN-14-GXL 615-C259 YL-14-GXL 651-C27 PK-14-GXL A513-C95 PK-16-GXL A629-C47 BU-14-GXL C542-C423 GN-14-GXL

H6

Y788-PC21 GN-18 Y788-PC18 GN-18 Y788-PC22 GN-18

200-C310 BK-18-GXL 200-C311 BK-18-GXL 200-C314 BK-14-GXL

503-C132 BR-18-GXL 504-C133 YL-18-GXL 505-C123 BU-18-GXL

H6

Y787-PC17 OR-18 Y787-PC19 OR-18 Y787-PC20 OR-18

H4

+ -

c

118-C131 GY-14-GXL 124-C88 GN-16-GXL 127-C246 OR-14-GXL 130-C357 RD-16-GXL 134-C250 YL-14-GXL 138-C194 GN-16-GXL 141-C377 PK-16-GXL 147-C308 RD-16-GXL 150-C3 OR-16-GXL 164-C265 WH-16-GXL 200-C28 BK-14-GXL 200-C92 BK-14-GXL 200-C255 BK-12-GXL 200-C392 BK-14-GXL 320-C287 OR-16-GXL 320-C529 OR-16-GXL 410-C240 WH-16-GXL 515-C384 GY-14-GXL 516-C385 GN-14-GXL 517-C393 BU-14-GXL 518-C190 OR-16-GXL 537-C191 GN-16-GXL 538-C192 BR-16-GXL 608-C263 GN-14-GXL 610-C127 OR-14-GXL 614-C239 PU-18-GXL 615-C259 YL-14-GXL 646-C253 OR-16-GXL 647-C251 GN-16-GXL 699-C456 PU-18-GXL 761-C4 GY-18-GXL 961-C101 BR-18-GXL 973-C51 BR-18-GXL 977-C40 YL-18-GXL

H2

A

Y794-C223 OR-18-GXL Y794-C272 OR-18-GXL

118-C131 GY-14-GXL 124-C88 GN-16-GXL 127-C246 OR-14-GXL 130-C357 RD-16-GXL 134-C250 YL-14-GXL 138-C194 GN-16-GXL 141-C377 PK-16-GXL 147-C308 RD-16-GXL 150-C3 OR-16-GXL 164-C265 WH-16-GXL 200-C28 BK-14-GXL 200-C92 BK-14-GXL 200-C255 BK-12-GXL 200-C392 BK-14-GXL 320-C287 OR-16-GXL 320-C529 OR-16-GXL 410-C240 WH-16-GXL 515-C384 GY-14-GXL 516-C385 GN-14-GXL 517-C393 BU-14-GXL 518-C190 OR-16-GXL 537-C191 GN-16-GXL 538-C192 BR-16-GXL 608-C263 GN-14-GXL 610-C127 OR-14-GXL 614-C239 PU-18-GXL 615-C259 YL-14-GXL 646-C253 OR-16-GXL 647-C251 GN-16-GXL 699-C456 PU-18-GXL 761-C4 GY-18-GXL 961-C101 BR-18-GXL 973-C51 BR-18-GXL 977-C40 YL-18-GXL

D

B

J807-C2 BK-18-GXL

J808-C66 BK-18-GXL J808-C90 BK-18-GXL

110-C328 RD-14-GXL 175-C475 RD-14-GXL

CONN 12

945-C159 BR-18-GXL

945-C160 945-C274 945-C401 945-C402 945-C468

J807-C524 BK-18-GXL J807-C525 BK-18-GXL

P988-C526 OR-18-GXL J807-C525 BK-18-GXL

CONNECT TO CJ-C47 VOL. 1 LOC E-6

944-C158 OR-18-GXL

OR-18-GXL OR-18-GXL OR-18-GXL OR-18-GXL OR-18-GXL

A307-C238 GY-18-GXL A907-C332 BU-18-GXL A975-C337 BU-18-GXL A982-C180 BR-18-GXL C216-C276 BK-18-GXL C216-C360 BK-18-GXL C495-C528 OR-18-GXL E455-C334 BR-18-GXL E796-C275 GN-18-GXL E900-C203 WH-18-GXL E901-C63 GN-18-GXL E906-C204 OR-18-GXL E907-C205 GY-18-GXL E908-C236 BR-18-GXL E909-C380 WH-18-GXL E929-C374 GY-18-GXL G732-C349 WH-18-GXL G995-C76 OR-18-GXL G996-C77 PK-18-GXL G997-C67 PU-18-GXL G998-C73 WH-18-GXL H704-C470 PK-18-GXL H746-C243 YL-18-GXL J764-C149 BR-18-GXL J764-C348 BR-18-GXL J764-C356 BR-18-GXL J765-C237 BU-18-GXL

Y794-C94 OR-18-GXL Y795-C321 GN-18-GXL

CONNECTS TO C-C103 PIN 4G

PC-C6 1552254 105-PC5 RD-16 T973-PC9 WH-18 T974-PC10 BR-18 T971-PC11 OR-18 251-PC14 BK-18 944-PC2 OR-18 945-PC3 BR-18 251-PC4 BK-18 C529-PC6 GY-18 C530-PC7 BU-18 251-PC13 BK-18 138-PC15 GN-18

CONVERTER OUTPUT SP SNSR + CONVERTER OUTPUT SP SNSR -

944-C157 944-C273 944-C400 944-C403 944-C467

N957-PL18 N960-PL19 N970-PL21 N973-PL22 N979-PL20

138-PC15 GN-18 138-PC1 GN-16 138-PC8 GN-18

E746-C53 GN-18-GXL G787-C406 GN-18-GXL G788-C409 YL-18-GXL P915-C408 PK-18-GXL T971-C515 OR-18-GXL

617-C298 BR-16-GXL 618-C110 YL-16-GXL 709-C25 OR-18-GXL 709-C347 OR-18-GXL 727-C16 GN-16-GXL 751-C350 GN-18-GXL 752-C352 YL-18-GXL 754-C351 BU-18-GXL 755-C354 OR-18-GXL 763-C58 BU-18-GXL 900-C353 PU-18-GXL 901-C355 WH-18-GXL

416-C55 OR-18-GXL 606-C296 GY-16-GXL 417-C81 GY-18-GXL 614-C154 PU-16-GXL 453-C54 PK-18-GXL 484-C82 YL-18-GXL 604-C108 OR-16-GXL 617-C298 BR-16-GXL 403-C420 GN-18-GXL A975-C337 BU-18-GXL J814-C282 BK-18-GXL 618-C110 YL-16-GXL C216-C360 BK-18-GXL 727-C16 GN-16-GXL N787-C339 BU-18-GXL

CONNECT TO CJ-C1 VOL. 1 LOC F-6

614-C34 PU-18-GXL 614-C109 PU-18-GXL 614-C383 PU-18-GXL 614-C397 PU-18-GXL

200-C195 BK-16-GXL 251-C521 BK-18-GXL 320-C287 OR-16-GXL 320-C529 OR-16-GXL C216-C404 BK-18-GXL

BU-16-GXL BU-16-GXL BU-16-GXL BU-16-GXL

605-C306 YL-16-GXL 606-C296 GY-16-GXL

308-C199 YL-16-GXL J809-C107 BK-18-GXL A907-C332 BU-18-GXL P989-C241 GN-18-GXL E455-C334 BR-18-GXL X778-C335 PU-18-GXL 321-C378 BR-18-GXL

102-C130 RD-18-GXL 102-C176 RD-14-GXL 102-C197 RD-14-GXL 118-C131 GY-14-GXL 127-C246 OR-14-GXL 130-C357 RD-16-GXL 134-C250 YL-14-GXL 141-C377 PK-16-GXL 147-C308 RD-16-GXL 164-C265 WH-16-GXL 200-C28 BK-14-GXL 200-C92 BK-14-GXL 200-C93 BK-14-GXL 200-C255 BK-12-GXL 200-C257 BK-16-GXL 200-C264 BK-14-GXL 201-C309 BK-16-GXL 201-C417 BK-16-GXL 410-C240 WH-16-GXL 506-C340 PU-18-GXL 507-C341 WH-18-GXL 518-C190 OR-16-GXL 537-C191 GN-16-GXL 538-C192 BR-16-GXL 592-C118 BU-16-GXL 592-C126 BU-16-GXL 604-C193 OR-16-GXL 608-C263 GN-14-GXL 610-C127 OR-14-GXL 614-C109 PU-18-GXL 614-C239 PU-18-GXL 615-C259 YL-14-GXL 646-C253 OR-16-GXL 647-C251 GN-16-GXL 699-C456 PU-18-GXL 761-C4 GY-18-GXL 944-C400 OR-18-GXL 945-C401 BR-18-GXL 961-C101 BR-18-GXL 973-C51 BR-18-GXL 977-C40 YL-18-GXL

604-C193 OR-16-GXL 604-C198 OR-16-GXL

592-C100 592-C115 592-C118 592-C126

YL-18 RD-16 BK-16 GN-18

H5

A513-C95 PK-16-GXL C216-C39 BK-18-GXL C542-C423 GN-14-GXL G746-C358 WH-18-GXL G948-C99 BR-18-GXL H728-C359 GN-18-GXL J808-C66 BK-18-GXL J808-C90 BK-18-GXL J808-C167 BK-18-GXL J808-C365 BK-18-GXL J815-C245 BK-18-GXL J815-C247 BK-18-GXL Y794-C223 OR-18-GXL Y794-C312 OR-18-GXL Y794-C318 OR-18-GXL Y795-C226 GN-18-GXL Y795-C313 GN-18-GXL Y795-C319 GN-18-GXL

447-C59 PK-18-GXL 453-C54 PK-18-GXL 484-C82 YL-18-GXL 506-C340 PU-18-GXL 507-C341 WH-18-GXL 521-C327 YL-14-GXL 522-C156 WH-14-GXL

G

F

YL-18-GXL YL-18-GXL YL-18-GXL YL-18-GXL

104-PL23 105-PL24 201-PL25 403-PL26

944-PL31 OR-18 945-PL32 BR-18 Y794-PL34 OR-18 Y795-PL33 GN-18

RD-16-GXL RD-16-GXL RD-16-GXL RD-16-GXL

RD-14-GXL RD-14-GXL PU-4 PU-16-GXL OR-16-GXL WH-16-GXL GN-18-GXL RD-14-GXL RD-8 RD-16-GXL

200-C269 BK-14-GXL

CONNECTS TO CAB GROUND BOSS

5 6 7 8 9 10 11 12

1 2 3 4 5 6 7 8 9 10 11 12

YL-18-GXL RD-16-GXL BK-16-GXL GN-18-GXL

944-C273 OR-18-GXL 945-C274 BR-18-GXL Y794-C272 OR-18-GXL Y795-C271 GN-18-GXL

N973-PL22 BR-18 N979-PL20 GN-18

105-PL27 RD-16 201-PL28 BK-16 104-PL29 YL-18 403-PL30 GN-18 944-PL31 OR-18 945-PL32 BR-18 Y795-PL33 GN-18 Y794-PL34 OR-18

1 2 3 4 5 6 7 8 9 10 11 12

105-PC5 RD-16

CONN 29 104-C278 105-C279 201-C268 403-C172

C-C101 1552254 105-C279 RD-16-GXL 201-C268 BK-16-GXL 104-C278 YL-18-GXL 403-C172 GN-18-GXL 944-C273 OR-18-GXL 945-C274 BR-18-GXL Y795-C271 GN-18-GXL Y794-C272 OR-18-GXL

CONN 33

C-C69 C-C44 1907613 1552254 1 105-C469 RD-16-GXL 2 T973-C511 WH-18-GXL 3 T974-C512 BR-18-GXL 4 T971-C515 OR-18-GXL

C-C2 1552264 515-C384 GY-14-GXL 516-C385 GN-14-GXL 522-C156 WH-14-GXL A524-C218 BR-16-GXL 200-C392 BK-14-GXL 517-C393 BU-14-GXL 124-C88 GN-16-GXL

HVAC

C

H4

124-C88 GN-16-GXL 200-C392 BK-14-GXL 515-C384 GY-14-GXL

592-HV8 BR-16 A524-HV7 PU-16

515-HV1 OR-14 516-HV2 GN-14 517-HV3 BU-14 522-HV5 WH-16 592-HV8 BR-16 A524-HV7 PU-16

ANTENNA AS. 319-6804

GPS ANTENNA

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 56 57 58 59 60 61 62 63 64 65 66 67 68 69 70

N960-PL19 OR-18 N970-PL21 YL-18

200-HV6 BK-14 200-HV9 BK-16 200-HV10 BK-14 200-HV4 BK-16

RXD GND DTR DCD

105-PC5 RD-16

N957-PL18 PK-18

200-HV4 BK-16 522-HV5 WH-16

RS-232 RS-232 RS-232 RS-232

102-C130 RD-18-GXL 118-C362 GY-18-GXL 200-C28 BK-14-GXL 200-C254 BK-14-GXL 200-C427 BK-14-GXL 200-C428 BK-14-GXL

YL-18 RD-16 BK-16 GN-18

944-PL31 OR-18 945-PL32 BR-18

J

BTRY + BTRY KEYSWITCH ON R-TERM RS-232 TXD

SATELLITE ANTENNA

N970-PL21 YL-18 N973-PL22 BR-18 N979-PL20 GN-18

K

H1

PL121SR RADIO 336-3545

PL-C5 1552252

PL-C6 1607690

H1

509-C424 WH-18-GXL 508-C410 PU-18-GXL

H9 J1

508-C410 PU-18-GXL 509-C424 WH-18-GXL

C-C78 1552273 504-C133 YL-18-GXL

RH RR CAB FLOOD 109-7041

36 Page,

RENR9764-04 VOL 2 of 2

651-CE12 PK-14 200-CE37 BK-14

C-C76 1552269 592-C395 BU-16-GXL 200-C315 BK-16-GXL

5

c

18

6

5

4

3

2

1

A