Catalogue

®

86727153 05 / 2015 Rev 06

025MTa160WB45- MLQ

P T 1.5

+ 1.2

Parts list 零部件明细

1.3

1.1

1.4

86726783

MAINTENANCE LEGEND 维护保养图例 PARTS TO CHANGE 更换零件 Depending on applications. 根据实际应用而定 Every 100 hours. 每100小时 Every 400 hours. 每400小时 Every 800 hours. 每800小时 Every 1600 hours. 每1600小时 Long term, only if damaged. 长期使用，只有损坏时更换

CAUTION 注意事项 If drifter settings are incorrect, wear parts can be damaged prematurely. 如果凿岩机调试不当，易损件可能过早损坏 If the drifter is used with deflated accumulators, premature damage can be caused to all parts. 如果蓄能器泄露压力，所有零件可能过早损坏 These inspection intervals can vary depending on ground conditions, use of drifter....... 大修间隔时间可能根据工况、凿岩机使用等情况而变化

E MONTABERT HC25 - 2015

025MTa****B45**L-

索引

70 63 Nm

60

120 130

100

37 Nm 140

80 170

110 +

90

50

80 Nm 190

235 mm mini 最短235mm 20

52 Nm 180

40

200 80 Nm

30

10

150 52 Nm

210 52 Nm

160 80 Nm

PARTS TO CHANGE 更换零件 Depending on applications. 根据实际应用而定

数量

品号

Description

名称

10

1

86714383

Carter

壳体

20

1

86714466

Cylinder

缸体

30

1

86250107

Drive component

滚针轴承

40

1

86221595

Drive component

滚针轴承

50

1

86679388

Seal

密封

60

1

86715489

Upper cylinder

上缸体

70

1

86624160

Pin

销

80

1

86715414

Strike piston

冲击活塞

90

1

86715422

Distributor

配油阀

100

1

86714490

Upper flange

上法兰

110

1

86633922

Diaphragm

氮气隔膜

120

12

95421335

UNF3/8”, socket head screw

UNF 3/8" 内六角螺栓

130

1

86600632

Valve

阀

140

1

86580966

Threaded plug

螺纹堵

150

1

95303368

Adaptor

接头

160

2

95303384

Adaptor

接头

170

1

86715448

Push

推杆

180

1

86418357

Plug

堵

190

2

86632916

Plug

堵

200

2

86263233

Plug

堵

210

1

86247723

Plug

堵

Every 100 hours. 每100小时 Every 400 hours. 每400小时 Every 800 hours. 每800小时 Every 1600 hours. 每1600小时 Long term, only if damaged. 长期使用，只有损坏时更换

11807 (05 / 2015) - rev 06

1.1

1.2 E MONTABERT HC25 - 2015

160*B45**L-

55 Nm

025MTa

152 Nm

410

430

80 Nm

380

390 310

400 102 Nm

420 300

340 330

370

350

索引

数量

品号

300

1

310

1

320 330 340

Description

名称

86697083

Hydraulic motor

液压马达

86668670

Rear cover

后盖

1

86715430

Piston cover

活塞盖

1

86668860

Thrust

滚轴垫圈

1

86668886

Ring

环

350

1

86712403

Ring

环

360

1

86684263

Seal

密封

370

1

86668696

Motor shaft

马达轴

380

1

86350857

O’ring

O型圈

390

8

95234712

UNF1/2”, socket head screw

UNF 1/2" 内六角螺栓

400

4

86548609

M12, socket head screw

M12 六角螺栓

410

2

86330107

Adaptor

接头

420

1

86420098

O’ring

O型圈

430

2

86247723

Plug

堵

320

360

PARTS TO CHANGE 更换零件 Depending on applications. 根据实际应用而定 Every 100 hours. 每100小时 Every 400 hours. 每400小时 Every 800 hours. 每800小时 Every 1600 hours. 每1600小时 Long term, only if damaged. 长期使用，只有损坏时更换

11810 (05 / 2015) - rev 06

1.3 E MONTABERT HC25 - 2015

WB45 - ML-

025MTa***

650

690

630 670

590 680

640 660 600

570

610

700

500 550 510 520 540 530 126 Nm

620 580 850 Nm

560 52 Nm

52 Nm

PARTS TO CHANGE 更换零件 Depending on applications. 根据实际应用而定

索引

数量

品号

500

1

510

1

520 530

Description

名称

86715455

Front guide

前导壳体

86736311

Ring

前导套

1

86582558

Snap ring

卡环

8

86715943

UNF1/2”, hexa. screw

UNF 1/2" 六角螺栓

540

8

86467032

Washer

垫圈

550

1

86715463

Ring

环

560

1

95303335

Adaptor

接头

570

1

86726734

Seal kit

水密封包

580

1

86728698

Front cover

前盖

590

2

86267069

O’ring

O型圈

600

1

86684271

Seal

密封

610

1

86733243

Retainer socket

钎尾把持套

620

1

86732526

O’ring

O型圈

630

1

86732575

Spline shank+Ring

钎尾花键套+环

640

1

86624160

Pin

销

650

1

86737376

Shank stop

钎尾把持套

660

1

86473303

O’ring

O型圈

670

1

86676822

Roller thrust

滚轴垫圈

680

1

86676889

Ring

环

690

1

86715554

Lip seal

唇形密封

700

1

86247723

Plug

堵

Every 100 hours. 每100小时 Every 400 hours. 每400小时 Every 800 hours. 每800小时 Every 1600 hours. 每1600小时 Long term, only if damaged. 长期使用，只有损坏时更换

11928 ( 05 / 2015 ) - rev 03

1.4 E MONTABERT HC25 - 2015

025MTa****B45**LA

索引

数量

品号

800

1

A

1

Description

名称

86711421

Shank (R32 female)

R32阴钎尾

86751831

Control gauge kit

检测卡尺套装

86730942

+ 86750569 800

R32 f

202 PARTS TO CHANGE 更换零件 Depending on applications. 根据实际应用而定 Every 100 hours. 每100小时 Every 400 hours. 每400小时 Every 800 hours. 每800小时 Every 1600 hours. 每1600小时 Long term, only if damaged. 长期使用，只有损坏时更换

11910 ( 05 / 2015 ) - rev 06

E MONTABERT - 2015

Seals kit

水密封包

025MTa***********

86350857 380

- 8673282386420098 420 86684263 360

86679388 50

86715554 690 86473303 660

86732526 620

86684271 600

Old version

旧版

86668944 660 570

570

86267069 590

570

- 86726734 1.5

MONTABERT SAS 203 Route de Grenoble CS 80097 69805 St PRIEST CEDEX FRANCE © Copyright 2015 Montabert. Any unauthorized use or copying of the contents or any part thereof is prohibited. Illustrations and photos in this brochure may show equipment with optional extras. Nothing contained in this brochure is intended to extend any warranty or representation expressed or implied, regarding the products described herein. Any such warranties or other terms and conditions of sale products shall be in accordance with Montabert’s standard terms and conditions of sale for such products, which are available upon request. Specifications and machines can be modified at any time and without notice. Montabert Société par Actions Simplifiée (SAS) au capital de 8,459,359 € - 397 482 647 RCS LYON

MONTABERT ®

www.montabert.com