RECEIVER
R-S202/R-S202D SERVICE MANUAL R-S202/R-S202D
■ CONTENTS TO SERVICE PERSONNEL ........................................... 2 FRONT PANELS ............................................................ 3 REAR PANELS .............................................................. 4 REMOTE CONTROL PANEL ......................................... 7 SPECIFICATIONS .......................................................... 7 INTERNAL VIEW ........................................................... 9 SERVICE PRECAUTIONS ............................................. 9 DISASSEMBLY PROCEDURES .................................. 10 UPDATING FIRMWARE ............................................... 13 SELF-DIAGNOSTIC FUNCTION ................................. 19
DISPLAY DATA ............................................................ 30 IC DATA ........................................................................ 31 BLOCK DIAGRAMS..................................................... 35 WIRING DIAGRAM ...................................................... 37 PRINTED CIRCUIT BOARDS ...................................... 38 PIN CONNECTION DIAGRAMS .................................. 44 SCHEMATIC DIAGRAMS ............................................ 45 REPLACEMENT PARTS LIST ..................................... 49 REMOTE CONTROL.................................................... 60
1013 6 4 '16.04
R-S202/R-S202D
■ TO SERVICE PERSONNEL 1. Critical Components Information
Components having special characteristics are marked ⚠ and must be replaced with parts having specifications equal to those originally installed.
WALL OUTLET
EQUIPMENT UNDER TEST
AC LEAKAGE TESTER OR EQUIVALENT
2. Leakage Current Measurement (For 120V Models Only)
When service has been completed, it is imperative to verify that all exposed conductive surfaces are properly insulated from supply circuits.
• Meter impedance should be equivalent to 1500 ohms shunted by 0.15 μF.
INSULATING TABLE
• Leakage current must not exceed 0.5mA. • Be sure to test for leakage with the AC plug in both polarities.
R-S202/R-S202D
For U model “CAUTION” “F1: FOR CONTINUED PROTECTION AGAINST RISK OF FIRE, REPLACE ONLY WITH SAME TYPE 8A, 125V FUSE.” For C model CAUTION F1: REPLACE WITH SAME TYPE 8A, 125V FUSE. ATTENTION F1: UTILISER UN FUSIBLE DE RECHANGE DE MÉME TYPE DE 8A, 125V.
CALIFORNIA PROPOSITION 65 WARNING This product contains chemicals known to the State of California to cause cancer, or birth defects or other reproductive harm. DO NOT PLACE SOLDER, ELECTRICAL/ELECTRONIC OR PLASTIC COMPONENTS IN YOUR MOUTH FOR ANY REASON WHATSOEVER! Avoid prolonged, unprotected contact between solder and your skin! When soldering, do not inhale solder fumes or expose eyes to solder/flux vapor! If you come in contact with solder or components located inside the enclosure of this product, wash your hands before handling food.
About lead free solder All of the P.C.B.s installed in this unit and solder joints are soldered using the lead free solder. Among some types of lead free solder currently available, it is recommended to use one of the following types for the repair work. • Sn + Ag + Cu (tin + silver + copper) • Sn + Cu (tin + copper) • Sn + Zn + Bi (tin + zinc + bismuth)
Caution: As the melting point temperature of the lead free solder is about 30°C to 40°C (50°F to 70°F) higher than that of the lead solder, be sure to use a soldering iron suitable to each solder.
2
R-S202/R-S202D
■ FRONT PANELS R-S202
R-S202/R-S202D
R-S202D
3
R-S202/R-S202D
■ REAR PANELS
R-S202/R-S202D
R-S202 (U, C models)
R-S202 (R model)
R-S202 (T model)
4
R-S202/R-S202D
R-S202 (K model)
R-S202/R-S202D
R-S202 (A model)
R-S202 (G model)
5
R-S202/R-S202D
R-S202/R-S202D
R-S202 (L model)
R-S202D (B, G models)
6
R-S202/R-S202D
■ REMOTE CONTROL PANEL
■ SPECIFICATIONS ■ Audio Section
RAX33
Minimum RMS Output Power (Power Amp. Section) (40 Hz to 20 kHz, 0.2 % THD, 8 ohms / L/R drive) U, C, R, T, A, B, G models ......................................... 100 W + 100 W L model .......................................................................... 85 W + 85 W Dynamic Power Per Channel (IHF) 8 / 6 / 4 / 2 ohms ............................................125 / 150 / 165 / 180 W Maximum Power Per Channel (1 kHz, 0.7 % THD, 4 ohms) [B, G models] ................................................................................................ 115 W Maximum Effective Output Power (JEITA) (1 kHz, 10 % THD, 8 ohms) R, T models...............................................................................140 W L model .....................................................................................125 W
R-S202/R-S202D
Input Sensitivity/Input Impedance (1 kHz, 100 W/8 ohms) CD etc................................................................. 500 mV / 47 k-ohms Output Level/Output Impedance REC OUT ........................................................... 500 mV / 2.2 k-ohms Headphone Jack Rated Output/Output Impedance (1 kHz, 500 mV, 8 ohms load / CD etc. input) ............................................................................. 470 mV / 470 ohms Frequency Response (CD etc.) 20 Hz to 20 kHz ................................................................ 0 ± 0.5 dB 10 Hz to 100 kHz .............................................................. 0 ± 3.0 dB Total Harmonic Distortion (20 Hz to 20 kHz, 50 W/8 ohms) CD etc. to SP OUT ......................................................... 0.2 % or less Signal to Noise Ratio (IHF-A Network) CD etc., Input shorted 500 mV .................................. 100 dB or more Residual Noise (IHF-A Network) ................................................................................................ 70 μ V Tone Control Characteristics Bass Boost/Cut (50 Hz)................................................................. ±10 dB Turnover frequency................................................................170 Hz Treble Boost/Cut (20 kHz)................................................................ ±10 dB Turnover frequency...............................................................3.0 kHz ■ FM Section Tuning Range U, C models ...........................................................87.5 to 107.9 MHz R, L models................................87.5 to 108.0 / 87.50 to 108.00 MHz A, B, G models ..................................................87.50 to 108.00 MHz 50 dB Quieting Sensitivity (IHF) (1 kHz, 100 % MOD.) Mono ........................................................................ 3 μ V (20.8 dBf) Signal to Noise Ratio (IHF) Mono / Stereo................................................................72 dB / 70 dB Harmonic Distortion (1 kHz) Mono / Stereo.................................................................0.3 % / 0.5 % Antenna Input .......................................................................... 75 ohms unbalanced
7
R-S202/R-S202D
Top view
11.5 (1/2")
Tuning Range U, C models .............................................................530 to 1,710 kHz R, L models.......................................530 to 1,710 / 531 to 1,611 kHz T, A, G models .........................................................531 to 1,611 kHz
45 (1-3/4")
• DIMENSIONS
■ AM Section
ø 71.6
[B, G models] Tuning Range ...................................................................174 to 240 MHz (Band III)
290 (11-3/8") 322 (12-5/8")
■ DAB Section (R-S202D)
190 (7-1/2")
Antenna ......................................................................................Loop antenna
ø 60
■ General
Power Consumption U, C, R, T, A, B, G models ........................................................175 W L model .....................................................................................140 W Standby Power Consumption [U, C, T, A, B, G, L models] ....................................................................................... 0.5 W or less Dimensions (W x H x D) .................................435 x 141 x 322 mm (17-1/8" x 5-1/2" x 12-5/8") Weight .................................................................................6.7 kg (14.8 lbs.) Finish U, C, R, T, A, B, G, L models ............................................ Black color R, T, A, B, G, L models ..................................................... Silver color Accessories Remote control............................................................................... x 1 Battery (R6, AA, UM-3) .................................................................. x 2 FM antenna (1.4 m) ....................................................................... x 1 AM antenna (1.0 m) ....................................................................... x 1 DAB/FM antenna (1.6 m) (R-S202D) ............................................. x 1
* Specifications are subject to change without notice.
8
335 (13-1/4")
A..................Australian model B........................British model G.................. European model L................. Singapore model
435 (17-1/8")
141 (5-1/2")
21 (7/8")
120 (4-3/4")
Front view
Power Supply U, C models ..............................................................AC 120 V, 60 Hz R model ........................................ AC 110–120/220–240 V, 50/60 Hz T model .....................................................................AC 220 V, 50 Hz A model ....................................................................AC 240 V, 50 Hz B, G models ..............................................................AC 230 V, 50 Hz L model ........................................................ AC 220–240 V, 50/60 Hz
U.........................U.S.A. model C.................. Canadian model R..................... General model T.....................Chinese model K.......................Korean model
50 (2")
20.5 (3/4")
Antenna .......................................................................... 75 ohms unbalanced
55 (2-1/8")
R-S202/R-S202D
Support Audio Format ................................. MPEG 1 Layer II / MPEG 4 HE ACC v2 (ACC+)
Unit: mm (inch)
R-S202/R-S202D
■ INTERNAL VIEW Top view 1
2
3
a SWITCH P.C.B. (R model) b MAIN (1) P.C.B. c TUNER Module (R-S202) MAIN (8) P.C.B. + DAB Module (A-S202D) d MAIN (5) P.C.B. e MAIN (7) P.C.B. f POWER TRANSFORMER g MAIN (6) P.C.B. h MAIN (3) P.C.B.
R-S202/R-S202D
i MAIN (2) P.C.B. j BTCARD P.C.B. k MAIN (4) P.C.B. 6
5
4
Front view
7 8
9
j k
■ SERVICE PRECAUTIONS Safety measures • Some internal parts in this product contain high voltages and are dangerous. Be sure to take safety measures during servicing, such as wearing insulating gloves. • Note that the capacitors indicated below are dangerous even after the power is turned off because an electric charge remains and a high voltage continues to exist there. Before starting any repair work, connect a discharging resistor (5 k-ohms/10 W) to the terminals of each capacitor indicated below to discharge electricity. The time required for discharging is about 30 seconds per each. C140, C143 and C149 on MAIN (1) P.C.B. For details, refer to PRINTED CIRCUIT BOARDS .
9
R-S202/R-S202D
■ DISASSEMBLY PROCEDURES (Remove parts in the order as numbered.) Disconnect the power cable from the AC outlet.
1. Removal of Top Cover a.
Remove screw (1), 4 screws (2) and 6 screws (3). (Fig. 1)
b.
Remove the top cover. (Fig. 1)
2. Removal of Front Panel Unit Remove 2 screws (4) and 6 screws (5). (Fig. 1)
b.
Remove CB102, CB204, CB401 and CB502. (Fig. 1)
c.
Release 2 hooks and then remove the front panel unit. (Fig. 1)
R-S202/R-S202D
a.
2 Top cover
1
4
3
4 CB401
Hook
2
CB502
5
CB102
5 CB204
MAIN (6) P.C.B.
MAIN (1) P.C.B.
MAIN (2) P.C.B. Front panel unit
5
Fig. 1
10
Hook
R-S202/R-S202D
3. Removal of AMP Unit a.
Remove 11 screws (7). (Fig. 3)
b.
Remove 4 screws (8) and screw (9). (Fig. 2)
c.
Remove CB4, CB7, CB103 and CB202. (Fig. 2)
d.
Remove the AMP unit. (Fig. 2)
8
9
CB4 CB7 CB103
8 R-S202/R-S202D
8
CB202
MAIN (1) P.C.B. AMP unit
Fig. 2
7
Rear view
7 Fig. 3
11
R-S202/R-S202D
When checking the MAIN (1) P.C.B.: • Place the P.C.B.s (with rear panel) upright. (Fig. 4) • Connect the heatsink and rear panel to the chassis with a ground lead or the like. (Fig. 4) • Reconnect all cables (connectors) that have been disconnected. • When connecting the flexible flat cable, be careful with polarity.
Rear panel
R-S202/R-S202D
Ground lead
Chassis
MAIN (1) P.C.B. Ground lead
Heatsink
Fig. 4
12
R-S202/R-S202D
■ UPDATING FIRMWARE When the following parts are replaced, the firmware must be updated to the latest version. MAIN P.C.B. Microprocessor: IC203 on FUNCTION (1) P.C.B.
● Confirmation of firmware version and checksum Before and after updating the firmware, check the firmware version and checksum by using the self-diagnostic function menu. Start up the self-diagnostic function and select 1. FIRMWARE VERSION/CHECK SUM menu. Using the sub-menu, have the firmware version and checksum displayed, and note them down. (For details, refer to SELF-DIAGNOSTIC FUNCTION ) * When the firmware version is different from written one after updating, perform the updating procedure again from the beginning. R-S202/R-S202D
● Initializing the back-up IC After updating the firmware, the back-up IC MUST be initialized by the following procedure to store the setting information properly. Start up the self-diagnostic function and select 5. FACTORY PRESET menu. (For details, refer to SELF-DIAGNOSTIC FUNCTION ) Select PRST RSRV , press the z (Power) key to turn off the power once and turn on the power again. Then the backup IC is initialized.
● Required Tools
● Preparation and precautions
• Firmware downloader program ...................................................................RFP.exe • Firmware .....................................................RS_202_xxx.mot • RS-232C conversion adaptor (Part No.: ZK189200) • Flexible flat cable (9 pin 150 mm pitch = 1.25, Part No.: ZD896000) • USB to Serial converter
• Download the firmware downloader program and the latest firmware from the specified download source to the same folder of the PC. • Prepare the above specified RS-232C cross cable. • While writing the firmware, keep the other application software on the PC closed. It is also recommended to keep the software on the task tray closed as well.
(USB type-A to D-sub 9 pin) * Recommendation: BUFFALO (Part No.: BSUSRC0605BS) FTDI Ltd. (Part No.: DS-US232R-10)
13
R-S202/R-S202D
● Connection *
Disconnect the power cable of this unit from the AC outlet.
• Connect the writing port (CB201 on MAIN (1) P.C.B.) located on the rear panel of this unit to the USB port of the PC with USB to serial converter, RS-232C conversion adaptor and flexible flat cable as shown below. (Fig. 1) This unit PC
Writing port (CB201 on MAIN (1) P.C.B.)
USB port
R-S202/R-S202D
Flexible flat cable (9P) USB to serial converter
RS-232C conversion adaptor
Fig. 1
● Operation Procedures 1.
Connect the power cable of this unit to the AC outlet. The power to this unit is supplied and the microprocessor is in the writing mode.
2.
Start up RFP.exe. The screen appears as shown below. (Fig. 2)
3.
Select the Basic mode and click [Next]. (Fig. 2)
Select Basic mode
Fig. 2
14
R-S202/R-S202D
4.
Select the type of the microprocessor and make the workspace. (Fig. 3) • Microcontroller:
RL78
• Using Target Microcontroller:
RL78/G13, R5F100JF
• Workspace Name:
Any name
• Project Name:
Any name
• Folder:
Any place * Click [Browse…] and specify the place where the workspace is made. (Fig.3)
5.
Click [Next]. (Fig. 3)
R-S202/R-S202D
RL78
RL78/G13, R5F100JF
Fig. 5 Workspace Name Project Name Folder
Fig. 3
15
R-S202/R-S202D
6.
Select COMx with the Tool and click [Next]. (Fig. 4) *
Do not proceed to other settings until clicking [Next] is completed. (Fig. 4)
R-S202/R-S202D
Tool: COMx
Fig. 4 7.
Make the port (COMx) setting. (Fig. 5) a. Access the device manager. (Fig. 5) * To access the device manager, click [Start], [Control panel], [System], [Hardware] and [Device manager] in this order. b. Right click the communication port (COMx) of the port (COM and LPT) to open the property. (Fig. 5) * COMx: Enter the port number of the PC to which the USB to serial converter is connected in place of x . c. Using the port setting function, set the Bit/second to 115200 . (Fig. 5)
8.
Click [OK]. (Fig. 5)
115200
Fig. 5
16
R-S202/R-S202D
9.
Click [Browse...] and select the firmware name. (Fig. 6)
10. Click [Start] to start writing. (Fig. 6)
R-S202/R-S202D
Writing being executed.
Fig. 6
17
R-S202/R-S202D
11. When writing of the firmware is completed, the screen appears as shown below. (Fig. 7)
R-S202/R-S202D
12. Click [X] to end RFP.exe. (Fig. 7)
Fig. 7 13. Disconnect the power cable of this unit from the AC outlet. 14. Remove the RS-232C conversion adaptor and flexible flat cable from the writing port (CB201 on MAIN (1) P.C.B.) of this unit. 15. Connect the power cable of this unit to the AC outlet, start up the self-diagnostic function and check that the firmware version and checksum are the same as written ones. (For details, refer to Confirmation of firmware version and checksum )
18
R-S202/R-S202D
■ SELF-DIAGNOSTIC FUNCTION This unit has self-diagnostic functions that are intended for inspection, measurement and location of faulty point. Each item has a main menu, each of which has sub-menu items. Listed in the table below are main menu items and sub-menu items. Note: Some of the menu items listed below may not apply to the models covered in this service manual. No. 1
3
4
VERSION/CHECK SUM
DISPLAY CHECK
Bluetooth
DAB
No.
Sub-menu
1
FIRMWARE VERSION
2
FIRMWARE CHECKSUM
3
MODEL/DESTINATION
4
BT VERSION
5
DAB VERSION (R-S202D)
1
INITIAL DISPLAY
2
ALL SEGMENT OFF
3
ALL SEGMENT ON
1
Bluetooth ADDRESS
2
Bluetooth LOOPBACK
3
Bluetooth NAME
1
SIGNAL QUALITY
1
PRESET INHIBIT
2
PRESET RESERVE
1
PS
2
DC
3
TEMPERATURE A
4
TEMPERATURE B
5
DESTINATION
6
KEY 0 / KEY 1
1
HISTORY 1
2
HISTORY 2
3
HISTORY 3
4
HISTORY 4
1
LAST
2
HISTORY 1
3
HISTORY 2
4
HISTORY 3
5
HISTORY 4
R-S202/R-S202D
2
Main menu
(Not for service)
(Not for service)
5
6
7
8
FACTORY PRESET
AD DATA CHECK
PROTECTION HISTORY
POWER OFF FACTOR HISTORY
19
R-S202/R-S202D
● Starting Self-Diagnostic Function While pressing the BASS + and SPEAKERS A keys, press the z (Power) key to turn on the power, and release those 2 keys. The self-diagnostic function mode is activated. Keys of this unit
“ ” (Power) indicator
R-S202/R-S202D
“ ” (Power) key
While pressing these keys, turn on the power.
● Starting Self-Diagnostic Function in the protection cancel mode If the protection function works and causes hindrance to troubleshooting, cancel the protection function by the procedure below, and it will be possible to enter the self-diagnostic function mode. (The protection functions other than the excess current detect function will be disabled.) While pressing the BASS + and SPEAKERS A keys, press the z (Power) key to turn on the power and keep pressing those 2 keys and z (Power) key for 3 seconds or longer. The self-diagnostic function mode is activated with the protection functions disabled. In this mode, the SLEEP segment of the FL display flashes to indicate that the mode is self-diagnostic function mode with the protection functions disabled. CAUTION! Using this unit with the protection function disabled may cause further damage to this unit. Use special care for this point when using this mode.
● Canceling Self-Diagnostic Function 1.
Before canceling self-diagnostic function, execute setting for 5. FACTORY PRESET menu. (Memory initialization inhibited or Memory initialized). *
2.
20
In order to keep the user memory preserved, be sure to select PRESET INHIBIT (Memory initialization inhibited).
Press the z (Power) key to turn off the power.
R-S202/R-S202D
● Display provided when Self-Diagnostic Function started The display is as described below depending on the situation when the power to this unit is turned off.
1. When the power is turned off by usual operation: NO PROTECT is displayed. Then 1. VERSION/SUM is displayed in a few seconds. Opening message
Main menu display
NO PRT
VER A01 U After a few seconds
R-S202/R-S202D
2. When the protection function worked to turn off the power: The information of protection function which worked at that time is displayed. Then 1. VERSION/SUM is displayed in a few seconds. Note: At that time if you restart the self-diagnostic function after turning off the power once, NO PROTECT will be displayed. That is because that situation is equal to 1. When the power is turned off by usual operation: . However history of the protection function is stored in memory as backup data. For details, refer to 7. PROTECTION HISTORY menu. 2-1.
When there is a history of protection function due to excess current.
I PRT Display: The Power indicator is flashing. Cause: An excessive current flowed through the power amplifier. Supplementary information: As current of the power amplifier is detected, the abnormal channel can be identified by checking the current detect transistor. Turning on the power without correcting the abnormality will cause the protection function to work immediately and the power supply will instantly be shut off. Notes: • Applying the power to this unit without correcting the abnormality can be dangerous and cause additional circuit damage. To avoid this, if protection function due to excess current works 1 time, the power will not turn on even when the “z” (Power) key is pressed. In order to turn on the power again, disconnect the power cable of this unit from the AC outlet once and then reconnect it again. • The output transistors in each amplifier channel should be checked for damage before applying power to this unit. • Amplifier current should be monitored by measuring DC voltage across the emitter resistors for each channel.
21
R-S202/R-S202D
2-2.
When the protection function worked due to abnormal DC output.
DC xxxL
H: Displayed when the voltage is HIGHER than upper limit L: Displayed when the voltage is LOWER than lower limit xxx: A/D conversion value of voltage at the moment when the protection function worked (Reference voltage: 3.3 V = 255)
Cause: DC output of the power amplifier is abnormal. Supplementary information: The protection function worked due to a DC voltage appearing at the speaker terminal. A cause could be a defect in the amplifier. Turning on the power without correcting the abnormality will cause the protection function to work in 3 seconds and the
R-S202/R-S202D
power supply will be shut off. 2-3.
When the protection function worked due to abnormal voltage in the power supply section.
PS xxxH
H: Displayed when the voltage is HIGHER than upper limit L: Displayed when the voltage is LOWER than lower limit xxx: A/D conversion value of voltage at the moment when the protection function worked (Reference voltage: 3.3 V = 255)
Cause: The voltage in the power supply section is abnormal. Supplementary information: The protection function worked due to a defect or overload in the power supply. Turning on the power without correcting the abnormality will cause the protection function to work in 1 seconds and the power supply will be shut off. Notes: • Applying the power to this unit without correcting the abnormality can be dangerous and cause additional circuit damage. To avoid this, if “PS” and “DC” protection function works 3 times consecutively, the power will not turn on even when the “z” (Power) key is pressed. In order to turn on the power again, disconnect the power cable of this unit from the AC outlet once and then reconnect it again. • The output transistors in each amplifier channel should be checked for damage before applying power to this unit. • Amplifier current should be monitored by measuring DC voltage across the emitter resistors for each channel. 2-4. When the protection function worked due to excessive heatsink/bridge diode temperature.
TA xxxH
H: Displayed when the voltage is HIGHER than upper limit L: Displayed when the voltage is LOWER than lower limit xxx: A/D conversion value of voltage at the moment when the protection function worked (Reference voltage: 3.3 V = 255) TA: Heatsink TB: Bridge diode (D113 on MAIN P.C.B.)
Cause: The temperature of the heatsink/bridge diode (D113) is excessive. Supplementary information: The protection function worked due to the temperature limit being exceeded. Causes could be poor ventilation or a defect related to the thermal sensor. Turning on the power without correcting the abnormality will cause the protection function to work in 1 second and the power supply will be shut off.
22
R-S202/R-S202D
● History of protection function When the protection function has worked, its history is stored in memory as backup data. Even if no abnormality is noted while servicing the unit, an abnormality which has occurred previously can be defined as long as the backup data has been stored. For details, refer to 7. PROTECTION HISTORY menu.
● Operation procedure of Main menu and Sub-menu Each item has a main menu, each of which has sub-menu items. a
Main menu selection Select the main menu using INPUT a (forward) and INPUT
(reverse) keys. R-S202/R-S202D
Sub-menu selection Select the sub-menu using TREBLE + (forward) and TREBLE – (reverse) keys. Keys of this unit Sub-menu selection
Reverse
Forward
Main menu selection
Reverse
Forward
● Functions in Self-Diagnostic Function mode In addition to the self-diagnostic function menu items, functions listed below are available. • Power ON/OFF • Master volume • SPEAKERS A ON/OFF * Functions related to the tuner and the set menu are not available.
● Initial settings when Self-Diagnostic Function started The following initial settings are used when self-diagnostic function is started. When self-diagnostic function is canceled, these settings are restored to those before starting self-diagnostic function. • Master volume:
60
• Input:
CD
• SPEAKER:
SPEAKERS A on
23
R-S202/R-S202D
● Details of Self-Diagnostic Function menu 1. VERSION/CHECK SUM This menu is used to display the firmware version and checksum. The checksum is obtained by adding the data at every 8-bit and expressing the result as a 4-digit hexadecimal notation. *
Numeric values in the figure are given as reference only. 1-1.
VER A10 U
FIRMWARE VERSION The firmware version of the microprocessor (IC203 on MAIN (1) P.C.B.) and destination are displayed.
R-S202/R-S202D
Not for service.
SUM 060C
R -U(013)
1-2.
FIRMWARE CHECKSUM The checksum value of the microprocessor (IC203 on MAIN (1) P.C.B.) is displayed.
1-3.
MODEL/DESTINATION The model name and destination are displayed. Not for service. Destination: U (U, C), R, T, A, B, G, L Model Model name
B 3.05
1-4.
R (R-S202) RD (R-S202D)
BLUETOOTH VERSION The firmware version of the Bluetooth module is displayed.
D N/A
24
1-5.
DAB VERSION (R-S202D) The firmware version of the DAB module is displayed.
R-S202/R-S202D
2. DISPLAY CHECK This menu is used to check operation of the FL display. Using the sub-menu, the display varies as shown below. FL display INITIAL DISPLAY
2-2.
ALL SEGMENT OFF
2-3.
ALL SEGMENT ON
R-S202/R-S202D
2-1.
* After check, change to next sub-menu at once. If you turn ON all segments for a long period, it may cause trouble.
Segment conditions of the FL driver and the FL tube are checked by turning ON and OFF all segments.
25
R-S202/R-S202D
3. Bluetooth The infomation of the Bluetooth module is displayed. 3-1.
Bluetooth ADDRESS The address of the Bluetooth module is displayed.
3481F43-2.
Bluetooth LOOPBACK Not for service.
B UART NG 3-3.
Bluetooth NAME
R-S202/R-S202D
The writing of memory is checked in Bluetooth module.
B NAME OK OK: Normal NG: Writing abnormal --: Checking
4. DAB Not for service. 4-1.
SIGNAL QUALITY
D SIQ N/A
5. FACTORY PRESET This menu is used to reserve/inhibit initialization of the back-up IC.
PRST INHI
3-1.
PRESET INHIBIT (Initialization inhibited) Initialization of the back-up IC is not executed. Select this sub-menu to protect the values set by the user.
PRST RSRV
3-2.
PRESET RESERVED (Initialization reserved) Initialization of the back-up IC is reserved. (Actual initialization is executed when the power is turned on next.) To reset to the original factory settings or to reset the backup IC, select this sub-menu and press the z (Power) key to turn off the power.
CAUTION: Before setting to the PRESET RESERVED, write down the existing preset memory content of the tuner. (This is because setting to the PRESET RESERVED will cause the user memory content to be erased.)
26
R-S202/R-S202D
6. AD DATA CHECK This menu is used to display the A/D conversion value of the microprocessor which detects panel keys and protection functions by using the sub-menu. When 6-6. KEY sub-menu is selected, keys become inoperable due to detection of the values of all keys. However, it is possible to advance to the next menu by pressing the ▲ (forward) key or ▼ (reverse) key on the remote control. * Numeric values in the figure are given as reference only. 6-1.
PS Power supply voltage (PS) protection detection. The voltage at 44 pin (PRPS) of IC203 is displayed. Normal value: 113 to 174 (Reference voltage: 3.3 V = 255) * If PS becomes out of the normal value range, the protection function works to turn off the power.
6-2.
R-S202/R-S202D
PS
148
DC Power amplifier DC (DC voltage) output is detected. The voltage at 42 pin (PRD) of IC203 is displayed. Normal value: 27 to 136 (Reference voltage: 3.3 V = 255) * If DC becomes out of the normal value range, the protection function works to turn off the power.
DC 6-3.
088
TEMPERATURE A Temperature of the heatsink is detected. The voltage at 43 pin (THM1) of IC203 is displayed. Normal value: 15 to 134 (Reference voltage: 3.3 V = 255) * If TA becomes out of the normal value range, the protection function works to turn off the power.
TA 6-4.
071
TEMPERATURE B Temperature of the bridge diode is detected. The voltage at 2 pin (THM2) of IC203 is displayed. Normal value: 15 to 130 (Reference voltage: 3.3 V = 255) * If TB becomes out of the normal value range, the protection function works to turn off the power.
TB
237
27
R-S202/R-S202D
6-5.
DESTINATION The destination is displayed.
DEST
6-6.
xxx
KEY0 / KEY1 Panel key is detected. KEY0: The voltage at 40 pin (KEY0) of IC203 is displayed. KEY1: The voltage at 41 pin (KEY1) of IC203 is displayed. When the A/D conversion value of the panel key becomes out of the specified range, normal operation will not be available.
R-S202/R-S202D
In that case, check the constant of voltage dividing resistor, solder condition, etc. Refer to table. * When 6-6. KEY menu is selected, keys become inoperable due to detection of the values of all keys. However, it is possible to advance to the next menu by pressing the ▲ (forward) key or ▼ (reverse) key on the remote control. (Reference voltage: 3.3 V = 255)
K-255,255 KEY1 KEY0
KEY0
Display
000 – 011
INPUT a
000 – 011
TUNING
012 – 032
INPUT
a
28
Display
KEY1
012 – 032
TUNING
033 – 054
TREBLE +
033 – 054
PRESET
055 – 079
TREBLE –
055 – 079
PRESET
080 – 107
BASS +
080 – 107
BAND
108 – 134
BASS –
108 – 134
MEMORY
135 – 160
̶
135 – 160
FM MODE
161 – 187
SPEAKER A
188 – 214
SPEAKER B
R-S202/R-S202D
7.
PROTECTION HISTORY This menu is used to display the history of protection function. When the SPEAKERS B key is pressed, the protection history being displayed will be cleared. * Numeric values in the figure are given as reference only.
1 PS xxxH
7-1. H: L:
HISTORY 1 Displayed when the voltage is HIGHER than upper limit Displayed when the voltage is LOWER than lower limit
xxx: A/D conversion value of voltage at the moment when the protection function worked (Reference voltage: 3.3 V = 255)
7-2.
HISTORY 2
3 TA xxxH
7-3.
HISTORY 3
4 NO PRT
7-4.
HISTORY 4
R-S202/R-S202D
2 DC xxxL
8. POWER OFF FACTOR HISTORY This menu is used to display the history of power off factor.
6-1 PANEL
8-1. LAST
Power off factor are as follows. 6-x PANEL 6-x REM
6-2 REM
8-2. HISTORY 1
6-3 SLEEP
8-3. HISTORY 2
6-4 APS
8-4. HISTORY 3
6-5 ---
8-5. HISTORY 4
z (Power) key of this unit z (Power) key on the remote control
6-x SLEEP
SLEEP timer
6-x APS
Auto Power Standby
6-x PRT
Protection
6-x AC
AC OFF
6-x BT
Bluetooth no operation
6-x ---
No history
29
R-S202/R-S202D
■ DISPLAY DATA ● V501 : 010ST027GNK (MAIN P.C.B.) 32
1
PATTERN AREA
● PIN CONNECTION
R-S202/R-S202D
Pin No. 32 Connection F2
31 F2
30 NP
29 1G
24 6G
23 7G
22 8G
21 9G
Pin No. 20 19 18 17 16 15 14 13 12 Connection 10G P16 P15 P14 P13 P12 P11 P10 P9
11 P8
10 P7
9 P6
Note : 1) Fn ..... Filament pin
28 2G
27 3G
26 4G
2) nG ..... Grid pin
25 5G
3) Pn ..... Anode pin
8 P5
7 P4
6 P3
5 P2
4 P1
3 NP
2 F1
4) NP ..... No pin
● GRID ASSIGNMENT 1G s1
s2 a
h
j
f
b
g 2G
3G
4G
5G
6G
7G
8G
9G
10G
r
m e
c p d (2G–10G)
● ANODE CONNECTION
30
P1
1G MHz
2G – 10G s2
P2
kHz
s1
P3 P4 P5 P6 P7 P8 P9 P10 P11 P12 P13 P14 P15 P16
ST SLEEP TUNED SP A SP B MEMORY PRESET
a b f h j k g m c e r p n d
k
n
1 F1
R-S202/R-S202D
■ IC DATA IC203: R5F100JFAFA (MAIN (1) P.C.B.) Microprocessor * No replacement part available. TIMER ARRAY UNIT (8ch)
PORT 0
4
P00 to P03
TI00/P00 TO00/P01
ch0
PORT 1
8
P10 to P17
PORT 2
8
P20 to P27
PORT 3
2
P30, P31
PORT 4
2
P40, P41
PORT 5
2
P50, P51 P60 to P63
TI01/TO01/P16
ch1
TI02/TO02/P17 (TI02/TO02/P15)
ch2
TI03/TO03/P31 (TI03/TO03/P14)
ch3
(TI04/TO04/P13)
ch4
(TI05/TO05/P12)
ch5
(TI06/TO06/P11)
ch6
PORT 6
4
TI07/TO07/P41 (TI07/TO07/P10) RxD2/P14 (RxD2/P76)
ch7
PORT 7
8
PORT 12
WINDOW WATCHDOG TIMER 12-BIT INTERVAL TIMER
PORT 14
UART0
RxD1/P03 TxD1/P02
UART1 CSI00
IIC01
SCL11/P30 SDA11/P50
IIC11
VDD
VSS TOOLRxD/P11, TOOLTxD/P12
CLOCK OUTPUT CONTROL
CSI21
2
XT1/P123
ON-CHIP
XT2/EXCLKS/P124
VOLTAGE REGULATOR
REGC
PCLBUZ0/P140 (PCLBUZ0/P31), PCLBUZ1/P15
RxD2/P14 (RxD2/P76) INTP0/P137 2
CRC
INTERRUPT CONTROL
2
INTP1/P50, INTP2/P51 INTP3/P30, INTP4/P31 INTP5/P16 INTP6/P140
4
INTP8/P74 to INTP11/P77
P16/TI01/TO01/INTP5/(RXD0)
P15/PCLBUZ1/SCK20/SCL20/(TI02)/(TO02)
P14/RxD2/SI20/SDA20/(SCLA0)/(TI03)/(TO03)
P13/TxD2/SO20/(SDAA0)/(TI04)/(TO04)
P12/SO00/TxD0/TOOLTxD/(TI05)/(TO05)
P146
BCD ADJUSTMENT
P11/SI00/RxD0/TOOLRxD/SDA00/(TI06)/(TO06)
IIC21
RESET X1/P121 X2/EXCLK/P122
OSCILLATOR
DIRECT MEMORY ACCESS CONTROL
P147/ANI18
IIC20
SCL21/P70 SDA21/P71
SCLA0/P60(SCLA0/P14)
MULTIPLIER& DIVIDER, MULITIPLYACCUMULATOR
CSI20
SCL20/P15 SDA20/P14
TOOL0/P40
ON-CHIP DEBUG
SDAA0/P61(SDAA0/P13)
BUZZER OUTPUT
UART2 LINSEL
P10/SCK00/SCL00/(TI07)/(TO07)
SCK20/P15 SI20/P14 SO20/P13 SCK21/P70 SI21/P71 SO21/P72
POR/LVD CONTROL
HIGH-SPEED
SERIAL ARRAY UNIT1 (2ch) TxD2/P13(TxD2/P77)
KR0/P70 to KR7/P77
SYSTEM CONTROL
SERIAL INTERFACE IICA0
RxD2/P14(RxD2/P76)
8
P30/INTP3/RTC1HZ/SCK11/SCL11
IIC00
KEY RETURN
ANI16/P03, ANI17/P02, ANI18/P147, ANI19/P120 AVREFP/P20 AVREFM/P21
RESET CONTROL
CSI11
SCL01/P75 SDA01/P74
4
POWER ON RESET/ VOLTAGE DETECTOR
RAM CSI01
SCL00/P10 SDA00/P11
A/D CONVERTER DATA FLASH MEMORY
P50/INTP1/SI11/SDA11
SCK11/P30 SI11/P50 SO11/P51
CODE FLASH MEMORY
RL78 CPU CORE
P51/INTP2/SO11
SCK00/P10 SI00/P11 SO00/P12 SCK01/P75 SI01/P74 SO01/P73
ANI0/P20 to ANI7/P27
8
SERIAL ARRAY UNIT0 (4ch) RxD0/P11(RxD0/P16) TxD0/P12(TxD0/P17)
P140, P146, P147
3
REAL-TIME CLOCK
R-S202/R-S202D
RTC1HZ/P30
P121 to P124 P130 P137
PORT 13
P17/TI02/TO02/(TXD0)
LOW-SPEED ON-CHIP OSCILLATOR
P70 to P77 P120
4
39 38 37 36 35 34 33 32 31 30 29 28 27 26
P70/KR0/SCK21/SCL21
P26/ANI6
41
25
P71/KR1/SI21/SDA21
P25/ANI5
42
24
P72/KR2/SO21
P24/ANI4
43
23
P73/KR3/SO01
P23/ANI3
44
22
P74/KR4/INTP8/SI01/SDA01
P22/ANI2
45
21
P75/KR5/INTP9/SCK01/SCL01
P21/ANI1/AVREFM
46
20
P76/KR6/INTP10/(RXD2)
P20/ANI0/AVREFP
47
19
P77/KR7/INTP11/(TXD2)
P130
48
18
P31/TI03/TO03/INTP4/(PCLBUZ0)
P03/ANI16/RxD1
49
17
P63
P02/ANI17/TxD1
50
16
P62
P01/TO00
51
15
P61/SDAA0
P00/TI00
52
14
P60/SCLA0
VSS
VDD
REGC
P121/X1
P122/X2/EXCLK
8 9 10 11 12 13
P137/INTP0
RESET
6 7
P123/XT1
5
P124/XT2/EXCLKS
3 4
P40/TOOL0
2
P41/TI07/TO07
1
P120/ANI19
40
P140/PCLBUZ0/INTP6
P27/ANI7
31
R-S202/R-S202D
32
Port Name
Function Name
I/O Related Power Supply
Detail of Function
OFF
ON
1
P140/PCLBUZ0/INTP6
HPRY
O
O
HP relay (LOW = OFF)
2
P120/ANI19
THM2
I
I
Temperature protection detection
3
P41/TI07/TO07
BT_MFB
O
O
Bluetooth Multi-Function Push Button Key
4
P40/TOOL0
TOOL0
I
I
For E1 debugging
5
RESET
N_RST
I
I
For debugging
6
P124/XT2/EXCLKS
(Vacant)
7
P123/XT1
(Vacant)
8
P137/INTP0
REM
I
IRQ
9
P122/X2/EXCLK
(Vacant)
IR light receiving unit
10
P121/X1
BT_AMP_EN
I
I
Bluetooth Amp Enable (Mute ON/OFF)
11
REGC
REGC
I
I
Regulator (Connected to VSS via capacitor)
12
VSS
VSS
I
I
GND
13
VDD
VDD
I
I
+5V power supply
14
P60/SCLA0
TU_SCL
I
I2C
Tuner pack
15
P61/SDAA0
TU_SDA
I
I2C
Tuner pack
16
P62
TU_N_RST
O
O
Tuner pack
17
P63
(Vacant)
18
P31/TI03/TO03/INTP4/(PCLBUZ0)
PRI
I
I
19
P77/KR7/INTP11/(TXD2)
TU_GPIO2
I
IRQ
Tuner pack
I protection detection
20
P76/KR6/INTP10/(RXD2)
(Vacant)
21
P75/KR5/INTP9/SCK01/SCL01
EVOL_SCL
I
I2C
VOL IC
22
P74/KR4/INTP8/SI01/SDA01
EVOL_SDA
I
I2C
VOL IC
23
P73/KR3/SO01
FL_STB
O
O
FL Driver
24
P72/KR2/SO21
FL_MOSI
O
SPI
FL Driver
25
P71/KR1/SI21/SDA21
FL_MISO
O
SPI
FL driver (spare)
26
P70/KR0/SCK21/SCL21
FL_SCK
O
SPI
FL Driver
27
P30/INTP3/RTC1HZ/SCK11/SCL11
PRY
O
O
28
P50/INTP1/SI11/SDA11
MPSW
I
IRQ
Main power SW (Tact SW)
29
P51/INTP2/SO11
PWR_DET
I
IRQ
Power detect (LOW = AC-OFF)
Power relay control
30
P17/TI02/TO02/(TXD0)
VOL_RA
I
I
Volume encoder clockwise
31
P16/TI01/TO01/INTP5/(RXD0)
VOL_RB
I
I
Volume encoder counterclockwise
32
P15/PCLBUZ1/SCK20/SCL20/(TI02)/(TO02)
(Vacant)
33
P14/RxD2/SI20/SDA20/(SCLA0)/(TI03)/(TO03)
REC_N_MUTE
O
O
REC OUT mute (LOW = MUTE ON)
34
P13/TxD2/SO20/(SDAA0)/(TI04)/(TO04)
PRE_N_MUTE
O
O
PRE OUT mute (LOW = MUTE ON)
35
P12/SO00/TxD0/TOOLTxD/(TI05)/(TO05)
(Vacant)
36
P11/SI00/RxD0/TOOLRxD/SDA00/(TI06)/(TO06)
(Vacant)
37
P10/SCK00/SCL00/(TI07)/(TO07)
PLED
O
O
Power LED (LOW = OFF)
38
P146
3.3S_PON
O
O
Power supply (VFD driver power supply) Model discrimination (LOW=R-S202 / HIGH=R-S202D)
39
P147/ANI18
MODEL
I
I
40
P27/ANI7
KEY0
I
I
INPUT (
41
P26/ANI6
KEY1
I
I
SPEAKERS (A, B) / FM MODE / MEMORY / BAND / PRESET (<, >) / TUNING (<<, >>)
42
P25/ANI5
PRD
I
I
DC protection detection (AMP DC / Voltage detection)
43
P24/ANI4
THM1
I
I
Temperature protection detection (Thermal detection)
I
I
PS protection detection (Power supply / Power voltage detection)
, a) / BASS (+, -) / TREBLE (+, -)
a
R-S202/R-S202D
Pin No.
44
P23/ANI3
PRPS
45
P22/ANI2
TEST
46
P21/ANI1/AVREFM
VREFM
I
I
Analog reference voltage minus
47
P20/ANI0/AVREFP
VREFP
I
I
Analog reference voltage plus
48
P130
SPBRY
O
O
Speaker B relay ON/OFF (LOW = OFF)
49
P03/ANI16/RxD1
BT_MISO
I
UART
50
P02/ANI17/TxD1
BT_MOSI
O
UART
ISSC BT Module
51
P01/TO00
BT_N_RST
O
O
Bluetooth Reset
52
P00/TI00
SPARY
O
O
Speaker A relay ON/OFF (LOW = OFF)
ISSC BT Module
R-S202/R-S202D Key detection for A/D port Key input (A/D) pull-up resistance 10 k-ohms + 1.0 k Ω
+ 1.0 k Ω
+ 1.5 k Ω
+ 2.2 k Ω
+ 3.3 k Ω
+ 4.7 k Ω
Detected voltage value at 40 pin
0 – 0.22 V
0.23 – 0.64 V
0.65 – 1.06 V
1.07 – 1.55 V
1.56 – 2.09 V
2.10 – 2.62 V
2.63 – 3.12 V
A/D value (3.3 V=255)
000 – 011
012 – 032
033 – 054
055 – 079
080 – 107
108 – 134
135 – 160
KEY0
INPUT a
INPUT a
TREBLE +
TREBLE –
BASS +
BASS –
0Ω
+ 1.0 k Ω
+ 1.0 k Ω
+ 1.5 k Ω
+ 2.2 k Ω
+ 3.3 k Ω
+ 4.7 k Ω
Detected voltage value at 41 pin
0 – 0.14 V
0.15 – 0.42 V
0.43 – 0.7 V
0.71 – 1.02 V
1.03 – 1.38 V
1.39 – 1.73 V
1.74 – 2.07 V
A/D value (3.3 V=255)
000 – 011
012 – 032
033 – 054
055 – 079
080 – 107
108 – 134
135 – 160
TUNING
TUNING
PRESET
PRESET
BAND
MEMORY
FM MODE
+ 7.5 k Ω
+ 15 k Ω
Detected voltage value at 41 pin
2.08 – 2.41 V
2.42 – 2.77 V
A/D value (3.3 V=255)
161 – 187
188 – 214
KEY1
SPEAKER A
SPEAKER B
KEY1
R-S202/R-S202D
0Ω
33
R-S202/R-S202D
R-S202/R-S202D
MEMO
34
A
B
C
D
E
F
G
H
I
J R-S202/R-S202D
1
■ BLOCK DIAGRAMS
Audio Section Block Diagram
BT_N_RST BT_AMP_EN BT_MFB
Bluetooth Module (BM20)
2
LINE 1 LINE 2
TONE CONTROL
CD
VOLUME
3
INPUT SELECTOR
FM/AM
INT CLK:428.7MHz
INT CLK:72MHz
X
POWER AMPLIFIER
SPARY
RY102
SPBRY
RY103
HPRY
RY101
PRE_N_MUTE
A SPEAKERS B PHONES
LINE 3 IC202 4
REC
Vol IC
X
27 28
BD3491FS
EVOL_SCL EVOL_SDA
REC_N_MUTE
5
FL Driver FL Display
Remote Control
HT16515
PRD PRI
FL_MOSI FL_MISO
REM MPSW PWR_DET TU_GPIO2
KEY0 KEY1 PRD THM1 THM2 PRPS DEST
REM
6
Volume
Push Key
MVOL_RA MVOL_RB KEY0 KEY1 MPSW
INTP0 INTP1 INTP2 INTP11
N_RST
MPSW
40 41 42 43 2 44 45 51
ANI7 ANI6 ANI5 ANI4 ANI19 ANI3 ANI2
<serial> UART1 I2CA0 I2C01 SPI
BT Module Tuner VOL IC FL Driver
Main Power Supply (Main Transformer)
PRY
IC203
Microprocessor R5F100JFAFA Internal CLK:32MHz
PWR_DET N_RST
Standby Power Supply (Sub Transformer)
AC IN
RESET
Force Reset
N_RST
7 35
A
B
C
D
E
F
G
H
I
J
R-S202/R-S202D
Power Supply Section Block Diagram
1
IC1
IC203
+3.3M
Microprocessor
Sub Transformer
Q209
2
+3.3M
Microprocessor (IC203), Remote, Key Input, Rotary Encoder
+3.3S
THM, FL Driver, Control circuit around Microprocessor
+B
Power Amplifier
-B
Power Amplifier
-24VP
FL Driver
+8.44V
Volume IC
+8.44V
Bluetooth OP AMP
+3.3T
Tuner
+3.3BT
Bluetooth
F1
FL Filament
F2
FL Filament
RY1 3.3S_PON
PRY
S1 RY1
3
F1
D7
120V / 230V / 220・240V / 110-120・220-240V / 50・60 Hz
4
Q123
15V
Q124
5
Q121
6 S2
7 36
A
B
C
D
E
F
G
H
I
J R-S202/R-S202D
1
■ WIRING DIAGRAM CB501
• OVERALL ASSEMBLY CB902
MAIN (1)
(R-S202D) to MAIN (8) (CB602)
2
MAIN (5) Top view R model
3
Tie AC cable and all wire from power transformer together.
SWITCH
CB3
CB4
Top view
CB102 CB204
CB202
Tie AC cable and all wire from power transformer together.
R model
CB7
CB4
Side view
R-S202: TUNER Module R-S202D: MAIN (8) P.C.B. + DAB Module
CB7 to MAIN (1) (CB102)
MAIN (1)
CB204
W102
CB101 Avoid all wire from touching heatsink.
4 POWER TRANSFORMER
MAIN (7)
CB103 W250
POWER TRANSFORMER
MAIN (5) Stick FFC 18p with MAIN (8) P.C.B. 60 mm
CB401
5 View A
CB502
MAIN (6)
MAIN (2)
W501
to MAIN (2) (CB501) to BTCARD (CB902)
Avoid wire from touching power transformer. 60 mm
6
Front panel (View A)
MAIN (6)
MAIN (4)
MAIN (3)
MAIN (2) W502B
W503A
W502A
W503B
to MAIN (1) (CB204) CB501
CB02 CB902
7 BTCARD
37
A
B
C
D
E
F
G
H
I
J
R-S202/R-S202D
■ PRINTED CIRCUIT BOARDS
1
MAIN (1)
Safety measures • Some internal parts in this product contain high voltages and are dangerous. Be sure to take safety measures during servicing, such as wearing insulating gloves. • Note that the capacitors indicated below are dangerous even after the power is turned off because an electric charge remains and a high voltage continues to exist there. Before starting any repair work, connect a discharging resistor (5 k-ohms/10 W) to the terminals of each capacitor indicated below to discharge electricity. The time required for discharging is about 30 seconds per each. C140, C143 and C149 on MAIN (1) P.C.B.
(Side A)
安全対策 ・ この製品の内部には高電圧部分があり危険です。修理の際は、絶縁性の手袋を使用するなどの安全対策を行ってください。 ・ 下記のコンデンサには電源を OFF にした後も電荷が残り、高電圧が維持されており危険です。修理作業前に放電用抵抗 (5 k Ω /10 W)を下記の各コンデンサの端子間に接続して放電してください。放電所用時間は各々約 30 秒間です。 MAIN(1)P.C.B. の C140、C143、C149
POWER TRANSFORMER
POWER cable
+
R
-
-
LINE L
CD
3 OUT L/R
+
IN L/R
2
1
L/R
L/R
T, A, G, L models
L/R
GND AOHPM GND BT_AMP_EN GND BT_MOSI GND
2
SPEAKERS A/B
NC BTAUDIO_L BTAUDIO_R BT_MFB UART_TX_IND BT_MISO BT_N_RST BT_3.3V
BT CARD (CB902)
Writing port CB201
CB102
CB5
CB6
CB7
CB4
3
CB202
GND +3.3V N_INT SDA
Lch Rch NC SCL N_RST
Power transformer
R-S202: AM/FM TUNER R-S202D: MAIN (8) (CB602)
CB204
4 W102
R model
U, C, T, A, G, L models
VPE 3.3M MG FL_STB FL_SCK M_PLED KEY0 MVOL_RA
-24V MG 3.3S FL_MISO FL_MOSI REM MPSW KEY1 MVOL_RB
CB101
MAIN (2) (CB501)
HPR E E HPL
5 MAIN (6) (CB401)
R model CB103
MG 3.3S THM
6
MAIN (7) (W250)
5 k-ohms 10 W
7 38
POWER TRANSFORMER
5 k-ohms
5 k-ohms
10 W
10 W
• Semiconductor Location Ref no. Location D113 E6 D7 C4 Q105 C5 Q106 F5 Q109 C5 Q110 C5 Q111 F5 Q112 F5
A
B
C
D
E
F
G
H
I
J R-S202/R-S202D
1
MAIN (1)
(Side B)
2
T, A, G, L models
R model
3
1
16 IC202
32
1
4
17 IC102
8
5
4
13 14 1 52
IC203
26 27
40 39
1
5 R model
6
7
3 IC1
5
4
• Semiconductor Location Ref no. Location D1 B5 D10 B4 D101 G4 D102 I4 D103 D5 D104 G5 D105 C6 D106 F6 D107 G4 D108 F5 D109 D4
Ref no. Location D110 C3 D111 F5 D112 F5 D114 E3 D115 F5 D117 D3 D119 F5 D120 F4 D125 D4 D126 D4 D127 D5 D128 G5 D2 B5 D202 G5 D203 H5 D204 H5 D207 H4 D3 B5 D4 B4 D5 B4 D6 B5 D8 B4 D9 B4 IC1 B5 IC102 G4 IC202 G3 IC203 H4 Q1 B5 Q101 D5 Q102 F5 Q103 D5 Q104 F5 Q107 C5 Q108 F5 Q117 C6 Q118 F6 Q119 G6 Q120 F4 Q121 G5 Q122 I4 Q123 D5 Q124 F5 Q125 C4 Q126 F4 Q128 C4 Q129 F4 Q131 F5 Q133 C4 Q2 B4 Q201 F3 Q202 F3 Q203 F4 Q204 G4 Q205 I3 Q206 I3 Q208 H5 Q209 H5 Q3 B4 Q4 B5 Q5 B5 Q6 B5 Q7 B5 Q8 C5
39
A
B
C
D
E
F
G
H
I
J
R-S202/R-S202D 1
(Side A)
CB502
MAIN (2)
2
CB501
POWER TRANSFORMER
W502A
Remote control sensor MG SW_SPAB MP_SW 3.3M
MVOL_RA KEY0 M_PLED FL_SCK FL_STB MG 3.3M VPE
STANDBY/ON indicator
MVOL_RB KEY1 MPSW REM FL_MOSI FL_MISO 3.3S MG -24V
MAIN (1) (CB204)
3
FM MODE
chassis
MEMORY
BAND
PRESET
TUNING
4
W503A
W501
–
BASS
+
–
TREBLE
+
INPUT
MAIN (3)
(Side A)
(Side A)
3.3M MP_SW SW_SPAB MG
MAIN (4)
5
3.3M VOL_RA VOL_RB MG SW_PDRT FG
W502B
6
(Power)
A
SPEAKERS
VOLUME W503B
+3.3M VOL_RA VOL_RB MG SW_PDRT FG
B • Semiconductor Location Ref no. Location D511 D2 D514 G2
7 40
A
B
C
D
E
F
G
H
I
J R-S202/R-S202D
1
MAIN (2)
(Side B)
2
22
12
23
IC501
11
33 34
1
44
3
4
5
MAIN (4) MAIN (3)
(Side B)
(Side B)
6
7
• Semiconductor Location Ref no. Location D501 D2 D502 D2 IC501 F2 Q502 E2 Q503 D3 Q504 G2
41
A
B
C
D
E
F
G
H
I
J
R-S202/R-S202D 1
MAIN (5)
MAIN (6)
(Side A)
MAIN (7)
(Side A)
(Side A)
PHL HPR HPE HPL
VCC OUT GND
IC250
CB401
2
MAIN (1) (W102)
W250
MG 3.3S THM
3
MAIN (1)
(CB101)
PHONES
4
MAIN (8)
(Side A)
(R-S202D) 5
CB602
Lch GND Rch +3.3V NC NC SCL SDA N_RST
6
MAIN (1) (CB202)
7 42
• Semiconductor Location Ref no. Location IC250 I2
A
B
C
D
E
F
G
H
I
J R-S202/R-S202D
1
MAIN (5)
(Side B)
MAIN (6)
MAIN (7)
(Side B)
(Side B)
2
3
4
MAIN (8) (R-S202D)
(Side B)
SWITCH
(Side A)
R model 5
VOLTAGE SELECTOR 220–230V
110–120V
YELLOW
PURPLE CB3
POWER TRANSFORMER
6
ORANGE
RED
7 43
R-S202/R-S202D
■ PIN CONNECTION DIAGRAMS • ICs BD3491FS-E2
HT16515-44LQFP 33
17
LM61CIZ
NJM2904M
22
8 +VS VOUT GND
12
44 11
1
27
40
16
1
R1190H033B-T1-FE
39
23
34
32
R5F100JFAFA
26
1 3
4
5
1
4 14
52 13
1
• Diodes 1SS352 TE
BAV103
D5SBA60 5A 600V
DB105
Anode
Anode
–
Cathode
Cathode
+ AC
– AC
F3A Anode
+
AC AC
Cathode
UDZV2.4B UDZV3.9B UDZV4.7B UDZV9.1B UDZV12B UDZV15B UDZV24B UDZV36B
Anode
Cathode
• Transistors 2N5401S-RTK/P
2N5551S-RTK/P 2SA1037K
C
2SA1037K Q,R,S 2SA1514K R,S 2SC3906K 2SD2704 K
E
DTC014EUBTL
E
B
B
B
KTA1661-Y-RTF/P KTA1664-Y-RTF/P KTC4376-Y-RTF/P
2SC5712
3LN01C-TB-E
D
E
B
2SC4468
C
C
C E B
2SC2412K 2SC2712-GR
C
S G
E
BC E
KTC3206Y-ATP
KTB631K Y, GR KTD600K-Y-U/PH
MCH6336-TL-E
4 3
6 3
2 1
1: IN 2: GND 3: OUT
B
1 C
E
E
44
CB
EC
B
1. Drain 2. Drain 3. Gate 4. Source 5. Drain 6. Drain
B
A
C
D
E
F
G
H
I
J
K
M
L
N
15
14
13
11
10
9
8
7
6
5
4
3
52806-1510
2
1
52045
Destination Part List +--------+---------------+-----------------+-----------------+-----------------+-----------------+-----------------+-----------------+ | sxx | LOCATION | UC | R | T | A | G | L | +--------+---------------+-----------------+-----------------+-----------------+-----------------+-----------------+-----------------+ | s1 | F1 | WQ21110 | WQ21110 | VV07180 | VV07180 | VV07180 | VV07180 | | | | 8A125V | 8A125V | T4.0AL250V | T4.0AL250V | T4.0AL250V | T4.0AL250V | +--------+---------------+-----------------+-----------------+-----------------+-----------------+-----------------+-----------------+ | s2 | J4 | X | X | VN50000 | VN50000 | VN50000 | VN50000 | | | | | | | | | | +--------+---------------+-----------------+-----------------+-----------------+-----------------+-----------------+-----------------+ | s3 | T1 | YF764A0 | YF765A0 | YF766A0 | YF766A0 | YF766A0 | YF766A0 | | | | YF764 | YF765 | YF766 | YF766 | YF766 | YF766 | +--------+---------------+-----------------+-----------------+-----------------+-----------------+-----------------+-----------------+ | s4 | R15 | X | RD35715 | X | X | X | X | | | | | 15K | | | | | +--------+---------------+-----------------+-----------------+-----------------+-----------------+-----------------+-----------------+ | s5 | R13 | X | RD35633 | X | X | X | X | | | | | 3.3K | | | | | +--------+---------------+-----------------+-----------------+-----------------+-----------------+-----------------+-----------------+ | s6 | Q6 | X | WC39760 | X | X | X | X | | | Q7 | | 2N5401S-RTK/P | | | | | +--------+---------------+-----------------+-----------------+-----------------+-----------------+-----------------+-----------------+ | s7 | Q8 | X | WC39830 | X | X | X | X | | | | | 2N5551S-RTK/P | | | | | +--------+---------------+-----------------+-----------------+-----------------+-----------------+-----------------+-----------------+ | s8 | Q5 | X | ZG24570 | X | X | X | X | | | | | KTA1661-Y-RTF/P | | | | | +--------+---------------+-----------------+-----------------+-----------------+-----------------+-----------------+-----------------+ | s10 | R14 | X | WW97570 | X | X | X | X | | | | | 47K | | | | | +--------+---------------+-----------------+-----------------+-----------------+-----------------+-----------------+-----------------+ | s11 | J2 | VN50000 | X | VN50000 | VN50000 | VN50000 | VN50000 | | | | | | | | | | +--------+---------------+-----------------+-----------------+-----------------+-----------------+-----------------+-----------------+ | s12 | D6 | X | WY16410 | X | X | X | X | | | | | UDZV12B | | | | | +--------+---------------+-----------------+-----------------+-----------------+-----------------+-----------------+-----------------+ | s13 | R11 | X | WW97570 | X | X | X | X | | | | | 47K | | | | | +--------+---------------+-----------------+-----------------+-----------------+-----------------+-----------------+-----------------+ | s14 | R7 | X | RD35710 | X | X | X | X | | | | | 10K | | | | | +--------+---------------+-----------------+-----------------+-----------------+-----------------+-----------------+-----------------+ | s15 | C10 | X | UR86710 | X | X | X | X | | | | | 10/50 | | | | | +--------+---------------+-----------------+-----------------+-----------------+-----------------+-----------------+-----------------+ | s16 | D8 | X | ZU12910 | X | X | X | X | | | | | F3A | | | | | +--------+---------------+-----------------+-----------------+-----------------+-----------------+-----------------+-----------------+ | s17 | C11 | X | WW19410 | X | X | X | X | | | C13 | | 0.1/100 | | | | | +--------+---------------+-----------------+-----------------+-----------------+-----------------+-----------------+-----------------+ | s18 | C14 | X | UR86610 | X | X | X | X | | | | | 1/50 | | | | | +--------+---------------+-----------------+-----------------+-----------------+-----------------+-----------------+-----------------+ | s24 | R16 | X | RD35810 | X | X | X | X | | | | | 100K | | | | | +--------+---------------+-----------------+-----------------+-----------------+-----------------+-----------------+-----------------+ | s101 | C157 | X | X | WN20010 | WN20010 | WN20010 | WN20010 | | | C158 | | | 0.01/100 | 0.01/100 | 0.01/100 | 0.01/100 | | | C160 | | | | | | | | | C161 | | | | | | | | | C162 | | | | | | | | | C173 | | | | | | | | | C174 | | | | | | | | | C175 | | | | | | | | | C176 | | | | | | | | | C189 | | | | | | | +--------+---------------+-----------------+-----------------+-----------------+-----------------+-----------------+-----------------+ | s102 | R197 | X | RD35710 | X | X | X | X | | | | | 10K | | | | | +--------+---------------+-----------------+-----------------+-----------------+-----------------+-----------------+-----------------+ | s103 | D119 | X | WY16520 | X | X | X | X | | | D120 | | UDZV36B | | | | | +--------+---------------+-----------------+-----------------+-----------------+-----------------+-----------------+-----------------+ | s104 | R186 | WW86390 | WW86320 | WW86390 | WW86390 | WW86390 | WW86320 | | | R191 | 330 | 82 | 330 | 330 | 330 | 82 | | | R196 | | | | | | | +--------+---------------+-----------------+-----------------+-----------------+-----------------+-----------------+-----------------+
CB102
GND
NC
0V
0V
1.33V
BTAUDIO_L
AOHPM
1.33V
BTAUDIO_R
GND
0V 1.33V
BT_MFB
0V
0V U A R T _ T X _ I N D 2.77V B T _ A M P _ E N
GND
BT_MISO
0V
3.25V
2.77V
BT_MOSI
0V G N D
3.57V C192
0.1/16 C153
10
3.25V
-24.8V
2
0
(Except RL Dest.)
R332
BTA_L
Lch
0V
9
R184
680
4.7K
CB7
0
0
J1
P40, P41
PORT 5
2
P50, P51
(TI04/TO04/P13)
ch4
(TI05/TO05/P12)
ch5
(TI06/TO06/P11)
ch6
PORT 6
4
P60, P63
TI07/TO07/P41 (TI07/TO07/P10) RxD2/P14 (RxD2/P76)
ch7
PORT 7
8
P70, P77
4
P121 to P124
3
P140, P146, P147
8
ANI0/P20 to AN17/P27
J4
12-BIT INTERVAL TIMER
C232
CODE FLASH MEMORY
RL78 Microprocessor CORE
SERIAL ARRAY UNIT0 (4ch)
DATA FLASH MEMORY
UART0 UART1
SCK00/P10 SI00/P11 SO00/P12
CSI00
SCK01/P75 SI01/P74 SO01/P73
CSI01
SCK11/P30 SI11/P50 SO11/P51
CSI11
SCL00/P10 SDA00/P11
IIC00
SCL01/P75 SDA01/P74
IIC01
SYSTEM CONTROL
IIC11
HIGH-SPEED ON-CHIP OSCILLATOR
KEY RETURN
POWER ON RESET/ VOLTAGE DETECTOR
RAM
VDD
SDAA0/P61(SDAA0/P13)
s103
D119
CLOCK OUTPUT CONTROL MULTIPLIER and DIVIDER MULITIPLYACCUMULATOR
RxD2/P14(RxD2/P76) INTP0/P137
CRC
INTERRUPT CONTROL
2
INTP1/P50 INTP2/P51
2
INTP3/P30, INTP4/P31 INTP5/P16 INTP0/P140
DIRECT MEMORY ACCESS CONTROL
4
INTP6/P74 to INTP11/P77
BCD ADJUSTMENT
2P10
R314 R315
C172
2P10
22K
10K
R316
2P10
UDZV15B
39K
0.1/100
R194
R323
D115
47K R192 C152
0.01(B)
46.9V R317
47.8V
47.8V
C167
C166
0.1/100
R220
PREOUT MUTE
R221
0.1/100
D113 D5SBA60
F3A
D126
D125
5 k-ohms 10 W
F3A
10/63
C197
IIC21
REGC
PCLBUZ0/P140 (PCLBUZ0/P31), PCLBUZ1/P15
2
46.2V
3.9
R179
100
R174
C142
47/50
120K
UDZV24B
4.7/50
C146
J102
R308
J5
no_use
SCL21/P70 SDA21/P71
45.8V
14.2V
–46.2V
KTA1664-Y-RTF/P
IIC20
XT2/EXCLKS/P124
VOLTAGE REGULATOR
IC250: LM61CIZ Temperature sensor
3.9
C10 1000P(B)
D120
s103 s102 Q126
2N5401S-RTK/P
Q120
2.4K R324
44V
Q123 -24.85V
SCL20/P15 SDA20/P14
XT1/P123
47.2V
-24.25V
–25.4V
SCLA0/P60(SCLA0/P14)
RESET X1/P121 X2/EXCLK/P122
SG
2N5401S-RTK/P Q131
J103
–26V
CSI21
TOOL0/P40
ON-CHIP DEBUG
VSS TOOL RxD/P11 TOOL TxD/P12
BUZZER OUTPUT
LINSEL
SCK21/P70 SI21/P71 SO21/P72
POR/LVD CONTROL
RESET CONTROL
UART2
CSI20
KR0/P70 to KR7/P77
8
R190
100P/100 R187
C170
C149
1000/63
UDZV9.1B
10K
R183
1.0K
100
R175
R178 D108
C147
10/50
D107
UDZV3.9B
no_use
AVREFE/P20 AVREFE/P21
RxD1/P03 TxD1/P02
SCK20/P15 SI20/P14 SO20/P13
ANI16/P03, ANI17/P02, ANI16/P147, ANI19/P120
4
A/D CONVERTER
RxD0/P11(RxD0/P16) TxD0/P12(TxD0/P17)
C288
3.3K
no_use s15
PORT 14
REAL-TIME CLOCK
RTC1HZ/P30
R197
10K
R225
For EVOL/ BT OP AMP 7mA +8.44V
C144
1000/10
470
R169
100
R168
C139
330/25
C287
0.1/16
Q124 KTC4376-Y-RTF/P
for TUNER/BT
C141
10/50
J104
P130 P137
PORT 13 LOW-SPEED ON-CHIP OSCILLATOR
2P10
D101
UDZV24B
62K
R200
33K
R307
4 T1
s4
R15
s14
R7 s24
9.04V
AGND
D6 R16
R14
s10
Q7 R11
9.12V
P120
PORT 12
WINDOW WATCHDOG TIMER
s2 3
1
3
4 2 Q5
Q6 s13 2200/25
C7
9.12V
J101
C9 D D
P30, P31
2
no_use
45.4V
CB103 H
1
E
2
H
3 VHI
to POWER TRANSFORMER
IC102 : NJM2904M Dual operational amplifier
–66.1V
TH101 NCP18XH103J03RB
DGND
V-
THM2
5 k-ohms 10 W
ST102
R-S A-S
U C
U.S.A CANADA
R T
GENERAL CHINA
K A B
L
EUROPEAN STANDARD SINGAPORE
E V
SOUTH EUROPE TAIWAN
KOREA AUSTRALIA
F P S
RUSSIAN LATIN AMERICA BRAZIL
BRITISH
H
THAI
REMARKS PARTS NAME NO MARK ELECTROLYTIC CAPACITOR SOLID ELECTROLYTIC CAPACITOR NO MARK CERAMIC CERAMIC
CAPACITOR TUBULAR CAPACITOR
POLYESTER FILM CAPACITOR POLYSTYRENE FILM CAPACITOR P
MICA CAPACITOR POLYPROPYLENE FILM
CAPACITOR
SEMICONDUCTIVE CERAMIC CAPACITOR
NO MARK
PARTS CARBON CARBON
RESISTOR
no_use
s101
no_use
s101 C176
MSP-108V-01PBSN TE101
s101 s101
no_use C159
C161 C160
s101 C190
s101 C157
C189
C184
no_use
no_use
no_use
R229
C183
no_use
1 0G
A/B SPEAKERS no_use
C179
no_use C180
no_use
no_use
no_use C178
s101 C177
s101 C162
s101 C174
s101 C158
C173
R232 C188 no_use
C187
no_use
no_use
3 1
1
+ 3 SPB -
IC1: R1190H033B-T1-FE Voltage regulator
SPBTE101
4
4
Thermal Shutdown
R
-
SPA TE101
2 SPA +
MSP-108V-01PBSN
5G
2
no_use
VDD 5
D117
1SS352
270 R196
Pin No.
Symbol
1
VOUT GND
2
Description Output Pin Ground Pin
3
CE
4
DELAY
5
VDD
Chip Enable Pin ("H" Active) Delay Pin (for setting Inrush Current Limit Time) Input Pin
Q133
no_use
2N5551S-RTK/P C156
C151
no_use
DELAY
IC202: BD3491FS-E2 47K
R185
R182
Sound processor with built-in surround sound function 32
31 A2
50K
50K VCC/2
E
R103
HPR W102
E
1P470
FIL
29
28
GND
27
SDA
26
SCL
I2C BUS LOGIC
V CC
25 OUT1
24
Page 46 K6 to MAIN (6)_CB401
23
SB1
SR
22 SB2
21 OUT2
20
19
BCB1
BCA1
18 BCA2
17 BCB2
VCC
• Bass Gain= ±14 dB/2dB step • Treble Gain= ±14 dB/2dB step • Volume 0 dB – -87 dB/1 dB step, -∞, Independent control • Input Gain 0 dB – +8 dB/2 dB step, 12, 16, 20 dB • Surround Gain= OFF, Low, Middle, High
4P 400MM B&C BL HPL
1P470
30
A1
HP OUT
10 R162
2 GND 4
R102
R165
Peak Current Protection
CE 3
RY3 (SP_B)
R173
47K
56K
Inrush Current Limit
R171
R177
no_use
C136 0.022/100 1P10
R160 C132
L101
1 VOUT Vref
1 6 RY103 981-2A-48DS-SP7
R318 s104
270
R191 1 6 RY102 981-2A-48DS-SP7
R319
RY2 (SP_A)
Q128
2N5551S-RTK/P
no_use
C148
D114
1SS352
s104
270
R320 s104 D110
6 1 R186 RY101 981-2A-48DS-SP7
1SS352 no_use
BAV103
1UH
Surround
Treble/Bass
Input Selector
47K
MAIN (1)
0.1/2W
★ All voltages are measured with a 10M Ω /V DC electronic voltmeter. ★ Components having special characteristics are marked ⚠ and must be replaced with parts having specifications equal to those originally installed. ★ Schematic diagram is subject to change without notice.
Volume
Volume
Input Gain
R156
(P=5) (P=10)
METAL PLATE RESISTOR FIRE PROOF CARBON FILM RESISTOR CEMENT MOLDED RESISTOR
C185
no_use
2 3 RY101
no_use
C133
R154 1K
C4468(O/P/Y)
KTD600K-Y-U/PH
C129
Q112
330K
2P0.1
R148 2.2
R138
R269
Q116 R146
2.2K D2704(K)
Q118
#
100
R142
5.6K
R136
no_use
Q108
no_use
R124
SPA 9 +
SPA
R172 4.7K 4.7K
DGND
510
BAV103
V-
L
7
8 6
no_use
+ SPB -
4.7K
METAL OXIDE FILM RESISTOR METAL FILM RESISTOR
SEMI VARIABLE
5 4 RY101
BAV103
3.26V 3.26V
NAME
FILM RESISTOR FILM RESISTOR
CHIP RESISTOR
981-2A-48DS-SP7
981-2A-48DS-SP7 C135
no_use
0.022/100 1P10
C131 R159
330K
R151 R150
33K C113
C137
MAIN
Details of colored lines
REMARKS
RY1 (HP)
Q125
15K
R153 D106
D104
6
Short Protection
63V
15K
R152
D105
C4468(O/P/Y)
C4468(O/P/Y)
330 1SS352
2.2
SPB
RIGHT
58.7V
C134 R122
R145
KTB631K-Y-U/PH
R141 D128
no_use
C128
120
Q104
C123
8.2K 8.2K
KTC3206Y-AT
150P(SL)
C117
C111
1.2K 100/16
R120
A1514K(R/S)
A1514K(R/S)
33K
R116
33/63
150P(SL)
#Q 1 1 5
R551 C186 no_use
47K C3906KT146(R,S)
R155
C4468(O/P/Y)
R147
2P0.1 D127 330
150P(SL)
1SS352
1.2K C114
2N5401S-RTK/P
47K
R157
2.2/50
C130
KTD600K-Y-U/PH 100
2.354mA R139
5.6K
107uA R135 0.0V
no_use
D2704(K)
0.235V
C126 no_use
8.2K 8.2K
8.2K C124 D121
C120
10/100
47/100
8.2K
R129
R127
8.2K 8.2K
R128
R113 R114
A1514K(R/S)
R119
47K
RESISTOR
CAPACITOR
NOTICE J
R110
C109
1.2K
RJ-1074_09-0353
(model) JAPAN G
100P/100
R126
C217
R277
8.2K
10K
R117
R237 10/16 D2704(K)
C169
R166 R235
47P(CH)
C207
Q202
47P(CH)
Q111
C119
5P(CH) 470
C102
no_use
10K
Q106
5
66.1V
3.26V
10/100 D122
R112 1K
1K
no_use
1.2K R236
Q201
R204
R106
R273
C216 D2704(K)
11
8
47K
R105
C208
47P(CH)
C206
R210
100K
1K
Q102
C103 10/50
R118
R
R115
R
10/50 1.2K
220P(SL)
10/16
R203
1UH
8
R164
100/6.3
470
R211
REC
10
10
2.2
10K
REC OUT
100K
L
2.2 1000P
PJ202
R228 C289
RJ-1074_09-0353
C209
R217 R207
4
R
470K
9
LINE3
#
R254
220P(SL)
470K
R219
470
Q114
R144
0V
R163
L102
TE102
TE101
981-2A-48DS-SP7
R257
R205
6
47K
R149 510
RY103 4 5
R108
PJ202
L
R161
0.048V
OUTPUT
- INPUT + INPUT
TE102 981-2A-48DS-SP7 RY103 3 2
47K
C106
8.2K
J207
470
C264
18K
981-2A-48DS-SP7
2N5551S-RTK/P
8.2K
E-VOLUME
RY102 3 2
10K
100P(SL) Q204 D2704(K)
D103 BAV103
R256
E AGND
10K
C3906KT146(R,S)
Q203 D2704(K)
1K
–61V
10/50 1.2K
4.7K
C251 0.22/50
-50V
8.2K
C250 0.22/50
L
R131
4.28V
R253
R255
10/100
BCB2
C249 0.22/50
C263
4.7K
2.0mA
C125
BCA2
C248 0.22/50
RJ-1074_09-0353
L
A1514K(R/S)
R252
BCB1
Q117 R101
2.2 R140
0.84V 1.0mA
776mV
C127 no_use
840uW
1/50
0.24V
KTC3206Y-AT
C260
OUT2
2.2
Q110
R130
SB2
Q105
120
1/50
2.2K
KTB631K-Y-U/PH
150P(SL)
C121
SR
BCA1
75p
R125
C261
C110
0.1/16
SB1
100/16
C259
OUT1
33K
1000/10
R109
8.94V
47/100
220P(SL)
C212 C213
TC1
4.28V
3.3V
VCC
R132
TC2
C262
SCL
Q113 R143
-0.6V
R133
VOL2
0V
C118
R134
VOL1
R121
GND SDA
R137
Q119 R158
0.09V 3 3 K
10/100
L2OL SEL1
Q101
no_use no_use
L2OR SEL2
1K
C122
F2
R107
820
F1
10/50
BTA_R
R111
E2
TUL TUR
10/50 C244
1800P/100 C247
220P(SL)
470K
R215
1
R
470K
5
R227
R
CDR
1800P/100 C246 R226
470
LINE2
E1
C104
BTA_L
n o _ u s en o _ u s e
R214
2
L
D2
CDL
10/50 C245
PJ202
L
L1R
C254 10/50
Q109
470
C115
C231 10/50
D1
L1L
C275 10/50
FIL
40.3V
Q107
R123
5P(CH)
C116
470
5 RJ-1073_09-0351
10/50
C2
C168
33/63 10/50 C241 C230
L2R
A2 BTA_R
C112
Q103
820
470K
R213
C211
L
10/50 C240
C1
100P/100
C210
220P(SL)
470K
10/50 C238 10/50 C239
6
R223
L
10/50C242 10/50C243
220P(SL)
LINE1
R222
470
B2
L2L
C253 10/50
C108
10/50C235
L3R
A1 BTA_L
20.5V
0.65V
50mW
47K
10/50C236
10/50C234
4
32.8mW 2.0mA
47P(CH)
4.28V
R104
470
R212
R
B1
L3L
7
R
BT IN
L=1 R=2
16 15 14 13 12 11 10 9 8 7 6 5 4 3 2 1 BD3491FS IC202 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32
C204
C205
470K
R216 R206
220P(SL) 220P(SL)
470K
R218 3
R322
LEFT 7
66V
2.0mA
C101
981-2A-48DS-SP7 RY102 4 5
C181
R167
5 k-ohms 10 W
R230 no_use C182
7 3 8 1 2
6800/66
UDZV9.1B
G101
STAR EARTH V599580 6 5 4
C143
6800/66
32.8mW
470
1
OUT L
C140
D202
AM/FM TUNER/DAB IN
C175
HPRY SPARY SPBRY PRD PRI EVOL_SCL EVOL_SDA
100K
10/50C237
10
C14 s12
D112
15V
R555
2
R
2
PORT 4
ch3
R261
L
IN L I N E 3
PORT 3
TI03/TO03/P31 (TI03/TO03/P14)
71V over
Q129 KTA1661-Y-RTF/P
F3A
100K
AGND
L
9
Q8
s7
4.2V
15V
66.1V
R202
L
s6
s18
25mW
ST1
100K
CD
3
4.2V
1SS352
R275
R271
P20 to P27
ch2
TE
R
R
1P47
100K
R556
R
OUT
R13
ST103
3.26V
6
ch1
TxD2/P13(TxD2/P77)
470K
Q205
-8.7V R E C O U T M U T E A1037AK(Q/R/S)
PORT 2
TI01/TO01/P16
RxD2/P14(RxD2/P76)
0.1/100 R199
100K
CD IN
LINE
12V
R234
R180
1P47
R195
R274
4.7K
P10 to P17
SERIAL ARRAY UNIT1 (2ch)
D111
s5
22
R9
1.0V
200 7V
<1W
220 for FL
PJ203
2
1
D8
s16 1/50
DLS5D1-O(M)0.25
D4 4.7K
R5 R6
KTC4376-Y-RTF/P
10K
no_use
C5
1.65V
R R
Q 1 2 1 12.1V 5712(TE12L/Q)
DTC014EUBTL
1/16W=62.5mW
8
VHIS
680 C15
UDZV9.1B
R10
10K D5
2.2/50
C17
Q3
3.6V
DGND
3.3V
50V
1
2
1K 1/50 Q2 KTC4376-Y-RTF/P
C16 27K
R2
R4
R17
47K
0.47/16
4
C3
0.47/16
C2
470/10
C1
1SS352 RY1
5
1 2
DELAY
+3.3V 20-90mA
s17
s8
7.0S
For Mute 18K
CD
J3
100P/100
C290
10/16 C138
22K
R326 S
D D
G
C273
220/10 MCH6336-TL-E Q209
100K
100
1SS352
Q4 KTC4376-Y-RTF/P
1SS352
R1
2.2M
R3
D3
Q1 3LN01C-TB-E
D2
30K
R193
CE
+3.3BT
D7
J2
8.94V
C13
0.1/100
s17
s6
7.7V
+8.4V
DB105
–9.2V
7
VHIS
C171
10/16
100P/100
CB4 BT_MFB
BT_AMP_EN
GND
REM 1K
10K
R
VDD
G :YF766 L :YF766
C8
C11
2.37V
R8
s11
IC1 R1190H033B-T1-F
3.3_PON
R282
22K
22
3.3V V O U T
UC:YF764 R :YF765 A :YF766
s3
1SS352
+3.3M
to CPU_PCB
1SS352
D1
N_RST PWR_DET
3
C278
100/10
R268
470K
0.1/16 D207
UDZV4.7B
450mm
N_RST PWR_DET
BT_AMP_EN
0.1/16
C252 N_RST
10K
R325 C291
22 R337
BT_MOSI C2712-GR(TE85L
1SS352
R188 C105
VDD
PRY
P00 to P03
8
SERIAL INTERFACE IICA0
1/2P1.5K
C266
no_use
no_use C256
2.2/50
100
Q206 1 0 0 -8.7V
R288
to TUNER PACK
DGND M_PRY
1SS352 D9
10K
R267
52045
FFC connector 1.25mm Pitch
30K
47K
4
PORT 1
SCL11/P30
R266 R259 100K
GPIO2
C292
8
R189
0.1/16
PORT 0
ch0
SDA11/P50
From TRANSFORMER
0V
Q122
R18
TIMER ARRAY UNIT (8ch) TI00/P00 TO00/P01
TI02/TO02/P17 (TI02/TO02/P15)
100
470K
0V
R327
0.1/100 R198
Rch GND
F1 CB5 s1 CB6 TP00351-31
C154
0V
RY1 DLS5D1-O(M)0.25
R170
R270
VV07180
C155
NC
0.01/250
7
R12 C4
PRPS
R284
0V
T4AL250
IC203: R5F100JFAFA 16 bit single chip microprocessor
D10
Force reset
C279 100P(SL) C277
REGC
VSS C276
1/50
X1
REM
X2
BT_AMP_EN
100
R286
C268
1000P(B)
R299 T_N_RST_OUT R313 PRE_N_MUTE
REC_N_MUTE N_INT
WQ21110
0.1/16
7
6
C255
TU_SCL
+ 3 . 3 V 3.61V
6
1
TU_SDA
3.61V
6 IC102 4 5 V-
T8A125
C6
NJM2904M
BTA_R
MG
3.26V
C267
5
3.61V
SCL
2.2/50
4
TU_N_RST
SDA
R-S202
22K
A1037AK(Q/R/S)
0.1/16
1
3
no_use
no_use
2
C258
N _ R S T 3.58V
2.2
5
C257
Page 46 F9 to MAIN (8)_CB602 (R-S202D) C B 2 10 2
R330
15K
Q208
3.3V
100P/100
R251
PRY
PWR_DET
MPSW
VOL_RA
VOL_RB
C280
0V
to AM/FM TUNER (R-S202)
BT_MISO
MPSW
M_PRY 100
1K
R291
R293
100
100
R285
100
R295
R294
REC_N_MUTE
PRE_N_MUTE
PWR_DET
MVOL_RB
MVOL_RA
REC_N_MUTE
PRE_N_MUTE
TOOLTxD
R300 no_use
no_use
10K 0.1/16
N_RST
HPRY
1K
0.1/16
R201
47K C271
R310
BT_MFB
UDZV4.7B
s201 D203
1000P(B)
R280
0.1/16
C282
1/25
C281
C270
1000P(B) C269
C272
C265
52044
1000P(B) 1000P(B)
N_RST
1000P(B)
3.27V
D204
0V
T_VDD
UDZV4.7B
T_SCLK
1
C12
3.27V
N_T_RST
2
THM2
100
0V
R292
0V
GND
TOOL0
T_VPP
4
TOOL0
5
HPRY
10K
0V
THM2
T_PGM/OE
R224
200V
R
6
TOOL0
FUSE 100V
C145
R328
8
T _ R X D / T O O3.27V LO
SPARY
SPARY
PRIMARY
AGND
5
7
3.27V
100P/100
4
T_BUSY/T_N_RST_OUT
BT_N_RST
15K
to POWER TRANSFORMER
to POWER TRANSFORMER
11
(FLASH) 1
(for factory)
BT_N_RST
8
3
BT_MOSI
BT_MOSI
0V
T_TXD
22K C150
3
CB201
R331
1
BT_MISO
BT_MISO
NJM2904M
R329
15K
MICROPROCESSOR
VREFP SPBRY
1
2
TEST VREFM
SPBRY
1000P(B)
30K D102
PRPS
1K
C284
1000P(B)
220/6.3
THM
PRPS
9
100 R301
R176 PRD
BT_MFB
100
R311
100
1K
KEY1
R281
R264
THM
TOOLRxD
M_PLED
3.3_PON MODEL
R309
12K
100
R306
C283
39 38 37 36 35 34 33 32 31 30 29 28 27 FL_SCK R290 MFL_SCK 40 26 R231 MFL_MISO FL_MISO 1K BT_N_RST 41 25 1K MFL_MOSI FL_MOSI R249 24 42 1 K R289 MFL_STB FL_STB 23 R302 43 EVOL_SDA R298 1K EVOL_SDA IC203 2.2K 22 44 R233 EVOL_SCL 100 R297 EVOL_SCL 21 45 R5F100JFAFA 2.2K 100 20 46 R248 GPIO2 GPIO2 19 47 100 R262 PRI PRI 18 48 1K 17 49 R287 TU_N_RST TU_N_RST 16 50 100 R276 TU_SDA TU_SDA 15 51 100 R272 TU_SCL TU_SCL 14 52 100 1 2 3 4 5 6 7 8 9 10 11 12 13
R305 KEY0
MKEY0 MKEY1 PRD
3.3S_PON
10K
R312
10K 10K
R265
R258
470K
R263
3
R336
10K
PHI
SAN-PH
22
CB205
no_use
C195 100P(SL)
R335
MG
ST250
4
S2
HOT
3
15K
10/16 C107
no_use
R279
0V
R304
3
3.27V
100P(SL)
3
3.3S
THM
C274
2
0.83V
R260
C285
MG
0.1/16
GND
1
2
THM
47K
3.3S
CB101
V+ 8 2 IC102
R283
100P(SL)
R181
C196
W250 THM 1
VCC
+8.4V
100
100P(SL)
THM OUT
S1
C193 100P(SL)
MAIN (7)
IC250 LM61CIZ
Pri
1
R209
0
BT IN
C194
2
(Except RL Destination)
0V
100
100P(SL) s202 Model Recognition R-S202 R304 10k 10k R-S202D R279
100
R340
100P(SL) C199
R339
MFL_MISO
MFL_STB
MFL_MOSI
MFL_SCK
REM
M_PLED
MPSW
MKEY0
MKEY1
MVOL_RA
MVOL_RB
s202 Destination recognition U R G A L R280 R-S201 560 20K 1.8K 2.7K 9.1K
R208
MAIN Transformer C198
2.2K
0V
0V
3.27V
3.27V
0V
0V
R238
BT_N_RST
BT_3.3V
+3.3BT
2200/6.3
-24V
VPE
MG
3.3M
3.3S
MG
FL_MISO
3.26V F L _ S T B
FL_MOSI
0V
3.26V F L _ S C K
REM
3.22V
3.22V M _ P L E D
MPSW
0V
KEY0
KEY1
3.27V
3.27V
MVOL_RB
0V
3.25V M V O L _ R A
WG03360
D109
17
16
15
14
13
12
11
10
9
8
To BTcard
7
to FL(CB501) 6
to BTCARD
5
Page 46 B6 to MAIN (2)_CB501 4
2
3
MAIN 1/2
CB204 1
1
■ SCHEMATIC DIAGRAMS
12
R-S202/R-S202D
Red / full line: Red /dashed line: Orange: Yellow: Green: Brown: Blue:
Power supply (+) Power supply (-) Signal detect Clock Protection detect Reset signal Panel key input
Safety measures • Some internal parts in this product contain high voltages and are dangerous. Be sure to take safety measures during servicing, such as wearing insulating gloves. • Note that the capacitors indicated below are dangerous even after the power is turned off because an electric charge remains and a high voltage continues to exist there. Before starting any repair work, connect a discharging resistor (5 k-ohms/10 W) to the terminals of each capacitor indicated below to discharge electricity. The time required for discharging is about 30 seconds per each. C140, C143 and C149 on MAIN (1) P.C.B.
50k B1
1
50k
50k
B2
2
C1
3
50k C2
4
50k D1
5
50k D2
6
50k E1
7
50k
50k
E2
8
F1
9
50k F2
10
SEL2
11
SEL2
12
VOL1
13
VOL2
14
TC2
15
TC1
16
安全対策 ・ この製品の内部には高電圧部分があり危険です。修理の際は、絶縁性の手袋を使 用するなどの安全対策を行ってください。 ・ 下記のコンデンサには電源を OFF にした後も電荷が残り、高電圧が維持されて おり危険です。修理作業前に放電用抵抗(5 k Ω /10 W)を下記の各コンデンサ の端子間に接続して放電してください。放電所用時間は各々約 30 秒間です。 MAIN(1)P.C.B. の C2185、C2186
45
B
A
C
D
E
F
G
H
I
J
K
L
M
N
R-S202/R-S202D
1
MAIN 2/2
MAIN (3)
270
10K
2
VOL_RA
R701
VOL_RB
3 3.25V
3
VOL_RB
10K
4
0V
4
MG
5 3.26V
5
SW_PDRT
6 0V
6
FG
470
KEY1
KEY1
16
VOL_RA
3.25V
VOL_RA
17
VOL_RB
0V
VOL_RB
KEY0
1.37V
L shape FFC connector
Q503
STANDBY/ON indicator
47K
R704
SW512
40mV
Page 45 L9 0V to MAIN (1)_W1020V
R546
R523
4.7K
R527
3.3K
R530
2.2K
R532
1.5K
R534
1K
40mV
1K
47
HPL HPE
U501 MG
3.21V
-
BODY
BASS
+
-
TREBLE
+
<<
INPUT
>>
JK401 L R GND JY-6317Y-03-030
PHONES
HPR
no_use
>>
TUNING
no_use
<<
>
0.01/100 C404 R401
PRESET
C403
<
no_use
no_use D402
<MEMORY>
0.01/100 D401
HP
HP OUT L
CB401
0.01/100 C402
15
3.27V
47K
MAIN (6)
1K
C401
14
MP_SW
D701 no_use D702
KEY0
FL_SCK
KEY1
R533
1K
SW513
0V 3.27V
0.1/16
FL_STB
R531
1.5K
SW504
SW502
SW501
R529
2.2K
SW510
R526
3.3K
SW508
R522
4.7K
SW506
R521
SW511
MPSW KEY0
C701
10K
PHL
13
R703
SAN-SAN
VI87840
SW509
100
2 0V
SW_PDRT
SW507
3.22V
VOL_RA
B COM
no_use
SW505
12
PLED
+3.3M
1P 100MM BLACK
G502 no_use
A
1
SW701
W501
W503B 1 3.27V
no_use
0.1/16
no_use C521
D510
D509
no_use
R528 R525
100P(SL)
R524
R554
100P(SL) C520
FL_MOSI
D514
100P(SL) C519
to chassis
470
C518 2N5401S-RTK/P –22.8V BT LED
W503A SAN-SAN
470
100P(SL)
470
Q504
R547
C523
R550
701-
SW702 REB161(9X7)PVB2 R702
LED2 R549 no_use LED1
0.1/16
C515
G2 SW_PDRT
R517
R548 1.2K
LED3
VOL
VOL_ENCODER
R516 100K
OSC
SW503
R544
SW516
VOLUME
DMISO
VOUT
3.22V
GND
REM
3.23V
10/16
11
FL_SCK
VCC
FL_SCK
SW515
47/16
0.1/16
C516
P16
C517
DMOSI
SW_SPAB
G3
G4
no_use
FL_MOSI
10
B SPEAKERS
CLK
0.1/16
C512
no_use
D508
no_use
D506
R513
0V 3.26V
B
MAIN (4)
STB
FL_STB
0.1/16 C514
FL_MOSI
(Power)
KEY1
7.5K
U501
C513
9
0V
SIR8430MH6
FL_MISO
R543
FL_STB
4
MG
1.3K
8
0V 3.26V
HLMP-Y701-G0000
FL_MISO
620
MG
7
SW_SPAB
R505
0V
6
P15
P13
P14
P11
P9
P12 G5
G6
G7
G8
G9
100K
R509
100K
0.1/16 J505
C509 0.1/16
3.27V
0.1/16
+3.3S
C507
5
no_use
3.27V
J501
+3.3M
3
no_use
Remote control sensor
DTC014EUBTL
7
4
3.27V
KEY0
R514
R542
Page 45 C1 to MAIN (1)_CB204
0V
–25.3V
D511
6
to FUNC(2)
C505
G501
MG
MP_SW
SPEAKERS
FL_MISO
Grid9
FL DRIVER
5
3
2
A
C2412K(Q/R/S) R508
C508
0.1/16
Q502
0V
1
0V
A
no_use HLMP-NS30-J0000
4
Grid10
HT16515-44LQFP
Vss
SEG16
Vdd
P1
IC501
Grid2
SEG15
Grid1
SEG14
P2
Grid4
P3
Grid3
SEG13
Grid6
SEG12
P4
Grid5
P5
Grid8
SEG11
Grid7
SEG10
P6
P10
P8
47/35 C506
C504
47/35
P7
SEG18
VPE
120mm
3.27V
W502B SAN-SAN 3.3M SW514
W502A 3.3M
15K
G10
2
VI87820
R541
SEG17
1
SPAB
MAIN (2)
Vee
CB501 52044 -VP
FL
1 F1
NP
2 F1
P1
P2 P2
4
P1
P3
P4 P4
P3
P5
P6 P6
P8
P7
P8
P7
P9 P9
P11
P12
P10 P10
P11
P12
P14
P15
P13 P13
P14
P15
10G
P16 P16
G10
8G
9G G9
G8
7G
6G G6
G7
5G
4G G4
G5
2G
3G
5
33 32 31 30 29 28 27 26 25 24 23 SEG9 34 22 SEG8 35 21 SEG7 36 20 SEG6 37 19 SEG5 38 18 SEG4 39 17 SEG3 40 16 SEG2 41 15 SEG1 42 14 Vdd 43 13 Vss 44 12 1 2 3 4 5 6 7 8 9 10 11
C503
G3
G2
1G
F2 C502
6
MG
0.1/16
C501
47/35
–25.3V
7
3.27V
0.01(B) UDZV2.4B UDZV2.4B
D502 D501
3
8
SW_SPAB
–21.2V
–23.2V
9
MP_SW 270 R504
R502 R501
PHL
R503
–22V
270
F1
270
2
F2
NP
to POWER TRANSFORMER
–22V
F2
CB502
010ST027GNK
29 28 27 26 25 24 23 22 21 20 19 18 17 16 15 14 13 12 11 10
P5
V501 32 31
8
DAB
MAIN (8) (R-S202D)
IC501: HT16515-44LQFP 1/4 to 1/12 Duty VFD controller 7
CB602
R603
DAB IN
6 8
Lch
L601
14-29
9
GND
9
5
ST601
10
46
3.3V
R605
R604
NC R602
C604
C603
C602
C601
24
NC
22
23
31-38
NC
Page 45 A5 to MAIN (1)_CB202
10,11
39-42
SCL 1-4
GND
21
NC
20
NC
NC
19
NC
NC 18
NC
17
SDA 16
SCL
15
NC 14
GND
13
3.3V 12 11
NC 10 9
NC
ST602
N_RST
NC 8
AUD_R 6 5
AUD_L 4 3
7
NC
GND
2 1
CB601 GND
NC
NC
Rch
SDA
13,43
12,44
30
N_RST R606
J
(model) JAPAN G
U C
U.S.A CANADA
R T
GENERAL CHINA
K A B
L
EUROPEAN STANDARD SINGAPORE
E V
SOUTH EUROPE TAIWAN
KOREA AUSTRALIA
F P S
RUSSIAN LATIN AMERICA BRAZIL
BRITISH
H
THAI
REMARKS PARTS NAME NO MARK ELECTROLYTIC CAPACITOR SOLID ELECTROLYTIC CAPACITOR NO MARK CERAMIC CERAMIC
CAPACITOR TUBULAR CAPACITOR
POLYESTER FILM CAPACITOR POLYSTYRENE FILM CAPACITOR P
Details of colored lines
RESISTOR
CAPACITOR
NOTICE
MICA CAPACITOR POLYPROPYLENE FILM
CAPACITOR
SEMICONDUCTIVE CERAMIC CAPACITOR
REMARKS NO MARK
PARTS CARBON CARBON
NAME
FILM RESISTOR FILM RESISTOR
(P=5) (P=10)
METAL OXIDE FILM RESISTOR METAL FILM RESISTOR METAL PLATE RESISTOR FIRE PROOF CARBON FILM RESISTOR CEMENT MOLDED RESISTOR SEMI VARIABLE CHIP RESISTOR
RESISTOR
★ All voltages are measured with a 10M Ω /V DC electronic voltmeter. ★ Components having special characteristics are marked ⚠ and must be replaced with parts having specifications equal to those originally installed. ★ Schematic diagram is subject to change without notice.
Red / full line: Red /dashed line: Orange: Yellow: Green: Brown: Blue:
Power supply (+) Power supply (-) Signal detect Clock Protection detect Reset signal Panel key input
B
A
C
D
E
F
G
H
I
J
K
L
M
N R-S202/R-S202D
1
SWITCH
2
3
SWITCH (R model)
4
PRM_SW VOLTAGE SELECTOR
CB3 Red
CB1
2
1
F2
Purple
CB2
4
6
220-230V
Orange
5
6
SL14
S W 13
110-120V
5
Yellow
1 2 3
to POWER TRANSFORMER
4 B4P7S-VH
7
8
9
10
J
(model) JAPAN G
U C
U.S.A CANADA
R T
GENERAL CHINA
K A B
L
EUROPEAN STANDARD SINGAPORE
E V
SOUTH EUROPE TAIWAN
KOREA AUSTRALIA
F P S
RUSSIAN LATIN AMERICA BRAZIL
BRITISH
H
THAI
REMARKS PARTS NAME NO MARK ELECTROLYTIC CAPACITOR SOLID ELECTROLYTIC CAPACITOR NO MARK CERAMIC CERAMIC
CAPACITOR TUBULAR CAPACITOR
POLYESTER FILM CAPACITOR POLYSTYRENE FILM CAPACITOR P
Details of colored lines
RESISTOR
CAPACITOR
NOTICE
MICA CAPACITOR POLYPROPYLENE FILM
CAPACITOR
SEMICONDUCTIVE CERAMIC CAPACITOR
REMARKS NO MARK
PARTS CARBON CARBON
NAME
FILM RESISTOR FILM RESISTOR
(P=5) (P=10)
METAL OXIDE FILM RESISTOR METAL FILM RESISTOR METAL PLATE RESISTOR FIRE PROOF CARBON FILM RESISTOR CEMENT MOLDED RESISTOR SEMI VARIABLE CHIP RESISTOR
RESISTOR
★ All voltages are measured with a 10M Ω /V DC electronic voltmeter. ★ Components having special characteristics are marked ⚠ and must be replaced with parts having specifications equal to those originally installed. ★ Schematic diagram is subject to change without notice.
Red / full line: Red /dashed line: Orange: Yellow: Green: Brown: Blue:
Power supply (+) Power supply (-) Signal detect Clock Protection detect Reset signal Panel key input 47
R-S202/R-S202D
■ REPLACEMENT PARTS LIST • ELECTRICAL COMPONENT PARTS WARNING ● Components having special characteristics are marked tions equal to those originally installed.
and must be replaced with parts having specifica-
ABBREVIATIONS IN THIS LIST ARE AS FOLLOWS: : CHIP ALUMI.ELECTROLYTIC CAP : CERAMIC CAP : CERAMIC CAP ARRAY : CHIP CERAMIC CAP : CHIP MULTILAYER CERAMIC CAP : RECOGNIZED CERAMIC CAP : CERAMIC TUBULAR CAP : SEMI CONDUCTIVE CERAMIC CAP : ELECTROLYTIC CAP : BIPOLAR ELECTROLYTIC CAP : CHIP ELECTROLYTIC CAP : MICA CAP : MULTILAYER FILM CAP : METALLIZED POLYESTER FILM CAP : MYLAR FILM CAP : MULTILAYER MYLAR FILM CAP : NIOBIUM OXIDE CAP : PAPER CAPACITOR : POLYSTYRENE FILM CAP : POLYMER MULTI-LAYER CAPACITOR : POLYESTER FILM CAP : POLYPROPYLENE FILM CAP : CHIP POLYPROPYLENE FILM CAP : TANTALIUM CAP : CHIP TANTALIUM CAP : TRIMMER CAP : CONNECTOR : CONNECTOR,BASE PIN : CONNECTOR,CANNON : CONNECTOR,DIN : CONNECTOR,FLAT CABLE : CONNECTOR,FLEXIBLE FLAT CABLE : HDMI CONNECTOR : PHOTO FIBER SENSOR,RECEIVED : PHOTO FIBER SENSOR,TRANSMITTED : SCHOTTKY BARRIER DIODE : DIODE ARRAY : DIODE BRIDGE : CHIP DIODE : VARACTOR DIODE : ZENER DIODE : CHIP ZENER DIODE : PHOTO DIODE : FERRITE BEADS : FERRITE CORE : CHIP FET : FLUORESCENT DISPLAY : CERAMIC FILTER : COMB FILTER MODULE : LC FILTER,EMI : CHIP FUSE : GROUND PLATE : GROUND TERMINAL : JUMPER CONNECTOR : JUMPER,TEST POINT : LIGHT DETECTING MODULE
LED.CHP : CHIP LED LED.DSPLY : LED DISPLAY LED.INFRD : LED,INFRARED PHOT.CPL : PHOTO COUPLER PHOT.INTR : PHOTO INTERRUPTER PHOT.RFLCT : PHOTO REFLECTOR PHOT.TR : PHOTO TRANSISTOR PIN.TEST : PIN,TEST POINT PTC.THERM : POSITIVE TEMPERATURE COEFFICIENT THERMISTOR R.ANTI.SURGE : FIXED ANTI SURGE RESISTOR R.ARRAY : RESISTOR ARRAY R.CAR. : CARBON RESISTOR R.CAR.CHP : CHIP RESISTOR R.CAR.FP : FLAME PROOF CARBON RESISTOR R.CEMENT : CEMENT RESISTOR R.CHP : CHIP RESISTOR R.FUS : FUSIBLE RESISTOR R.MTL.CHP : CHIP METAL FILM RESISTOR R.MTL.FLM : METAL FILM RESISTOR R.MTL.OXD : METAL OXIDE FILM RESISTOR R.MTL.PLAT : METAL PLATE RESISTOR RSNR.CE : CERAMIC RESONATOR RSNR.CRYS : CRYSTAL RESONATOR SCR.BND.HD : BIND HEAD B-TIGHT SCREW SCR.TERM : SCREW TERMINAL SCR.TR : SCREW,TRANSISTOR SURG.PRTCT : SURGE PROTECTOR SUPRT.PCB : P.C.B. SUPPORT SW.LEVER : LEVER SWITCH SW.MICRO : MICRO SWITCH SW.LEAF : LEAF SWITCH SW.PUSH : PUSH SWITCH SW.RT : ROTARY SWITCH SW.RT.ENC : ROTARY ENCODER SW.RT.MTR : ROTARY SWITCH WITH MOTOR SW.SLIDE : SLIDE SWITCH SW.TACT : TACT SWITCH TERM.SP : SPEAKER TERMINAL TERM.WRAP : WRAPPING TERMINAL THRMST.CHP : CHIP THERMISTOR TR : TRANSISTOR TR.CHP : CHIP TRANSISTOR TR.DGT : DIGITAL TRANSISTOR TR.DGT.CHP : CHIP DIGITAL TRANSISTOR TR.PAIR : PAIR TRANSISTOR TRANS : TRANSFORMER TRANS.PULS : PULSE TRANSFORMER TRANS.PWR : POWER TRANSFORMER VARISTOR.C : CHIP VARISTOR VOLT.SELCT : VOLTAGE SELECTOR VR : ROTARY POTENTIOMETER VR.MTR : POTENTIOMETER WITH MOTOR VR.SLIDE : SLIDE POTENTIOMETER VR.SW : POTENTIOMETER WITH SWITCH VR.TRIM : TRIMMER POTENTIOMETER
R-S202/R-S202D
C.A.EL.CHP C.CE C.CE.ARRAY C.CE.CHP C.CE.M.CHP C.CE.SAFTY C.CE.TUBLR C.CE.SMI C.EL C.EL.BP C.EL.CHP C.MICA C.ML.FLM C.MP C.MYLAR C.MYLAR.ML C.NIOB.OXD C.PAPER C.PLS C.PML C.POL C.PP C.PP.CHP C.TNTL C.TNTL.CHP C.TRIM CN CN.BS.PIN CN.CANNON CN.DIN CN.FLAT CN.FFC CN.HDMI CN.PHOTO.R CN.PHOTO.T D.SCHOTTKY DIODE.ARRAY DIODE.BRG DIODE.CHP DIODE.VAR DIODE.ZENR DIODE.Z.CHP DIODE.PHOT FER.BEAD FER.CORE FET.CHP FL.DSPLY FLTR.CE FLTR.COMB FLTR.LC.RF FUSE.CHP GND.MTL GND.TERM JUMPER.CN JUMPER.TST L.DTCT
49
R-S202/R-S202D
R-S202
MAIN Ref No. * * * * * * ⚠ ⚠ ⚠ * *
* ⚠
R-S202/R-S202D
*
*
*
50
CB4 CB5-6 CB7 CB101 CB102 CB103 CB201 CB202 CB204 CB401 CB501 CB502 C1 C2-3 C4 C6 C7 C8 C9 C10 C11 C12 C13 C14 C15-16 C17 C101-102 C103-104 C105 C106 C107-109 C110-111 C112-113 C114 C117-119 C120 C121-122 C123 C124-125 C130 C131-132 C137 C138 C139 C140 C140 C141 C142 C143 C143 C144 C145 C146 C147 C149 C150 C152 C153 C154-155 C157-158 C160-162 C166-167
Part No. ZU625400 ZU625500 ZU625600 ZU625700 ZU625800 ZU625900 VG879900 WN103000 VG879900 VB389900 WG033601 LB932031 VQ044400 VQ047200 VM973500 VB858300 VF982300 VB858200 UR828470 WJ590701 US035100 WQ939401 UR849221 WW194100 US063100 UR867100 WW194100 US063100 WW194100 UR866100 UR866100 UR866220 US061470 UR867100 UR818220 US062100 ZD517600 UR838100 US060500 US062150 US062150 UR897470 UR897100 UR897470 UR897100 UR866220 ZD520400 UR818100 ZD517600 UR848330 ZH987600 ZH998400 UR867100 UR867470 ZH987600 ZH998400 UR829100 ZD517600 UR866470 UR867100 UR779100 ZD517600 US064100 UR819220 WW194100 WN200100 WN200100 WW194100
* New Parts
Description P.C.B. P.C.B. P.C.B. P.C.B. P.C.B. P.C.B. CN.BS.PIN CLIP.FUSE CN.BS.PIN CN.BS.PIN CN.BS.PIN CN.BS.PIN CN.BS.PIN CN.BS.PIN CN.BS.PIN CN.BS.PIN CN.BS.PIN CN.BS.PIN C.EL C.CE.CHP C.CE.CHP C.CE.SAFTY C.EL C.MYLAR C.CE.CHP C.EL C.MYLAR C.CE.CHP C.MYLAR C.EL C.EL C.EL C.CE.CHP C.EL C.EL C.CE.CHP C.MYLAR C.EL C.CE.CHP C.CE.CHP C.CE.CHP C.EL C.EL C.EL C.EL C.EL C.MYLAR C.EL C.MYLAR C.EL C.EL C.EL C.EL C.EL C.EL C.EL C.EL C.MYLAR C.EL C.EL C.EL C.MYLAR C.CE.CHP C.EL C.MYLAR C.CE.M.CHP C.CE.M.CHP C.MYLAR
MAIN MAIN MAIN MAIN MAIN MAIN 2P TP00351-31 2P 3P 52806 15P TE 3P 9P 9P 17P 4P 17P 3P 470uF 10V 0.47 16V K RECT. 0.1uF 16V B 0.01uF 250V 2200uF 25V 0.1uF 100V 1000pF 50V B 10uF 50V 0.1uF 100V 1000pF 50V B 0.1uF 100V 1uF 50V 1uF 50V 2.2uF 50V 47pF 50V B 10uF 50V 220uF 6.3V 100pF 50V B 100pF 100V 100uF 16V 5pF 50V B 150pF 50V B 150pF 50V B 47uF 100V 10uF 100V 47uF 100V 10uF 100V 2.2uF 50V 0.022uF 100V 100uF 6.3V 100pF 100V 330uF 25V 6800uF 66V 6800uF 66V 10uF 50V 47uF 50V 6800uF 66V 6800uF 66V 1000uF 10V 100pF 100V 4.7uF 50V 10uF 50V 1000uF 63V 100pF 100V 0.01uF 50V B 2200uF 6.3V 0.1uF 100V 0.01uF 100V 0.01uF 100V 0.1uF 100V
Markets UC R TK A G L
R R R R
UCRTKAL G
UCRTKAL G
TKAGL TKAGL
Ref No. C168-169 C170 C171 C172 C173-176 C189 C192 C193-196 C197 C198-199 C204-205 C206-207 C208-213 C216-217 C230-231 C232 C234-245 C246-247 C248-251 C252 C253-254 C259-260 C261 C262 C263-264 C265 C266-267 C268-270 C271 C272 C273 C274 C275 C276 C277 C278 C279 C280 C281 C282 C283-284 C285 C287 C289 C290-291 C292 C401-403 C501 C502 C503 C504 C505 C506 C507-509 C512-513 C514 C515-516 C517 C518-520 C521 C523 C701 D1-4 D5 D6 ⚠ D7 * D8 D9-10
Part No. UR877330 ZD517600 UR837100 WW194100 WN200100 WN200100 US035100 US062100 UR877100 US062100 US062220 US061470 US062220 UR837100 UR867100 US135100 UR867100 ZD519100 UR865220 US135100 UR867100 UR866100 US135100 UR829100 UR867100 US063100 UR866220 US063100 US135100 US046100 UR828220 US062100 UR867100 UR866100 US135100 UR828100 US062100 US135100 US063100 US135100 US063100 US135100 US135100 US163100 UR837100 US135100 WN200100 WQ711900 US035100 US064100 WQ711900 US035100 WQ711900 US035100 US035100 UM397100 US035100 UM397470 US062100 US035100 US062100 US035100 ZP358601 WY163800 WY164100 WH471700 ZU129100 ZP358601
* New Parts
Description C.EL C.MYLAR C.EL C.MYLAR C.CE.M.CHP C.CE.M.CHP C.CE.CHP C.CE.CHP C.EL C.CE.CHP C.CE.CHP C.CE.CHP C.CE.CHP C.EL C.EL C.CE.CHP C.EL C.MYLAR C.EL C.CE.CHP C.EL C.EL C.CE.CHP C.EL C.EL C.CE.CHP C.EL C.CE.CHP C.CE.CHP C.CE.CHP C.EL C.CE.CHP C.EL C.EL C.CE.CHP C.EL C.CE.CHP C.CE.CHP C.CE.CHP C.CE.CHP C.CE.CHP C.CE.CHP C.CE.CHP C.CE.CHP C.EL C.CE.CHP C.CE.M.CHP C.EL C.CE.CHP C.CE.CHP C.EL C.CE.CHP C.EL C.CE.CHP C.CE.CHP C.EL C.CE.CHP C.EL C.CE.CHP C.CE.CHP C.CE.CHP C.CE.CHP DIODE DIODE.ZENR DIODE.ZENR DIODE.BRG DIODE.CHP DIODE
33uF 100pF 10uF 0.1uF 0.01uF 0.01uF 0.1uF 100pF 10uF 100pF 220pF 47pF 220pF 10uF 10uF 0.1uF 10uF 1800pF 0.22uF 0.1uF 10uF 1uF 0.1uF 1000uF 10uF 1000pF 2.2uF 1000pF 0.1uF 1uF 220uF 100pF 10uF 1uF 0.1uF 100uF 100pF 0.1uF 1000pF 0.1uF 1000pF 0.1uF 0.1uF 1000pF 10uF 0.1uF 0.01uF 47uF 0.1uF 0.01uF 47uF 0.1uF 47uF 0.1uF 0.1uF 10uF 0.1uF 47uF 100pF 0.1uF 100pF 0.1uF 1SS352 TE UDZV9.1B UDZV12B DB105 F3A 1SS352 TE
63V 100V 16V 100V 100V 100V 16V B 50V B 63V 50V B 50V B 50V B 50V B 16V 50V 16V 50V 100V 50V 16V 50V 50V 16V 10V 50V 50V B 50V 50V B 16V 25V 10V 50V B 50V 50V 16V 10V 50V B 16V 50V B 16V 50V B 16V 16V 50V 16V 16V 100V 35V 16V B 50V B 35V 16V B 35V 16V B 16V B 16V 16V B 16V 50V B 16V B 50V B 16V B
Markets
TKAGL TKAGL
R 1A 600V R
R-S202/R-S202D
R-S202
MAIN Ref No.
⚠* ⚠
⚠*
* ⚠ ⚠ ⚠
*
⚠ ⚠
⚠ ⚠ ⚠ ⚠#
⚠
Part No. WY164800 ZP358601 ZA984400 WY162900 WY163800 WY164800 ZP358601 ZU129100 VN953300 ZP358601 WY164300 ZP358601 WY165200 ZU129100 ZP358601 WY163800 WY163101 WY163101 WZ443400 WZ745700 ZR754101 WQ211100 VV071801 V5995800 YD268A00 XV190A00 YF439A00 YF475A00 X0515B00 YF471A00 V4478300 WD195400 WD195200 WH445000 ZE933000 ZG245700 WC397600 WC398300 WD896300 WC292201 WC883400 ZG214200 ZG214100 ZG214200 ZU111000 WF549900 WC397600 ZC256500 VV925403 ZE918100 ZE933000 WC398300 WC397600 WC398300 ZG245700 WC397600 WC398300 WC883400 VV556500 WW782100 WQ381001 VV556400 WW782100 WC397600 RD359220 RD356100 RD355100 RD357270
* New Parts
Description DIODE.ZENR DIODE DIODE DIODE.ZENR DIODE.ZENR DIODE.ZENR DIODE DIODE.CHP DIODE.BRG DIODE DIODE.ZENR DIODE DIODE.ZENR DIODE.CHP DIODE DIODE.ZENR DIODE.ZENR DIODE.ZENR DIODE.ZENR LED LED FUSE FUSE PLATE.GND IC IC IC IC.CPU IC IC JACK.PHONE JACK.PIN JACK.PIN FET TR TR TR TR TR TR TR TR TR TR TR.POWER TR TR TR TR.CHP TR TR TR TR TR TR TR TR TR TR TR.DGT FET TR TR.DGT TR R.CHP R.CHP R.CHP R.CHP
UDZV24B 1SS352 TE BAV103 UDZV3.9B UDZV9.1B UDZV24B 1SS352 TE F3A D5SBA60 5A 600V 1SS352 TE UDZV15B 1SS352 TE UDZV36B F3A 1SS352 TE UDZV9.1B UDZV4.7B UDZV4.7B UDZV2.4B HLMP-Y701-G0000 HLMP-NS30 BLUE 8A 125V 4A 250V R1190H033B-T1-FE NJM2904M OP AMP BD3491FS R5F100JFAFA CPU LM61CIZ THERMAL HT16515-44LQFP JY-6317Y-03-030 6P 4P 3LN01C-TB-E KTC4376-Y-RTF/P KTA1661-Y-RTF/P 2N5401S-RTK/P 2N5551S-RTK/P 2SA1514K R,S KTC3206Y-AT 2SD2704 K KTD600K-Y-U/PH KTB631K Y,GR KTD600K-Y-U/PH 2SC4468 O,P,Y 2SC3906K T146 R,S 2N5401S-RTK/P 2SC5712 2SC2712-GR KTA1664-Y-RTF/P KTC4376-Y-RTF/P 2N5551S-RTK/P 2N5401S-RTK/P 2N5551S-RTK/P KTA1661-Y-RTF/P 2N5401S-RTK/P 2N5551S-RTK/P 2SD2704 K 2SA1037K Q,R,S DTC014EUBTL MCH6336-TL-E 2SC2412K Q,R,S DTC014EUBTL 2N5401S-RTK/P 2.2MΩ 1/16W J 1KΩ 1/16W J 100Ω 1/16W J 27KΩ 1/16W J
Markets
Ref No.
*
R
UCR TKAGL
unwritten * ⚠* * ⚠* ⚠ ⚠ R R R
Note: Those parts marked with # are not included in the P.C.B. assembly.
⚠ ⚠* ⚠*
*
⚠ * ⚠
*
*
R5 R6 R7 R8 R9 R10 R11 R12 R13 R14 R15 R16 R17-18 R101 R102-103 R104-105 R106-107 R108 R109-110 R111-112 R113-118 R119-120 R121-122 R123-124 R127-129 R130-131 R132-134 R135-136 R137-138 R139 R140-141 R142 R143-146 R147-148 R149-150 R151 R152-153 R154 R155-157 R158 R159-160 R161 R162-163 R164 R165 R167 R168 R169 R170 R171-173 R174 R175 R176 R177 R178 R179 R180 R181 R182 R183 R184 R185 R186 R186 R187 R188-189 R190 R191
Part No. RD356470 RD357100 RD357100 RD357100 WW862501 RD357100 WW975700 RD357100 RD356330 WW975700 RD357150 RD358100 RD357470 RD356100 V8071300 RD357470 RD356100 RD353220 RD357330 RD355820 RD356820 RD356120 RD357330 RD355470 RD356820 RD355120 RD356820 WW865700 WW865102 WW863301 WW863901 WW863301 WW861300 ZG861500 RD355510 RD358330 RD357150 RD358330 RD357470 RD357100 V8070300 RD357470 WW862101 RD357470 RD357560 RD357180 WW863301 WW864101 WW863701 RD356470 RD355100 WW863301 RD355100 RD357470 WW864600 WW865102 V8070700 RF355680 RD357470 RD357100 RF355680 RD357470 WW863901 WW863200 WW865200 RD357300 RD356330 WW863901
* New Parts
Description R.CHP R.CHP R.CHP R.CHP R.CAR.FP R.CHP R.MTL.OXD R.CHP R.CHP R.MTL.OXD R.CHP R.CHP R.CHP R.CHP R.MTL.FLM R.CHP R.CHP R.CHP R.CHP R.CHP R.CHP R.CHP R.CHP R.CHP R.CHP R.CHP R.CHP R.CAR.FP R.CAR.FP R.CAR.FP R.CAR.FP R.CAR.FP R.CAR.FP R.WW R.CHP R.CHP R.CHP R.CHP R.CHP R.CHP R.MTL.FLM R.CHP R.CAR.FP R.CHP R.CHP R.CHP R.CAR.FP R.CAR.FP R.CAR.FP R.CHP R.CHP R.CAR.FP R.CHP R.CHP R.CAR.FP R.CAR.FP R.MTL.FLM R.MTL.CHP R.CHP R.CHP R.MTL.CHP R.CHP R.CAR.FP R.CAR.FP R.CAR.FP R.CHP R.CHP R.CAR.FP
4.7KΩ 10KΩ 10KΩ 10KΩ 22Ω 10KΩ 47KΩ 10KΩ 3.3KΩ 47KΩ 15KΩ 100KΩ 47KΩ 1KΩ 470Ω 47KΩ 1KΩ 2.2Ω 33KΩ 820Ω 8.2KΩ 1.2KΩ 33KΩ 470Ω 8.2KΩ 120Ω 8.2KΩ 5.6KΩ 2.2KΩ 100Ω 330Ω 100Ω 2.2Ω 0.1Ω 510Ω 330KΩ 15KΩ 330KΩ 47KΩ 10KΩ 10Ω 47KΩ 10Ω 47KΩ 56KΩ 18KΩ 100Ω 470Ω 220Ω 4.7KΩ 100Ω 100Ω 100Ω 47KΩ 1KΩ 2.2KΩ 47Ω 680Ω 47KΩ 10KΩ 680Ω 47KΩ 330Ω 82Ω 2.4KΩ 30KΩ 3.3KΩ 330Ω
1/16W 1/16W 1/16W 1/16W 1/4W 1/16W 1/4W 1/16W 1/16W 1/4W 1/16W 1/16W 1/16W 1/16W 1W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 2W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1W 1/16W 1/4W 1/16W 1/16W 1/16W 1/4W 1/4W 1/4W 1/16W 1/16W 1/4W 1/16W 1/16W 1/4W 1/4W 1W 1/16W 1/16W 1/16W 1/16W 1/16W 1/4W 1/4W 1/4W 1/16W 1/16W 1/4W
Markets J J J J
R
J R J J J J J J
R R R R
J J J J J J J J J J J J
J J J J J J J J J J
R-S202/R-S202D
*
D101 D102 D103-106 D107 D108 D109 D110-111 D112 D113 D114 D115 D117 D119-120 D125-126 D127-128 D202 D203-204 D207 D501-502 D511 D514 F1 F1 G101 IC1 IC102 IC202 IC203 IC250 IC501 JK401 PJ202 PJ203 Q1 Q2-4 Q5 Q6-7 Q8 Q101-104 Q105-106 Q107-108 Q109 Q110-111 Q112 Q113-116 Q117-118 Q119-120 Q121 Q122 Q123 Q124 Q125 Q126 Q128 Q129 Q131 Q133 Q201-204 Q205-206 Q208 Q209 Q502 Q503 Q504 R1 R2 R3 R4
J J J J
D J J D J UCTKAG RL J J UCTKAG
51
R-S202/R-S202D
R-S202
MAIN Ref No.
R-S202/R-S202D
R191 R192 R193 R194 R195 * R196 R196 R197 R198-199 R200 R201 R202 R203-204 R205-207 R208-209 R210-211 R212-215 R216-219 ⚠ R220-221 R222-223 R224-225 R226-227 R228 R231 R233 ⚠ R234 R236-237 R238 R248 R249 * R251 R252-253 R254-255 R256-258 R259 R260 R261 R262 R263 R264 R265 R266-267 R268 R269 R270-271 R272 R273 R274-275 R276 R277 R281 R282 * R283 R284 R285-287 R288 R289-290 R291 R292 R293 R294-295 R297-299 R302 R304 R305-306 R307 R308 R309
52
Part No. WW863200 WW975500 RD357300 RD357220 HL006150 WW863901 WW863200 RD357100 RD358470 RD357620 RF456100 RD355470 RD356100 RD355470 RD350000 RD358100 RD355470 RD358470 WW861600 RD358470 RD357100 RD358470 RD353220 RD356100 RD356220 V8070700 RD357100 WW862101 RD355100 RD356100 RF357151 RD356470 RD356120 RD357100 RD358100 RD357470 RD358100 RD356100 RD358470 RD356100 RD357100 RD355100 RD358470 RD356100 RD356470 RD355100 RD356120 RD358100 RD355100 RD356120 RD357100 RD356100 RF357151 RD358100 RD355100 RD353220 RD356100 RD355100 RD357100 RD356100 RD355100 RD355100 RD356220 RD357100 RD355100 RD357330 RD358120 RD357120
* New Parts
Description R.CAR.FP R.MTL.OXD R.CHP R.CHP R.MTL.OXD R.CAR.FP R.CAR.FP R.CHP R.CHP R.CHP R.CHP R.CHP R.CHP R.CHP R.CHP R.CHP R.CHP R.CHP R.CAR.FP R.CHP R.CHP R.CHP R.CHP R.CHP R.CHP R.MTL.FLM R.CHP R.CAR.FP R.CHP R.CHP R.MTL.CHP R.CHP R.CHP R.CHP R.CHP R.CHP R.CHP R.CHP R.CHP R.CHP R.CHP R.CHP R.CHP R.CHP R.CHP R.CHP R.CHP R.CHP R.CHP R.CHP R.CHP R.CHP R.MTL.CHP R.CHP R.CHP R.CHP R.CHP R.CHP R.CHP R.CHP R.CHP R.CHP R.CHP R.CHP R.CHP R.CHP R.CHP R.CHP
82Ω 39KΩ 30KΩ 22KΩ 1.5KΩ 330Ω 82Ω 10KΩ 470KΩ 62KΩ 1.0KΩ 470Ω 1KΩ 470Ω 0Ω 100KΩ 470Ω 470KΩ 3.9Ω 470KΩ 10KΩ 470KΩ 2.2Ω 1KΩ 2.2KΩ 47Ω 10KΩ 10Ω 100Ω 1KΩ 15KΩ 4.7KΩ 1.2KΩ 10KΩ 100KΩ 47KΩ 100KΩ 1KΩ 470KΩ 1KΩ 10KΩ 100Ω 470KΩ 1KΩ 4.7KΩ 100Ω 1.2KΩ 100KΩ 100Ω 1.2KΩ 10KΩ 1KΩ 15KΩ 100KΩ 100Ω 2.2Ω 1KΩ 100Ω 10KΩ 1KΩ 100Ω 100Ω 2.2KΩ 10KΩ 100Ω 33KΩ 120KΩ 12KΩ
1/4W 1/4w 1/16W 1/16W 1/2W 1/4W 1/4W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/4W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1W 1/16W 1/4W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W
SWITCH Markets RL
J J
J J J F J J J J J J J J J J J J J J J J D J J J J J J J J J J J J J J J J J J J J J D J J J J J J J J J J J J J J J
UCTKAG RL R
Ref No. R310 R311 R312 R313 ⚠ * R314-317 R318-320 ⚠ R322 R323 R324 R325-326 R327 * R328-329 R330-331 R332 R335-337 R339-340 R501-504 R508-509 R513 R514 R516 R517 R521 R522-523 R524-525 R526-527 R528 R529-530 R531-534 R541 R542 R543 R544 R546 R547 R548 R555-556 R701 R702 R703 R704 ⚠ RY1 ⚠ RY101-103 ST1 ST102-103 ST250 SW501-516 SW702 ⚠ T1 ⚠ T1 ⚠ T1 TE101 TH101 U501 * V501
⚠ ⚠ ⚠
CB1-2 CB3 F2 SW1
Part No.
Description
RD357470 RD356100 RD357100 RD355100 VC756301 WW863800 RD357180 RD357100 RD357470 RF357220 RF355100 RF357151 RF357220 RF355100 RD354223 RD355100 RD355270 RD358100 RD354470 RD356750 RD358100 RD357100 RD356470 RD356330 RD355470 RD356220 RD355470 RD356150 RD356100 RD357150 RD355620 RD356130 RD355100 RD356470 RD355470 RD356120 RD358100 RD357100 RD357470 RD357100 RD357470 WQ804101 ZJ359600 V4040500 V4040500 WA246200 WD483100 WU974000 YF764A00 YF765A00 YF766A00 V9065900 V9760200 WW715100 ZJ559100 ZG943300 WP935100
R.CHP R.CHP R.CHP R.CHP R.MTL.OXD R.CAR.FP R.CHP R.CHP R.CHP R.MTL.CHP R.MTL.CHP R.MTL.CHP R.MTL.CHP R.MTL.CHP R.CHP R.CHP R.CHP R.CHP R.CHP R.CHP R.CHP R.CHP R.CHP R.CHP R.CHP R.CHP R.CHP R.CHP R.CHP R.CHP R.CHP R.CHP R.CHP R.CHP R.CHP R.CHP R.CHP R.CHP R.CHP R.CHP R.CHP RELAY RELAY SCR.TERM SCR.TERM SCR.TERM SW.TACT SW.RT.ENC TRANS.SUB TRANS.SUB TRANS.SUB TERM.SP THRMST.CHP L.DTCT FL.DSPLY FL.SPACER HOLDER
ZN201600 WN103000 V9377900 VV071801 WV382901
P.C.B. CLIP.FUSE CN.BS.PIN FUSE SW.SLIDE
* New Parts
Markets
47KΩ 1/16W J 1KΩ 1/16W J 10KΩ 1/16W J 100Ω 1/16W J 10Ω 2W 270Ω 1/4W 18KΩ 1/16W J 10KΩ 1/16W J 47KΩ 1/16W J 22KΩ 1/16W D 100Ω 1/16W D 15KΩ 1/16W D 22KΩ 1/16W D 100Ω 1/16W D 22Ω 1/16W J 100Ω 1/16W J 270Ω 1/16W J 100KΩ 1/16W J 47Ω 1/16W J 7.5KΩ 1/16W J 100KΩ 1/16W J 10KΩ 1/16W J 4.7KΩ 1/16W J 3.3KΩ 1/16W J 470Ω 1/16W J 2.2KΩ 1/16W J 470Ω 1/16W J 1.5KΩ 1/16W J 1KΩ 1/16W J 15KΩ 1/16W J 620Ω 1/16W J 1.3KΩ 1/16W J 100Ω 1/16W J 4.7KΩ 1/16W J 470Ω 1/16W J 1.2KΩ 1/16W J 100KΩ 1/16W J 10KΩ 1/16W J 47KΩ 1/16W J 10KΩ 1/16W J 47KΩ 1/16W J DC DLS5D1-O(M)0.25 981-2A-48DS-SP7 M3 M3 3.5 SKRGAAD010 REB161(9X7)PVB20FI UC R TKAGL MSP-108V-01 PBSN NCP18XH103J03RB SIR8430MH6 010ST027GNK 1P
SWITCH TP00351-31 4P 4A 250V SL14
R
R-S202/R-S202D
R-S202D
MAIN Ref No. * ⚠ ⚠ ⚠ * *
* ⚠ *
*
* New Parts
Description P.C.B. CN.BS.PIN CLIP.FUSE CN.BS.PIN CN.BS.PIN CN.BS.PIN CN.BS.PIN CN.BS.PIN CN.BS.PIN CN.BS.PIN CN.BS.PIN CN.BS.PIN CN.BS.PIN CN CN.BS.PIN C.EL C.CE.CHP C.CE.CHP C.CE.SAFTY C.EL C.MYLAR C.CE.CHP C.CE.CHP C.EL C.EL C.CE.CHP C.EL C.EL C.CE.CHP C.MYLAR C.EL C.CE.CHP C.CE.CHP C.CE.CHP C.EL C.EL C.EL C.EL C.EL C.MYLAR C.EL C.MYLAR C.EL C.EL C.EL C.EL C.EL C.EL C.MYLAR C.EL C.EL C.EL C.MYLAR C.CE.CHP C.EL C.MYLAR C.CE.M.CHP C.CE.M.CHP C.MYLAR C.EL C.MYLAR C.EL
MAIN 2P TP00351-31 2P 3P 52806 15P TE 3P 9P 9P 17P 4P 17P 3P 24P TE SCFS852254 9P 470uF 10V 0.47 16V K RECT. 0.1uF 16V B 0.01uF 250V 2200uF 25V 0.1uF 100V 1000pF 50V B 1000pF 50V B 1uF 50V 2.2uF 50V 47pF 50V B 10uF 50V 220uF 6.3V 100pF 50V B 100pF 100V 100uF 16V 5pF 50V B 150pF 50V B 150pF 50V B 47uF 100V 10uF 100V 47uF 100V 10uF 100V 2.2uF 50V 0.022uF 100V 100uF 6.3V 100pF 100V 330uF 25V 6800uF 66V 10uF 50V 47uF 50V 6800uF 66V 1000uF 10V 100pF 100V 4.7uF 50V 10uF 50V 1000uF 63V 100pF 100V 0.01uF 50V B 2200uF 6.3V 0.1uF 100V 0.01uF 100V 0.01uF 100V 0.1uF 100V 33uF 63V 100pF 100V 10uF 16V
Markets BG
Ref No. C172 C173-176 C189 C192 C193-196 C197 C198-199 C204-205 C206-207 C208-213 C216-217 C230-231 C232 C234-245 C246-247 C248-251 C252 C253-254 C259-260 C261 C262 C263-264 C265 C266-267 C268-270 C271 C272 C273 C274 C275 C276 C277 C278 C279 C280 C281 C282 C283-284 C285 C287 C289 C290-291 C292 C401-403 C501 C502 C503 C504 C505 C506 C507-509 C512-513 C514 C515-516 C517 C518-520 C521 C523 C601 C602 C603 C604
Part No. WW194100 WN200100 WN200100 US035100 US062100 UR877100 US062100 US062220 US061470 US062220 UR837100 UR867100 US135100 UR867100 ZD519100 UR865220 US135100 UR867100 UR866100 US135100 UR829100 UR867100 US063100 UR866220 US063100 US135100 US046100 UR828220 US062100 UR867100 UR866100 US135100 UR828100 US062100 US135100 US063100 US135100 US063100 US135100 US135100 US163100 UR837100 US135100 WN200100 WQ711900 US035100 US064100 WQ711900 US035100 WQ711900 US035100 US035100 UM397100 US035100 UM397470 US062100 US035100 US062100 US064100 US035100 WD758300 UM388330
* New Parts
Description C.MYLAR C.CE.M.CHP C.CE.M.CHP C.CE.CHP C.CE.CHP C.EL C.CE.CHP C.CE.CHP C.CE.CHP C.CE.CHP C.EL C.EL C.CE.CHP C.EL C.MYLAR C.EL C.CE.CHP C.EL C.EL C.CE.CHP C.EL C.EL C.CE.CHP C.EL C.CE.CHP C.CE.CHP C.CE.CHP C.EL C.CE.CHP C.EL C.EL C.CE.CHP C.EL C.CE.CHP C.CE.CHP C.CE.CHP C.CE.CHP C.CE.CHP C.CE.CHP C.CE.CHP C.CE.CHP C.EL C.CE.CHP C.CE.M.CHP C.EL C.CE.CHP C.CE.CHP C.EL C.CE.CHP C.EL C.CE.CHP C.CE.CHP C.EL C.CE.CHP C.EL C.CE.CHP C.CE.CHP C.CE.CHP C.CE.CHP C.CE.CHP C.CE.CHP C.EL
0.1uF 0.01uF 0.01uF 0.1uF 100pF 10uF 100pF 220pF 47pF 220pF 10uF 10uF 0.1uF 10uF 1800pF 0.22uF 0.1uF 10uF 1uF 0.1uF 1000uF 10uF 1000pF 2.2uF 1000pF 0.1uF 1uF 220uF 100pF 10uF 1uF 0.1uF 100uF 100pF 0.1uF 1000pF 0.1uF 1000pF 0.1uF 0.1uF 1000pF 10uF 0.1uF 0.01uF 47uF 0.1uF 0.01uF 47uF 0.1uF 47uF 0.1uF 0.1uF 10uF 0.1uF 47uF 100pF 0.1uF 100pF 0.01uF 0.1uF 10uF 330uF
Markets
100V 100V 100V 16V B 50V B 63V 50V B 50V B 50V B 50V B 16V 50V 16V 50V 100V 50V 16V 50V 50V 16V 10V 50V 50V B 50V 50V B 16V 25V 10V 50V B 50V 50V 16V 10V 50V B 16V 50V B 16V 50V B 16V 16V 50V 16V 16V 100V 35V 16V B 50V B 35V 16V B 35V 16V B 16V B 16V 16V B 16V 50V B 16V B 50V B 50V B 16V B 10V 6.3V
R-S202/R-S202D
*
CB4 CB5-6 CB7 CB101 CB102 CB103 CB201 CB202 CB204 CB401 CB501 CB502 CB601 CB602 C1 C2-3 C4 C6 C7 C8 C9 C12 C15-16 C17 C101-102 C103-104 C105 C106 C107-109 C110-111 C112-113 C114 C117-119 C120 C121-122 C123 C124-125 C130 C131-132 C137 C138 C139 C140 C141 C142 C143 C144 C145 C146 C147 C149 C150 C152 C153 C154-155 C157-158 C160-162 C166-167 C168-169 C170 C171
Part No. ZU626000 VG879900 WN103000 VG879900 VB389900 WG033601 LB932031 VQ044400 VQ047200 VM973500 VB858300 VF982300 VB858200 ZS226200 VQ044400 UR828470 WJ590701 US035100 WQ939401 UR849221 WW194100 US063100 US063100 UR866100 UR866220 US061470 UR867100 UR818220 US062100 ZD517600 UR838100 US060500 US062150 US062150 UR897470 UR897100 UR897470 UR897100 UR866220 ZD520400 UR818100 ZD517600 UR848330 ZH998400 UR867100 UR867470 ZH998400 UR829100 ZD517600 UR866470 UR867100 UR779100 ZD517600 US064100 UR819220 WW194100 WN200100 WN200100 WW194100 UR877330 ZD517600 UR837100
53
R-S202/R-S202D
R-S202D
MAIN Ref No.
⚠
⚠* ⚠
⚠*
* ⚠ ⚠
*
⚠ ⚠
R-S202/R-S202D
#
⚠
54
C701 D1-4 D5 D7 D9-10 D101 D102 D103-106 D107 D108 D109 D110-111 D112 D113 D114 D115 D117 D125-126 D127-128 D202 D203-204 D207 D501-502 D511 D514 F1 G101 IC1 IC102 IC202 IC203 IC250 IC501 JK401 PJ202 PJ203 Q1 Q2-4 Q101-104 Q105-106 Q107-108 Q109 Q110-111 Q112 Q113-116 Q117-118 Q119-120 Q121 Q122 Q123 Q124 Q125 Q126 Q128 Q129 Q131 Q133 Q201-204 Q205-206 Q208 Q209 Q502
Part No. US035100 ZP358601 WY163800 WH471700 ZP358601 WY164800 ZP358601 ZA984400 WY162900 WY163800 WY164800 ZP358601 ZU129100 VN953300 ZP358601 WY164300 ZP358601 ZU129100 ZP358601 WY163800 WY163101 WY163101 WZ443400 WZ745700 ZR754101 VV071801 V5995800 YD268A00 XV190A00 YF439A00 YF475A00 X0515B00 YF471A00 V4478300 WD195400 WD195200 WH445000 ZE933000 WD896300 WC292201 WC883400 ZG214200 ZG214100 ZG214200 ZU111000 WF549900 WC397600 ZC256500 VJ927101 ZE918100 ZE933000 WC398300 WC397600 WC398300 ZG245700 WC397600 WC398300 WC883400 VV556500 WW782100 WQ381001 VV556400
* New Parts
Description C.CE.CHP DIODE DIODE.ZENR DIODE.BRG DIODE DIODE.ZENR DIODE DIODE DIODE.ZENR DIODE.ZENR DIODE.ZENR DIODE DIODE.CHP DIODE.BRG DIODE DIODE.ZENR DIODE DIODE.CHP DIODE DIODE.ZENR DIODE.ZENR DIODE.ZENR DIODE.ZENR LED LED FUSE PLATE.GND IC IC IC IC.CPU IC IC JACK.PHONE JACK.PIN JACK.PIN FET TR TR TR TR TR TR TR TR.POWER TR TR TR TR TR TR TR TR TR TR TR TR TR TR TR.DGT FET TR
Markets
Ref No.
0.1uF 16V B 1SS352 TE UDZV9.1B DB105 1A 600V 1SS352 TE UDZV24B 1SS352 TE BAV103 UDZV3.9B UDZV9.1B UDZV24B 1SS352 TE F3A D5SBA60 5A 600V 1SS352 TE UDZV15B 1SS352 TE F3A 1SS352 TE UDZV9.1B UDZV4.7B UDZV4.7B UDZV2.4B HLMP-Y701-G0000 HLMP-NS30 BLUE 4A 250V R1190H033B-T1-FE NJM2904M OP AMP BD3491FS R5F100JFAFA CPU LM61CIZ THERMAL HT16515-44LQFP JY-6317Y-03-030 6P 4P 3LN01C-TB-E KTC4376-Y-RTF/P 2SA1514K R,S KTC3206Y-AT 2SD2704 K KTD600K-Y-U/PH KTB631K Y,GR KTD600K-Y-U/PH 2SC4468 O,P,Y 2SC3906K T146 R,S 2N5401S-RTK/P 2SC5712 2SC2712-Y(TE85R,F) KTA1664-Y-RTF/P KTC4376-Y-RTF/P 2N5551S-RTK/P 2N5401S-RTK/P 2N5551S-RTK/P KTA1661-Y-RTF/P 2N5401S-RTK/P 2N5551S-RTK/P 2SD2704 K 2SA1037K Q,R,S DTC014EUBTL MCH6336-TL-E 2SC2412K Q,R,S
Note: Those parts marked with # are not included in the P.C.B. assembly.
*
* ⚠* * * ⚠ ⚠ * *
⚠ ⚠* ⚠*
*
⚠ * ⚠
Q503 Q504 R1 R2 R3 R4 R5 R6 R8 R9 R10 R12 R17-18 R101 R102-103 R104-105 R106-107 R108 R109-110 R111-112 R113-118 R119-120 R121-122 R123-124 R127-129 R130-131 R132-134 R135-136 R137-138 R139 R140-141 R142 R143-146 R147-148 R149-150 R151 R152-153 R154 R155-157 R158 R159-160 R161 R162-163 R164 R165 R167 R168 R169 R170 R171-173 R174 R175 R176 R177 R178 R179 R180 R181 R182 R183 R184 R185
Part No. WW782100 WC397600 RD359220 RD356100 RD355100 RD357270 RD356470 RD357100 RD357100 WW862501 RD357100 RD357100 RD357470 RD356100 V8071300 RD357470 RD356100 RD353220 RD357330 RD355820 RD356820 RD356120 RD357330 RD355470 RD356820 RD355120 RD356820 WW865700 WW865102 WW863301 WW863901 WW863301 WW861300 ZG861500 RD355510 RD358330 RD357150 RD358330 RD357470 RD357100 V8070300 RD357470 WW862101 RD357470 RD357560 RD357180 WW863301 WW864101 WW863701 RD356470 RD355100 WW863301 RD355100 RD357470 WW864600 WW865102 V8070700 RF355680 RD357470 RD357100 RF355680 RD357470
* New Parts
Description TR.DGT TR R.CHP R.CHP R.CHP R.CHP R.CHP R.CHP R.CHP R.CAR.FP R.CHP R.CHP R.CHP R.CHP R.MTL.FLM R.CHP R.CHP R.CHP R.CHP R.CHP R.CHP R.CHP R.CHP R.CHP R.CHP R.CHP R.CHP R.CAR.FP R.CAR.FP R.CAR.FP R.CAR.FP R.CAR.FP R.CAR.FP R.WW R.CHP R.CHP R.CHP R.CHP R.CHP R.CHP R.MTL.FLM R.CHP R.CAR.FP R.CHP R.CHP R.CHP R.CAR.FP R.CAR.FP R.CAR.FP R.CHP R.CHP R.CAR.FP R.CHP R.CHP R.CAR.FP R.CAR.FP R.MTL.FLM R.MTL.CHP R.CHP R.CHP R.MTL.CHP R.CHP
DTC014EUBTL 2N5401S-RTK/P 2.2MΩ 1/16W 1KΩ 1/16W 100Ω 1/16W 27KΩ 1/16W 4.7KΩ 1/16W 10KΩ 1/16W 10KΩ 1/16W 22Ω 1/4W 10KΩ 1/16W 10KΩ 1/16W 47KΩ 1/16W 1KΩ 1/16W 470Ω 1W 47KΩ 1/16W 1KΩ 1/16W 2.2Ω 1/16W 33KΩ 1/16W 820Ω 1/16W 8.2KΩ 1/16W 1.2KΩ 1/16W 33KΩ 1/16W 470Ω 1/16W 8.2KΩ 1/16W 120Ω 1/16W 8.2KΩ 1/16W 5.6KΩ 1/4W 2.2KΩ 1/4W 100Ω 1/4W 330Ω 1/4W 100Ω 1/4W 2.2Ω 1/4W 0.1Ω 2W 510Ω 1/16W 330KΩ 1/16W 15KΩ 1/16W 330KΩ 1/16W 47KΩ 1/16W 10KΩ 1/16W 10Ω 1W 47KΩ 1/16W 10Ω 1/4W 47KΩ 1/16W 56KΩ 1/16W 18KΩ 1/16W 100Ω 1/4W 470Ω 1/4W 220Ω 1/4W 4.7KΩ 1/16W 100Ω 1/16W 100Ω 1/4W 100Ω 1/16W 47KΩ 1/16W 1KΩ 1/4W 2.2KΩ 1/4W 47Ω 1W 680Ω 1/16W 47KΩ 1/16W 10KΩ 1/16W 680Ω 1/16W 47KΩ 1/16W
Markets
J J J J J J J J J J J J J J J J J J J J J J J
J J J J J J J J J J
J J J J
D J J D J
R-S202/R-S202D
R-S202D
MAIN Ref No.
Part No. WW863901 WW865200 RD357300 RD356330 WW863901 WW975500 RD357300 RD357220 HL006150 WW863901 RD358470 RD357620 RF456100 RD355470 RD356100 RD355470 RD350000 RD358100 RD355470 RD358470 WW861600 RD358470 RD357100 RD358470 RD353220 RD356100 RD356220 V8070700 RD357100 WW862101 RD355100 RD356100 RF357151 RD356470 RD356120 RD357100 RD358100 RD357470 RD358100 RD356100 RD358470 RD356100 RD357100 RD355100 RD358470 RD356100 RD356470 RD355100 RD356120 RD358100 RD355100 RD356120 RD357100 RD356470 RD357100 RD356100 RF357151 RD358100 RD355100 RD353220 RD356100 RD355100
* New Parts
Description R.CAR.FP R.CAR.FP R.CHP R.CHP R.CAR.FP R.MTL.OXD R.CHP R.CHP R.MTL.OXD R.CAR.FP R.CHP R.CHP R.CHP R.CHP R.CHP R.CHP R.CHP R.CHP R.CHP R.CHP R.CAR.FP R.CHP R.CHP R.CHP R.CHP R.CHP R.CHP R.MTL.FLM R.CHP R.CAR.FP R.CHP R.CHP R.MTL.CHP R.CHP R.CHP R.CHP R.CHP R.CHP R.CHP R.CHP R.CHP R.CHP R.CHP R.CHP R.CHP R.CHP R.CHP R.CHP R.CHP R.CHP R.CHP R.CHP R.CHP R.CHP R.CHP R.CHP R.MTL.CHP R.CHP R.CHP R.CHP R.CHP R.CHP
330Ω 2.4KΩ 30KΩ 3.3KΩ 330Ω 39KΩ 30KΩ 22KΩ 1.5KΩ 330Ω 470KΩ 62KΩ 1.0KΩ 470Ω 1KΩ 470Ω 0Ω 100KΩ 470Ω 470KΩ 3.9Ω 470KΩ 10KΩ 470KΩ 2.2Ω 1KΩ 2.2KΩ 47Ω 10KΩ 10Ω 100Ω 1KΩ 15KΩ 4.7KΩ 1.2KΩ 10KΩ 100KΩ 47KΩ 100KΩ 1KΩ 470KΩ 1KΩ 10KΩ 100Ω 470KΩ 1KΩ 4.7KΩ 100Ω 1.2KΩ 100KΩ 100Ω 1.2KΩ 10KΩ 4.7KΩ 10KΩ 1KΩ 15KΩ 100KΩ 100Ω 2.2Ω 1KΩ 100Ω
1/4W 1/4W 1/16W 1/16W 1/4W 1/4w 1/16W 1/16W 1/2W 1/4W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/4W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1W 1/16W 1/4W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W
Markets
J J
J J
J J F J J J J J J J J J J J J J J J J D J J J J J J J J J J J J J J J J J J J J J J J D J J J J J
Ref No. R292 R293 R294-295 R297-299 R302 R305-306 R307 R308 R309 R310 R311 R312 R313 ⚠ * R314-317 R318-320 R322 R323 R324 R325-326 R327 * R328-329 R330-331 R332 R335-337 R339-340 R501-504 R508-509 R513 R514 R516 R517 R521 R522-523 R524-525 R526-527 R528 R529-530 R531-534 R541 R542 R543 R544 R546 R547 R548 R555-556 R602 R603 R604-605 R606 R701 R702 R703 R704 ⚠ RY1 ⚠ RY101-103 ST1 ST102-103 ST250 ST601 SW501-516 SW702
Part No. RD357100 RD356100 RD355100 RD355100 RD356220 RD355100 RD357330 RD358120 RD357120 RD357470 RD356100 RD357100 RD355100 VC756301 WW863800 RD357180 RD357100 RD357470 RF357220 RF355100 RF357151 RF357220 RF355100 RD354223 RD355100 RD355270 RD358100 RD354470 RD356750 RD358100 RD357100 RD356470 RD356330 RD355470 RD356220 RD355470 RD356150 RD356100 RD357150 RD355620 RD356130 RD355100 RD356470 RD355470 RD356120 RD358100 RD357100 RD350000 RD356470 RD350000 RD357100 RD357470 RD357100 RD357470 WQ804101 ZJ359600 V4040500 V4040500 WA246200 ZR366200 WD483100 WU974000
* New Parts
Description R.CHP R.CHP R.CHP R.CHP R.CHP R.CHP R.CHP R.CHP R.CHP R.CHP R.CHP R.CHP R.CHP R.MTL.OXD R.CAR.FP R.CHP R.CHP R.CHP R.MTL.CHP R.MTL.CHP R.MTL.CHP R.MTL.CHP R.MTL.CHP R.CHP R.CHP R.CHP R.CHP R.CHP R.CHP R.CHP R.CHP R.CHP R.CHP R.CHP R.CHP R.CHP R.CHP R.CHP R.CHP R.CHP R.CHP R.CHP R.CHP R.CHP R.CHP R.CHP R.CHP R.CHP R.CHP R.CHP R.CHP R.CHP R.CHP R.CHP RELAY RELAY SCR.TERM SCR.TERM SCR.TERM SUPPORT.DA SW.TACT SW.RT.ENC
Markets
10KΩ 1/16W J 1KΩ 1/16W J 100Ω 1/16W J 100Ω 1/16W J 2.2KΩ 1/16W J 100Ω 1/16W J 33KΩ 1/16W J 120KΩ 1/16W J 12KΩ 1/16W J 47KΩ 1/16W J 1KΩ 1/16W J 10KΩ 1/16W J 100Ω 1/16W J 10Ω 2W 270Ω 1/4W 18KΩ 1/16W J 10KΩ 1/16W J 47KΩ 1/16W J 22KΩ 1/16W D 100Ω 1/16W D 15KΩ 1/16W D 22KΩ 1/16W D 100Ω 1/16W D 22Ω 1/16W J 100Ω 1/16W J 270Ω 1/16W J 100KΩ 1/16W J 47Ω 1/16W J 7.5KΩ 1/16W J 100KΩ 1/16W J 10KΩ 1/16W J 4.7KΩ 1/16W J 3.3KΩ 1/16W J 470Ω 1/16W J 2.2KΩ 1/16W J 470Ω 1/16W J 1.5KΩ 1/16W J 1KΩ 1/16W J 15KΩ 1/16W J 620Ω 1/16W J 1.3KΩ 1/16W J 100Ω 1/16W J 4.7KΩ 1/16W J 470Ω 1/16W J 1.2KΩ 1/16W J 100KΩ 1/16W J 10KΩ 1/16W J 0Ω 1/16W J 4.7KΩ 1/16W J 0Ω 1/16W J 10KΩ 1/16W J 47KΩ 1/16W J 10KΩ 1/16W J 47KΩ 1/16W J DC DLS5D1-O(M)0.25 981-2A-48DS-SP7 M3 M3 3.5
R-S202/R-S202D
* R186 R187 R188-189 R190 * R191 R192 R193 R194 R195 * R196 R198-199 R200 R201 R202 R203-204 R205-207 R208-209 R210-211 R212-215 R216-219 ⚠ R220-221 R222-223 R224-225 R226-227 R228 R231 R233 ⚠ R234 R236-237 R238 R248 R249 * R251 R252-253 R254-255 R256-258 R259 R260 R261 R262 R263 R264 R265 R266-267 R268 R269 R270-271 R272 R273 R274-275 R276 R277 R279 R280 R281 R282 * R283 R284 R285-287 R288 R289-290 R291
SKRGAAD010 REB161(9X7)PVB20FI
55
R-S202/R-S202D
R-S202D
MAIN Ref No. T1 TE101 TH101 U501 * V501
Part No. YF766A00 V9065900 V9760200 WW715100 ZJ559100 ZG943300 WP935100
R-S202/R-S202D
⚠
56
* New Parts
Description TRANS TERM.SP THRMST.CHP L.DTCT FL.DSPLY FL.SPACER HOLDER
MSP-108V-01 PBSN NCP18XH103J03RB SIR8430MH6 010ST027GNK 1P
Markets
R-S202/R-S202D
Carbon Resistors Value 1.0 Ω 1.8 Ω 2.2 Ω 3.3 Ω 4.7 Ω 5.6 Ω 10 Ω 15 Ω 22 Ω 27 Ω 33 Ω 39 Ω 47 Ω 56 Ω 68 Ω 75 Ω 82 Ω 91 Ω 100 Ω 110 Ω 120 Ω 150 Ω 160 Ω 180 Ω 200 Ω 220 Ω 270 Ω 330 Ω 390 Ω 430 Ω 470 Ω 510 Ω 560 Ω 680 Ω 820 Ω 910 Ω 1.0 kΩ 1.2 kΩ 1.5 kΩ 1.8 kΩ 2.0 kΩ 2.2 kΩ 2.4 kΩ 2.7 kΩ 3.0 kΩ 3.3 kΩ 3.6 kΩ 3.9 kΩ 4.7 kΩ 5.1 kΩ 5.6 kΩ 6.8 kΩ 8.2 kΩ 9.1 kΩ 10 kΩ
1/4W Type Part No. 1/6W Type Part No. HJ35 3100 HF85 3100 HJ35 3180 HF85 3220 HJ35 3220 HF85 3330 HJ35 3330 HJ35 3470 HF85 3470 HJ35 3560 HF85 3560 HF45 4100 HF45 4100 HJ35 4150 HF85 4150 HF45 4220 HF45 4220 HJ35 4270 HF85 4270 HF45 4330 HF45 4330 HJ35 4470 HF85 4390 HF45 4470 HF45 4470 HF45 4560 HF45 4560 HF45 4680 HF45 4680 HF45 4750 HF45 4750 HF45 4820 HF45 4820 HF45 4910 HF45 4910 HF45 5100 HF45 5100 HF85 5110 HJ35 5110 HF45 5120 HF45 5120 HF45 5150 HF45 5150 HJ35 5160 HF45 5180 HF45 5180 HF45 5200 HF45 5200 HF45 5220 HF45 5220 HF45 5270 HF45 5270 HF45 5330 HF45 5330 HF45 5390 HF45 5390 HF45 5430 HF45 5430 HF45 5470 HF45 5470 HF45 5510 HF45 5510 HF45 5560 HF45 5560 HF45 5680 HF45 5680 HF45 5820 HF45 5820 HF45 5910 HF45 5910 HF45 6100 HF45 6100 HF45 6120 HF45 6120 HF45 6150 HF45 6150 HF45 6180 HF45 6180 HJ35 6200 HF85 6200 HF45 6220 HF45 6220 HJ35 6240 HF85 6240 HF45 6270 HF45 6270 HF45 6300 HF45 6300 HF45 6330 HF45 6330 HJ35 6360 HF85 6360 HF45 6390 HF45 6390 HF45 6470 HF45 6470 HF45 6510 HF45 6510 HF45 6560 HF45 6560 HF45 6680 HF45 6680 HF45 6820 HF45 6820 HF45 6910 HF45 6910 HF45 7100 HF45 7100
Value 11 kΩ 12 kΩ 13 kΩ 15 kΩ 18 kΩ 22 kΩ 24 kΩ 27 kΩ 30 kΩ 33 kΩ 36 kΩ 39 kΩ 47 kΩ 51 kΩ 56 kΩ 62 kΩ 68 kΩ 82 kΩ 91 kΩ 100 kΩ 110 kΩ 120 kΩ 130 kΩ 150 kΩ 180 kΩ 220 kΩ 270 kΩ 300 kΩ 330 kΩ 390 kΩ 470 kΩ 560 kΩ 680 kΩ 820 kΩ 1.0 MΩ 1.2 MΩ 1.5 MΩ 1.8 MΩ 2.2 MΩ 3.3 MΩ 3.9 MΩ 4.7 MΩ
1/4W Type Part No. 1/6W Type Part No. HF45 7110 HF45 7110 HJ35 7120 HF85 7120 HF45 7130 HF45 7130 HF45 7150 HF45 7150 HF45 7180 HF45 7180 HF45 7220 HF45 7220 HF45 7240 HF45 7240 HJ35 7270 HF85 7270 HF45 7300 HF45 7300 HF45 7330 HF45 7330 HF45 7360 HF45 7360 HF45 7390 HF45 7390 HF45 7470 HF45 7470 HF45 7510 HF45 7510 HF45 7560 HF45 7560 HF45 7620 HF45 7620 HF45 7680 HF45 7680 HF45 7820 HF45 7820 HF45 7910 HF45 7910 HF45 8100 HF45 8100 HF45 8110 HF45 8110 HF45 8120 HF45 8120 HF45 8130 HF45 8150 HF45 8150 HF45 8180 HF45 8180 HJ35 8220 HF85 8220 HF45 8270 HF45 8270 HF45 8300 HF45 8300 HF45 8330 HF45 8330 HF85 8390 HJ35 8390 HF45 8470 HF45 8470 HF85 8560 HJ35 8560 HF85 8680 HJ35 8680 HF85 8820 HJ35 8820 HF45 9100 HF45 9100 HJ35 9120 HJ35 9150 HF85 9150 HJ35 9180 HF85 9180 HJ35 9220 HF85 9220 HJ35 9330 HF85 9330 HJ35 9390 HJ35 9470 HF85 9470
1/4W Type HF45
1/4W Type HJ35
1/6W Type HF85
10mm
5mm
: Not available
57
A
B
C
D
E
F
G
H
I
J
R-S202/R-S202D
•
1
OVERALL ASSEMBLY
R model
77
35
25 52
74
36
35 73
79
2
78
4
1 (7)
72
73
73 101
79 51
12
71
3 32 (2)
77
76
10
1 (5)
76
3
73
70 38 103
70
4
32 (3)
70
72
72
1 (6)
53
75
102
70
14
79
70
1 (3) 72
70
31
13
5 1 (2)
72
70
32 (1)
1 (1) 50
2
62
1 (4) 55
R-S202D
6
61
33
200
11
72 203 R-S202 202 U, C, R, L models 200-1 7
202 T, K, A, G models
72 204 R-S202D
205 T model
54
55 72
14 58
80
1 (8)
35
73
R-S202/R-S202D
Ref No.
Part No.
Description
Remarks
Markets
Ref No.
Part No.
Description
Remarks
*
1
ZU625400
P.C.B. ASSEMBLY
MAIN
UC
70
WE774800
BIND HEAD P-TIGHT SCREW
3x8
*
1
ZU625500
P.C.B. ASSEMBLY
MAIN
R
71
VK173200
SCREW TRANSISTOR
3x15
*
1
ZU625600
P.C.B. ASSEMBLY
MAIN
TK
72
WE774300
BIND HEAD B-TIGHT SCREW
3x8
MFZN2W3
*
1
ZU625700
P.C.B. ASSEMBLY
MAIN
A
73
WE774100
BIND HEAD BONDING B-T. SCREW
3x8
MFZN2B3
*
1
ZU625800
P.C.B. ASSEMBLY
MAIN
R-S202
G
74
WE877900
BIND HEAD S-TIGHT SCREW
3x6
MFZN2W3
*
1
ZU626000
P.C.B. ASSEMBLY
MAIN
R-S202D
BG
75
WE774600
HEXAGONAL HEAD B-TIGHT SCREW
3x18
MFZN2W3
*
1
ZU625900
P.C.B. ASSEMBLY
MAIN
L
76
ZK590300
BIND S-TIGHT SCREW
4x10 SP
MFZN2W3
*
2
ZU626100
P.C.B. ASSEMBLY
BTCARD
77
VH313200
PW HEAD S-TIGHT SCREW
4x8-10
MFNI3BL
BL
3
ZP339600
TUNER MODULE
TUNER TU-04
R-S202
UCRL
77
VD069600
PW HEAD S-TIGHT SCREW
4x8-10
MFNI33
SI
3
ZP339700
TUNER MODULE
TUNER TU-04
R-S202
TKAG
78
WE200500
DISH HEAD B-TIGHT SCREW
3x6
MFNI3BL
BL
4
ZN201600
P.C.B. ASSEMBLY
SWITCH
R
78
WE200400
DISH HEAD B-TIGHT SCREW
3x6
MFNI33
SI
⚠
10
YF699A00
POWER TRANSFORMER
UC
79
ZK590400
BIND B-TIGHT SCREW
3x8
MFZN2W3
⚠
10
YF700A00
POWER TRANSFORMER
R
80
WG205000
NUT
3/8 UNEF-32
⚠
10
YF702A00
POWER TRANSFORMER
T
101
WQ621800
DAMPER
2x10x310
Markets
MFZN2W3 SP
MFC2
R
R-S202D
⚠
10
YF703A00
POWER TRANSFORMER
KA
102
V5881100
CUSHION
5x8x25
⚠
10
YF705A00
POWER TRANSFORMER
BG
103
ZK306200
INSULATOR
4x60x0.25
⚠
10
YF704A00
POWER TRANSFORMER
11
ZT362800
DAB MODULE
VERONA2
R-S202D
#
12
ZU111000
POWER TRANSISTOR
2SC4468 O,P,Y
Q113-116
*
200
ZU492600
REMOTE CONTROL
RAX33
*
13
MF117300
FLEXIBLE FLAT CABLE
17P 300mm P=1.25
*
200-1
ZV285900
BATTERY COVER
Black
14
MF109071
FLEXIBLE FLAT CABLE
9P
202
ZQ304900
FM ANTENNA
1P 1.4m
1pc
R-S202
UCRL
⚠
25
WY040900
POWER CABLE
1.8m
UC
202
VQ147100
FM ANTENNA
1.4m
1pc
R-S202
TKAG
⚠
25
WY042500
POWER CABLE
1.8m
R
203
VR248500
AM ANTENNA
1m
1pc
R-S202
⚠
25
WY042600
POWER CABLE
1.8m
T
204
WG233200
DAB/FM ANTENNA
1.6m
1pc
R-S202D
⚠
25
WY042400
POWER CABLE
1.8m
K
205
ZK090800
ANTENNA ISOLATOR
11D05Z59
1pc
⚠
25
WY042100
POWER CABLE
1.8m
A
BATTERY
R6,AA,UM-3 2pcs
⚠
25
WY041100
POWER CABLE
1.8m
B
1.8m
⚠
L
70mm
BG
P=1.25
ACCESSORIES
6005A001
25
WY041700
POWER CABLE
*
31
ZU460600
FRONT PANEL
R-S202 BL
UC
ZK189200
RS-232C CONVERSION ADAPTOR
V5.0 without FFC
*
31
ZU460700
FRONT PANEL
R-S202 BL
RTKAGL
ZD896000
FLEXIBLE FLAT CABLE
9P 150mm P=1.25
*
31
ZU460900
FRONT PANEL
R-S202D BL
*
31
ZU460800
FRONT PANEL
R-S202 SI
*
31
ZU461000
FRONT PANEL
R-S202D SI
32
ZG936900
BUTTON
BL
32
ZG937000
BUTTON
SI
33
ZH629500
KNOB
VOLUME
BL
33
ZH629600
KNOB
VOLUME
SI
*
35
ZU649100
REAR PANEL
UC
*
35
ZU649200
REAR PANEL
R
*
35
ZU649300
REAR PANEL
R-S202
*
35
ZU649400
REAR PANEL
R-S202D
36
ZG942200
TOP COVER
BL
36
ZG942300
TOP COVER
*
38
ZJ666900
SSUPPORT
*
50
ZU461100
WINDOW SHEET
51
VV849300
RADIATION SHEET
19x24
52
V2438700
CORD STOPPER
10P1
53
WQ664500
SUPPORT
H8
54
ZG943200
CUSHION
LEG
55
ZC1818i0
LEG
D60/H21 Black
20x20x2 R2
61
ZS601900
PUSH RIVET
P2648(B)
R-S202D
62
VQ368600
PUSH RIVET
P3555-B
* New Parts
GL
RC7060N010008
T
SERVICE TOOLS
SUPPORTING TAPE
TKAGL
SI TOP
Finish ....... BL: Black color, SI: Silver color Note: Those parts marked with # are not included in the P.C.B. assembly.
* New Parts
59
A
B
C
D
E
F
G
H
I
J
R-S202/R-S202D
■ REMOTE CONTROL KEY NO. LAYOUT
PANEL
KEY CODE
RAX33
2
Key No
U1 GPM6P1001A 1 2
PB3
PB2
PB4
PB1
16
1
15
4 PB5
4 5
3
6
PB0
PD0
VSS_TX
PD1
VDD
PD2
7
LED
PD3
8
VSS
PD4
PD5
7
13 VDD
4
VCC C1
11
10 13
10 9
16
7
11
16
22
29
37
46
56
3
5
8
12
17
23
30
38
47
57
10
13
18
24
31
39
48
58
12
19
25
32
40
49
59
15
20
26
33
41
50
60
21
27
34
42
51
61
28
35
43
52
62
45
53
64
55
65
20
18 21 23
26
27
28
63
54
17
15
24
29 44
14
31
30 33
34
66
37
6
38
39
40
41
42
43
44
45
1
SLEEP
7A-30
3
z STANDBY/ON
7E-2A
4
LINE 1
7A-C1
5
LINE 2
7A-19
6
LINE 3
7A-18
7
CD
7A-15
8
TUNER
7A-16
9
BAND
7A-AE
10
TUNING
7F01-641B
11
TUNING
7F01-611E
12
MEMORY
7F01-6718
13
PRESET
7F01-5E21
14
PRESET
7F01-5B24
15
INFO
7A-2758
16
TREBLE -
7A-BAC5
17
TREBLE +
7A-B9C6
18
SPEAKERS A
19
BASS -
7A-B8C7
20
BASS +
7A-B7C8
21
SPEAKERS B
7A-9B
22
BALANCE L
7A-BBC4
23
BALANCE R
7A-BCC3
24
▲ (up)/BLUETOOTH
60
(left)/BLUETOOTH f
25 26
ENTER
7A-9A
7A-9D 7A-9F 7A-DE
(right)/BLUETOOTH g
28
(down)/BLUETOOTH ad
29
MENU
30
DIMMER
31
VOLUME +
7A-1A
33
MUTE
7A-1C
34
VOLUME -
7A-1B
37
s(stop)
79-56
38
d(pause)
79-55
39
a(play)
79-02
40
DISC SKIP
79-4F
41
f(skip-)
79-04
42
g(skip+)
27
43
7
Code
▲
14
36
11
22
25
5
9
BAT 3V
4
9
8
12
2
6
6
VCC
19 1
5
14
4.7 uF/50 V
3
3
Function
▲
SCHEMATIC DIAGRAM
▲
1
(open/close)
7A-9E 7A-9C 7A-84 7A-82FD
79-07 79-01
44
h(search-)
79-05
45
j(search+)
79-06
R-S202/R-S202D
MEMO
R-S202/R-S202D 61
R-S202/R-S202D