Loading documents preview...
Automated Hematology Analyzer MEK-7300K
If you have any comments or suggestions on this manual, please contact us at: www.nihonkohden.com
0634-900905
In order to use this product safely and fully understand all its functions, make sure to read this manual before using the product. Keep this manual near the instrument or in the reach of the operator and refer to it whenever the operation is unclear. The contents of this manual are subject to change without notice.
Copyright Notice The entire contents of this manual are copyrighted by Nihon Kohden. All rights are reserved. No part of this document may be reproduced, stored, or transmitted in any form or by any means (electronic, mechanical, photocopied, recorded, or otherwise) without the prior written permission of Nihon Kohden.
Trademark
The mark printed on the SD card that is used in this instrument is a trademark. The company name and model name are trademarks and registered trademarks of each company.
After signing this non-disclosure agreement or equivalent, you can use the technical reference manual.
Non-Disclosure Agreement (Sample) THIS AGREEMENT between
(COMPANY) and Nihon Kohden Corporation (NK),
effective from the date stated below by COMPANY, shall govern the conditions of disclosure of the Technical Reference Manual and other confidential technical information given to COMPANY by NK relating to Nihon Kohden hematology analyzer
(collectively “Confidential Information”).
COMPANY hereby agrees not to disclose Confidential Information to any other party or copy the Confidential Information without the express written consent of NK. Upon request of NK, COMPANY shall immediately return the Technical Reference Manual, including all copies, to NK. THIS AGREEMENT shall not apply to the following information. (a) Publicly known before or after disclosure by NK through no fault of COMPANY. (b) In the possession of COMPANY before disclosure by NK. (c) Acquired by COMPANY from a third party having an independent right to disclose the information. If COMPANY causes damage to NK against THIS AGREEMENT, COMPANY shall make compensation for the damage. When any discrepancy occurs in the interpretation of THIS AGREEMENT or when any discrepancy occurs between COMPANY and NK in regard to matters not stipulated in THIS AGREEMENT, COMPANY and NK shall discuss the discrepancy amicably in order to reach a solution in good faith. Two copies of THIS AGREEMENT shall be made and signed by COMPANY and NK. COMPANY and NK shall each have one copy of THIS AGREEMENT. COMPANY NK Date:
Date:
Company:
Nihon Kohden Corporation
Address:
1-31-4, Nishiochiai, Shinjuku-ku, Tokyo
Signature:
Signature:
Signee’s name in block letters:
Technical Reference Manual MEK-7300K
N.1
Contents Section 1
1 2
Replaceable Parts List........................................................... 1.1 Composition...................................................................................................................... 1.3 Units and Boards.............................................................................................................. 1.6 Units....................................................................................................................... 1.6 Boards.................................................................................................................... 1.8 Chassis........................................................................................................................... 1.10 MC-730V CBC Measuring Unit....................................................................................... 1.12 MJ-730V Flow Cytometry Piping Unit............................................................................. 1.14 YZ-002B1 (VALVE PLATE 3P45IN ASSY): 602.............................................................. 1.16 YZ-002B2 (VALVE PLATE 2POUT ASSY): 603.............................................................. 1.17 YZ-002B3 (VALVE PLATE 4PIN ASSY): 604.................................................................. 1.18 YZ-002B4 (VALVE PLATE 2P45IN ASSY): 605.............................................................. 1.19 YZ-002B5 (VALVE PLATE 4POUT ASSY): 606.............................................................. 1.20 YZ-002B6 (VALVE PLATE 3POUT ASSY): 607.............................................................. 1.21 Flow Cell Adjusting Fixture............................................................................................. 1.22 MP-640V Pump Unit....................................................................................................... 1.23 MP-730V Mixed Pump Unit............................................................................................. 1.24 MP-731V Triple Pump Unit.............................................................................................. 1.25 MS-730V Sampler Unit................................................................................................... 1.26 MS-731V Cap Pierce Unit............................................................................................... 1.28 JQ-731V/JQ-732V Valve Unit.......................................................................................... 1.29 JQ-730V Inlet/Outlet Unit................................................................................................ 1.30 YZ-003B1 (VALVE PLATE 3PIN ASSY): 712.................................................................. 1.32 Power Supply Unit.......................................................................................................... 1.33 PV-730VK Front Panel Unit............................................................................................. 1.34 WA-730VK Printer........................................................................................................... 1.36
Section 2
Cable Wiring and Tube List.................................................... 2.1 Cable Wiring..................................................................................................................... 2.2 SOCKET HOUSING......................................................................................................... 2.9 Tube List......................................................................................................................... 2.10 Hydraulic System Diagram............................................................................................. 2.11 Block Diagram................................................................................................................. 2.12
Technical Reference Manual MEK-7300K
C.1
Section 1 Replaceable Parts List Composition.......................................................................................................................................................... 1.3 Units and Boards.................................................................................................................................................. 1.6 Units........................................................................................................................................................... 1.6 Boards........................................................................................................................................................ 1.8 Chassis............................................................................................................................................................... 1.10 MC-730V CBC Measuring Unit.......................................................................................................................... 1.12 MJ-730V Flow Cytometry Piping Unit................................................................................................................. 1.14 YZ-002B1 (VALVE PLATE 3P45IN ASSY): 602.................................................................................................. 1.16 YZ-002B2 (VALVE PLATE 2POUT ASSY): 603.................................................................................................. 1.17 YZ-002B3 (VALVE PLATE 4PIN ASSY): 604...................................................................................................... 1.18 YZ-002B4 (VALVE PLATE 2P45IN ASSY): 605.................................................................................................. 1.19 YZ-002B5 (VALVE PLATE 4POUT ASSY): 606.................................................................................................. 1.20 YZ-002B6 (VALVE PLATE 3POUT ASSY): 607.................................................................................................. 1.21 Flow Cell Adjusting Fixture................................................................................................................................. 1.22 MP-640V Pump Unit........................................................................................................................................... 1.23 MP-730V Mixed Pump Unit................................................................................................................................ 1.24 MP-731V Triple Pump Unit................................................................................................................................. 1.25 MS-730V Sampler Unit....................................................................................................................................... 1.26 MS-731V Cap Pierce Unit.................................................................................................................................. 1.28 JQ-731V/JQ-732V Valve Unit............................................................................................................................. 1.29 JQ-730V Inlet/Outlet Unit.................................................................................................................................... 1.30 YZ-003B1 (VALVE PLATE 3PIN ASSY): 712...................................................................................................... 1.32 Power Supply Unit.............................................................................................................................................. 1.33 PV-730VK Front Panel Unit................................................................................................................................ 1.34 WA-730VK Printer.............................................................................................................................................. 1.36
Technical Reference Manual MEK-7300K
1.1
1
1. REPLACEABLE PARTS LIST When ordering parts or accessories from your nearest Nihon Kohden Corporation representative, please quote the NK code number and part name which are listed in this service manual, and the name or model of the unit in which the required part is located. This will help us to promptly attend to your needs. Always use Nihon Kohden parts and accessories to assure maximum performance from your instrument. Rank A B C D
1.2
Requires replacement within about 1 to 3 months. Requires replacement within about 6 to 12 months. Requires replacement when this component has deterioration or damage. Requires replacement which must be done by service personnel trained in Nihon Kohden or by representative.
Technical Reference Manual MEK-7300K
1. REPLACEABLE PARTS LIST
1
Composition MEK-7300K
UT-7241
MAIN BD
UT-7242
POWER BD
UT-7243
DRIVER BD
UT-7244
ANALOG BD
UT-7238
VALVE CONNECTION BD1
UT-7240
VALVE CONNECTION BD3
MC-730V
CBC Measuring Unit
MJ-730V
Technical Reference Manual MEK-7300K
UT-7201
HGB AMP BD
UT-7202
HGB LED BD
UT-7249
MEASURING BD (RBC)
UT-7249
MEASURING BD (WBC)
UT-7250
CONNECTION BD
XP-602V
2-way Valve (× 2)
XP-612V
2-way Valve (× 7)
Flow Cytometry Piping Unit XP-513V
3-way Valve
XP-612V
2-way Valve (× 21)
1.3
1. REPLACEABLE PARTS LIST
MO-820V2
LASER OPTICAL UNIT
MF-820V2
FLOWCELL UNIT
UT-7172
MO PREAMP BD UT-7173
MO FS PREAMP BD
UT-7174
MO FL PREAMP BD
UT-7175
MO SD PREAMP BD
UT-7176 MP-640V
Pump Unit
MP-640V
Pump Unit
MP-730V
Mixed Pump Unit
MP-731V
MS-730V
1.4
MO LD DRIVER BD
UT-7200
MIXED PUMP BD
XP-513V
3-way Valve
Triple Pump Unit UT-7239
VALVE CONNECTION BD2
XP-503V
3-way Valve (× 2)
Sampler Unit UT-7234
SAMPLER JUNCTION BD
UT-7235
SAMPLER SENSOR BD
MS-731V
Cap Pierce Unit
JQ-730V
Inlet/Outlet Unit UT-7236
LIQUID SENSOR BD
XP-612V
2-way Valve (× 4)
Technical Reference Manual MEK-7300K
1. REPLACEABLE PARTS LIST
JQ-731V
1
Valve Unit XP-612V
JQ-732V
2-way Valve
Valve Unit XP-612V
PV-730VK
2-way Valve (× 2)
Front Panel Unit UT-7246
LCD BD
UT-7247
KEY BD
UT-7248
PRINT KEY BD
WA-730VK UT-7205
Technical Reference Manual MEK-7300K
PRINTER DRIVER BD
1.5
1. REPLACEABLE PARTS LIST
Units and Boards Units Rank C C C C C D C C C C C C C C
Index 100 200 300 400 500 600 700 800 900 1000 1200 1300 1400 1500
Model MC-730V MS-730V MS-731V MP-730V MP-731V MJ-730V JQ-730V PV-730VK WA-730VK MO-820V2 — MP-640V JQ-731V JQ-732V
Qty 1 1 1 1 1 1 1 1 1 1 1 2 1 1
Description CBC measuring unit Sampler unit Cap pierce unit Mixed pump unit Triple pump unit Flow cytometry piping unit Inlet/Outlet unit Front panel unit Internal printer Laser optical unit Power supply unit Rotary pump unit Valve unit Cap pierce valve unit 1000
800
700
200
500
100
400 900
600
1400 300
1.6
1500
1300
1300
Technical Reference Manual MEK-7300K
1. REPLACEABLE PARTS LIST
CHASSIS
37
38
100
800
900
1400
300
200
1500
1300
1000
1300
1100
600
700
500
400
1200
1
Technical Reference Manual MEK-7300K
1.7
1. REPLACEABLE PARTS LIST
Boards Rank C C C C C C C C C C C C C C C C C C C
Index A G B C D E F L M N O P Q S R H I J K
Model UT-7238 UT-7239 UT-7240 UT-7241 UT-7242 UT-7243 UT-7244 UT-7249 UT-7250 UT-7201 UT-7202 UT-7234 UT-7235 UT-7200 UT-7236 UT-7246 UT-7247 UT-7248 UT-7205
Qty 1 1 1 1 1 1 1 2 1 1 1 1 1 1 1 1 1 1 1
Description VALVE CONNECTION BD1 VALVE CONNECTION BD2 VALVE CONNECTION BD3 MAIN BD†2 POWER BD DRIVER BD ANALOG BD MEASURING BD†1 CONNECTION BD†1 HGB AMP BD†1 HGB LED BD†1 SAMPLER JUNCTION BD SAMPLER SENSOR BD MIXED PUMP BD LIQUID SENSOR BD LCD BD KEY BD PRINTER KEY BD PRINTER DRIVER BD
Refer to “MC-730V CBC Measuring Unit”. UT-7241 battery: 619403 Use the part with the latest suffix except in special circumstances. †1
*
†2
*
F C
P
R
Q
D E G
H
I
J S K B
1.8
A
†2
∗
Battery: 619403
UT-7241
Technical Reference Manual MEK-7300K
1. REPLACEABLE PARTS LIST
F
B
C
E
A
D
R
1
Technical Reference Manual MEK-7300K
1.9
1. REPLACEABLE PARTS LIST
Chassis
Rank C C C C C C C C C C C C C C C D C C C C C C C C C C C C C C C C C C C C C C
Index 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38
Code No. 127925 6114-921051 6114-921042 6111-903754 6112-907739 6121-900337 6124-903907 6114-920783 344254 128514 6113-032014 533941 9000-005888 9000-005995 6113-916032 6141-900451 6114-919731 6114-919749 6113-915443 6113-915381 6114-920872 6114-920863 297821 553144 6114-906406 6114-906398 6113-032005 128185 533816 6113-915452 6114-920907 6114-920899 6114-923646 6114-923655 9000-012194 6114-924654 486047 676769
*
* * *
* * * *
* *
* * * * * * * *
* * * * * * * * * * * * *
* * * * * * *
Qty 1 1 1 1 1 1 1 1 3 2 1 4 2 10 1 1 1 1 1 1 1 2 1 4 4 4 1 1 24 1 4 5 1 1 1 1 1 2
Description Bolt Spacing UN18-2102-0006 (L10) PLATE MO BLIND PLATE (73) Cover (73) Side cover (73) Rear cover (73) Key Switch Label (M2) LOCK PLATE (73) Grommet G105 UN18-2102-0036 L=50 Single manifold Rubber feet TK-38 Slide rail BT200-L100 Grommet NG-79-P Holder (JQ-730V) Chassis ASSY (73) Sensor holder (73) Tube cover (73) SW Holder DILUTER SW (73) SHEET (VALVE CONNECTION1) SHEET (PUMP) Grommet rubber bush 15C O-ring P-3 (fluorocarbon rubber) Tube fitting nut Tube stopper Manifold (3P)1 Bolt Spacing UN18-2102-0015 L19 Grommet G-26 Slide plate (73) GASKET STGZ 10-10 L100 GASKET STGZ 5-5 L100 GASKET STGH 10-10 L240 GASKET STGZ 10-10 L400 109P0612H757 Fan guard (73) Micro SW V-10-3A5 Photo-interrupter KI-1234-AALF
* Use the part with the latest suffix except in special circumstances.
1.10
Technical Reference Manual MEK-7300K
Technical Reference Manual MEK-7300K
8
30
20
13
19
13
29
37
9
16
23
14
12
29
18
27
28
17
38
10
11
25
24
31
31
21
26
34
15
3
32
5 36
6
2
35
4
1
7
1. REPLACEABLE PARTS LIST
1
1.11
1. REPLACEABLE PARTS LIST
MC-730V CBC Measuring Unit
Rank C C D C C C C C C C C D C C C C C C C C C C C C C C B C C C C C A C D D C D C D C C
Index 101 102 103 104 105 106 107 108 109 110 111 112 113 114 115 116 117 118 119 120 121 122 123 124† 125† 126 127 128 129 130† 131 132 133 134 135 136 137 138 139 140 141 142
Model/Code No. YZ-002B9 6114-919099 6114-919152 YZ-001B8 YZ-001B0 YZ-0402 YZ-0287 6114-922683 6114-922692 6113-914925 YZ-0283 553242 6114-903989 2114-065847 2114-080812 6114-067438 676769 2114-050997 2114-051033 6114-067456 6114-067465 553144 315375 553233 556827 344254 2114-082062 2114-080171 6113-043305 9000-023093 6114-906398 6114-906406 6144-001899 (T802) 2114-073972 YZ-0412 YZ-0411 6113-914907 6113-914916 6112-907632 6114-919205 6114-919214 126481
* *
* * *
*
*
* * * * *
*
* * * * * * * *
* * * * * * * * * * * * *
Qty 1 2 3 2 2 1 2 2 3 1 2 2 1 1 1 3 2 13 10 7 3 13 1 2 2 2 2 1 1 2 13 13 2 2 7 2 1 1 1 4 4 4
Description MC TRAY ASSY MC Dripping Cover (73) Bath Block Fitting S-IN Bath ASSY (7300) Manometer ASSY HGB case ASSY Vacuum chamber assy Shield gasket STGZ10-10 (L=135) Shield gasket STGZ10-10 (L=20) MC Case (73) Sub bath assy (8222) Stepping motor SPG20-41868G036-309 Screw Rubber packing 1 Bath cap Filter joint (black) Photo interruptor KI1235-AALF Joint spring Joint collar.2 Tube joint.1 Tube joint.2 O-ring (fluorocarbon rubber) O-ring (red silicone rubber) O-ring (red silicone rubber) O-ring (fluorocarbon rubber) Grommet G106 Filter packing S Bath fitting collar Air trap Aperture (80) Tube stopper Tube fitting nut Filter ASSY (PP) Filter collar•A 2-way valve XP-612V 2-way valve XP-602V HGB Shield Case Sub bath holder MC front chassis MC bush MC collar M3 spacer TM-147 NO.1
* Use the part with the latest suffix except in special circumstances. YZ-0345 consists of 124, 125 and 130.
†
1.12
Technical Reference Manual MEK-7300K
Technical Reference Manual MEK-7300K
113
116
134
133
127
129
123
111
111
112
119
118
120
104
137
117
128
124
114
130
125
115
126
140
112
138
106
141
101
N
105
142
O
139
c
107
L
102
132
a
a
142
b
107
131
122
103
105
135
L
135
M
135
135
136
136
109
108
b
c
119
118
121
110
1. REPLACEABLE PARTS LIST
1
1.13
1. REPLACEABLE PARTS LIST
MJ-730V Flow Cytometry Piping Unit
Rank C C C C C C C C C C C C C C C C C C C C C D
No. 601 602 603 604 605 606 607 608 609 610 611 612 613 614 615 616 617 618 619 620 621 622
Model/Code No. YS-025B8 YZ-002B1 YZ-002B2 YZ-002B3 YZ-002B4 YZ-002B5 YZ-002B6 YZ-0416 YZ-001B2 YZ-001B9 YZ-002B7 YZ-0288 344254 321332 6113-027074 6114-122994 6114-123003 6114-123048 6114-906406 6114-906398 553144 YZ-0410
* *
*
* * * * * *
Qty 1 1 1 1 1 1 2 2 1 1 1 1 1 1 1 3 2 1 30 30 30 1
Description Waste chamber ASSY Valve plate 3P45INASSY Valve plate 2POUTASSY Valve plate 4PINASSY1 Valve plate 2P45INASSY Valve plate 4POUTASSY2 Valve plate 3POUTASSY Pinch valve Heater ASSY (7300) Mixing chamber ASSY Pressure chamber ASSY Air chamber ASSY Grommet G105 Grommet NG-79L Valve holder Tube joint ID1F Tube joint ID1 Tube joint ID05 Tube fitting nut Tube stopper O-ring P-3 (fluorocarbon rubber) 3-way valve XP-513V
* Use the part with the latest suffix except in special circumstances.
1.14
Technical Reference Manual MEK-7300K
601
Technical Reference Manual MEK-7300K
607
a
603
608
612
611
613
615
607
622
616
a
614
609
617
608
606
610
602
616
605
617
618
604 620 621
619
1. REPLACEABLE PARTS LIST
1
1.15
1. REPLACEABLE PARTS LIST
YZ-002B1 (VALVE PLATE 3P45IN ASSY): 602
Rank D D D D D D
No. 1 2 3 4 5 —
Model/Code No. 6113-915176 6114-919794 6113-915407 6113-915514 6114-923762 YZ-0412†
* * * * *
Qty 1 1 1 1 2 3
Description Valve plate 3P45 Valve block O-ring S-IN Valve block fitting T-IN Valve block O-ring T-IN Port O ring Ø 1.6 hardness 60 2-way valve XP-612V
* Use the part with the latest suffix except in special circumstances. YZ-0412 consists of XP-612V and cables.
†
1
3
4
2 5
5
YZ-0412
1.16
Technical Reference Manual MEK-7300K
1. REPLACEABLE PARTS LIST
1
YZ-002B2 (VALVE PLATE 2POUT ASSY): 603
Rank D D D D D
No. 1 2 3 4 —
Model/Code No. 6113-916023 6114-919847 6114-919811 6114-136462 YZ-0412†
* * * *
Qty 1 1 1 1 2
Description Valve plate 2P Valve block O-ring S-OUT Valve block fitting T-OUT Port O-ring (silicone SN6021) 2-way valve XP-612V
* Use the part with the latest suffix except in special circumstances. YZ-0412 consists of XP-612V and cables.
†
3 4 2 1
YZ-0412
Technical Reference Manual MEK-7300K
1.17
1. REPLACEABLE PARTS LIST
YZ-002B3 (VALVE PLATE 4PIN ASSY): 604
Rank D D D D D D D
No. 1 2 3 4 5 6 —
Model/Code No. 6113-915167 6114-919794 6113-915407 6113-915514 6114-136462 297919 YZ-0412†
*
* * * * *
Qty 1 1 1 2 3 1 4
Description Valve plate 4P Valve block O-ring S-IN Valve block fitting T-IN Valve block O-ring T-IN Port O-ring (silicone SN6021) Grommet rubber bush G99 2-way valve XP-612V
* Use the part with the latest suffix except in special circumstances. YZ-0412 consists of XP-612V and cables.
†
1
4
4
5
5
YZ-0412
6
1.18
3
2
5
Technical Reference Manual MEK-7300K
1. REPLACEABLE PARTS LIST
1
YZ-002B4 (VALVE PLATE 2P45IN ASSY): 605
Rank D D D D D
No. 1 2 3 4 —
Model/Code No. 6113-916888 6114-919794 6113-915407 6114-923762 YZ-0412†
* * * *
Qty 1 1 1 1 2
Description Valve plate 2P45 Valve block O-ring S-IN Valve block fitting T-IN Port O ring Ø 1.6 hardness 60 2-way valve XP-612V
* Use the part with the latest suffix except in special circumstances. YZ-0412 consists of XP-612V and cables.
†
1
2
3 4
YZ-0412
Technical Reference Manual MEK-7300K
1.19
1. REPLACEABLE PARTS LIST
YZ-002B5 (VALVE PLATE 4POUT ASSY): 606
Rank D D D D D D D
No. 1 2 3 4 5 6 —
Model/Code No. 6113-915167 6114-919847 6114-919811 6114-919838 6114-136462 297919 YZ-0412†
*
Qty 1 1 1 2 3 1 4
* * * * *
Description Valve plate 4P Valve block O-ring S-OUT Valve block fitting T-OUT Valve block O-ring T-OUT Port O-ring (silicone SN6021) Grommet rubber bush G99 2-way valve XP-612V
* Use the part with the latest suffix except in special circumstances. YZ-0412 consists of XP-612V and cables.
†
6
1
4
4
3 5
5 YZ-0412
2 5
1.20
Technical Reference Manual MEK-7300K
1. REPLACEABLE PARTS LIST
1
YZ-002B6 (VALVE PLATE 3POUT ASSY): 607
Rank D D D D D D D
No. 1 2 3 4 5 6 —
Model/Code No. 6113-915755 6114-919847 6114-919811 6114-919838 6114-136462 297919 YZ-0412†
*
* * * * *
Qty 1 1 1 1 2 1 3
Description Valve plate 3P Valve block O-ring S-OUT Valve block fitting T-OUT Valve block O-ring T-OUT Port O-ring (silicone SN6021) Grommet rubber bush G99 2-way valve XP-612V
* Use the part with the latest suffix except in special circumstances. YZ-0412 consists of XP-612V and cables.
†
1 4
3 5
5
YZ-0412
6
Technical Reference Manual MEK-7300K
2
1.21
1. REPLACEABLE PARTS LIST
Flow Cell Adjusting Fixture
Rank C C C C C
Index 1101 1102 1103 1104 1105
Code No. 553215 6114-923058 6114-919696 6114-919678 6114-919651
*
* * * *
Qty 1 1 1 1 1
Description O-ring P-15 (Silicon) Lock screw plate Scree holder O-ring holder Hex adaptor
* Use the part with the latest suffix except in special circumstances.
YZ-003B0
1100
1102 1103 1101 1104
1105
YZ-003B0 (MO unit) does not include a flow cell adjustment part. 1.22
Technical Reference Manual MEK-7300K
1. REPLACEABLE PARTS LIST
1
MP-640V Pump Unit
Rank C A
Index 1301 1302
Model YS-003B4 YS-001B1 (T462)
Qty 1 1
Description Rotor assy Pump tube (N) assy
1302 1301
Technical Reference Manual MEK-7300K
1.23
1. REPLACEABLE PARTS LIST
MP-730V Mixed Pump Unit
Rank C C C D D C D C C D C
Index 401 402 403 404 405 406 407 408 409 410 411
Model/Code No. YZ-001B1 YZ-001B4 6114-920997 686954 6113-027074 6114-906398 487296 553144 6114-906406 YZ-0410 676769
* * *
Qty 1 1 1 2 1 3 2 3 3 1 2
* * * *
*
Description Sheath cylinder assy (7300) Diluter cylinder assy (7300) DRIP PROOF SHEET (MP-730V) Stepping motor Valve holder Tube stopper Universal coupling O-ring (fluorocarbon rubber) Tube fitting nut 3-way valve XP-513V Photosensor KI1234-AALF
* Use the part with the latest suffix except in special circumstances.
405 404 401
404 407
410
409 406 408 411
407
402
S 403
1.24
Technical Reference Manual MEK-7300K
1. REPLACEABLE PARTS LIST
1
MP-731V Triple Pump Unit
Rank C C D C D C C C C C C C
Index 501 502 503 504 505 506 507 508 509 510 37† 38†
Model/Code No. YZ-001B5 6114-921015 693171 6113-027074 686954 6114-906406 6114-906398 553144 YZ-0410 676769 6114-925154 6114-925163
* * * *
* * * * * *
Qty 3 1 2 2 2 3 3 3 2 4 1 1
Description Cylinder assy DRIP PROOF SHEET (MP-731V) PK Coupling PK60M-29 A3B5 Valve holder Stepping motor Tube fitting nut Tube stopper O-ring (fluorocarbon rubber) 3-way valve XP-513V Photosensor KI1234-AALF TRAY (MP-731V) Absorber Sheet
* Use the part with the latest suffix except in special circumstances. 37 and 38 are the parts of chassis, not of unit.
†
505 505
503 503
509 504
510
506 507
508
510 510
G
502
510 38
37
Technical Reference Manual MEK-7300K
501
1.25
1. REPLACEABLE PARTS LIST
MS-730V Sampler Unit
Rank C C D C C C C C C C C C B C A C C C
Index 201 202 203 204 205 206 207 208 209 210 211 212 213 214 215 216 217 218
Model/Code No. 6114-919339 6114-926304 YK-00016 297821 6114-914451 6114-122994 6114-914469 686963 6144-900124 6114-902606 688212 YZ-0354 2114-082062 2114-050997 6144-001899 (T802) 904087 9000-005914 2114-073972
* *
* * *
*
* * *
* * * * * * *
Qty 1 1 1 1 1 1 1 2 2 2 2 1 1 1 1 1 2 1
Description Sample tube guide (73) Sample cup (filter) 73 MS-730V tube ASSY Grommet rubber bush 15C Filter joint (82) Tube joint ID1F Screw (82) KH42KM2R082 Sample tube ASSY Sampling nozzle fastening screw Shaft coupling Rinse unit assy for open mode Filter packing S Joint spring Filter ASSY (PP) SML2CD-28X190-BDX10BL-P1.25-S5 Flat clamp FCR-45 V0 Filter collar
* Use the part with the latest suffix except in special circumstances.
1.26
Technical Reference Manual MEK-7300K
210
Technical Reference Manual MEK-7300K
209
209
210
203
201
205
214
215
207
202
218
206
213
Q
208
208
211
217
211
216
212
P 204
1. REPLACEABLE PARTS LIST
1
1.27
1. REPLACEABLE PARTS LIST
MS-731V Cap Pierce Unit
Rank D C C C A B C C C D D C C
Index 301 302 303 304 305 306 307 308 309 310 311 312 313
Model/Code No. YZ-002B0 6114-906905 YZ-0342 YZ-0365 6144-001899 (T802) 2114-082062 6114-920061 YZ-001B3 676769 686963 517086 9000-000893 9000-005834
*
* * *
* * *
* *
Qty 1 1 1 1 1 1 1 1 2 1 1 2 1
Description Cap pierce base ASSY (7300) Filter manifold Cap pierce needle assy Rinse unit assy for closed mode Filter ASSY (PP) Filter packing S Protect seat Open solenoid (7300) Photo-interrupter KI-1234-AALF Stepping motor Shaft coupling Photo-interrupter LG217L-3 COMPONENT CLIP V-1005
* Use the part with the latest suffix except in special circumstances.
312
303
312 313 302
311
306 305 304 310 309 309
a
a
301
307 308
1.28
Technical Reference Manual MEK-7300K
1. REPLACEABLE PARTS LIST
1
JQ-731V/JQ-732V Valve Unit
Rank C C
Index 1401 1501
Model JQ-731V JQ-732V
Qty 1 1
Description Valve unit Valve unit
1401
1501
Technical Reference Manual MEK-7300K
1.29
1. REPLACEABLE PARTS LIST
JQ-730V Inlet/Outlet Unit
*
Rank C C C D D C D C C C D C C C C C C C
No. 701 702 703 704 705 706 707 708 709 710 711 712 713 714 715 716 717 718
Model/Code No. 6124-041643 6113-034476 6124-905861 6143-901838 6113-915318 6113-915327 6114-919152 6114-906398 6114-906406 553144 6114-920578 YZ-003B1 6114-920587 6114-919571 127907 127934 344254 2114-051042
*
* * *
* * * * * * * * * * * * *
Qty 1 4 1 1 1 1 1 11 11 11 1 1 1 1 1 1 1 1
Description EMERGENCY SW Label Bubble detector (6300) MEK-7300 Port label Chassis ASSY (JQ-730V) JQ-730V Chassis3 Port Panel (73) Valve block fitting S-IN Tube stopper Tube fitting nut O-ring P-3 (fluorocarbon rubber) JQ Joint Valve plate 3PINASSY JQ Manifold Laser SW blanket Spacer UN18-2102-0008 L12 Spacer UN18-2102-0014 L18 Grommet G105 Joint.5 nut
Use the part with the latest suffix except in special circumstances.
1.30
Technical Reference Manual MEK-7300K
1. REPLACEABLE PARTS LIST
1 R
702 710 708 709 712 714 707 705 716
710
715
717 713
711
704
706
b a
701
718
703
Technical Reference Manual MEK-7300K
1.31
1. REPLACEABLE PARTS LIST
YZ-003B1 (VALVE PLATE 3PIN ASSY): 712
Rank D D D D D D
No. 1 2 3 4 5 —
Model/Code No. 6113-915755 6114-919794 6113-915407 6113-915514 6114-136462 YZ-0412†
* * * * *
Qty 1 1 1 1 2 3
Description Valve plate 3P Valve block O-ring S-IN Valve block fitting T-IN Valve block O-ring T-IN Port O-ring (silicone SN6021) 2-way valve XP-612V
* Use the part with the latest suffix except in special circumstances. YZ-0412 consists of XP-612V and cables.
†
2 4 3 5 5 1
YZ-0412
1.32
Technical Reference Manual MEK-7300K
1. REPLACEABLE PARTS LIST
1
Power Supply Unit
Rank C C C C C C C
Index 1201 1202 1203 1204 1205 1206 1207
Code No. 2124-009676 2224-001102 6142-901457 6113-915924 6144-005993 936836 313635
* *
* * * * *
Qty 1 1 1 1 1 1 1
Description Function earth nameplate EARTH nameplate SC chassis Plate (SC) Equipotential terminal LEP240F-24 Power entry module FN284-4-06
1203 D
1207 1205
1202 1201 1204 1206
Technical Reference Manual MEK-7300K
1.33
1. REPLACEABLE PARTS LIST
PV-730VK Front Panel Unit
Rank C C C D D D C D D C C C D D D D D D C D D D D D D D C
Index a e f 801 802 803 805 806 807 808 809 810 812 813 814 815 816 817 818 819 820 821 822 823 824 825 830
Code No. 932689 938834 932671 639088 6122-901183 6141-900469 6113-915488 6113-916941 6113-915461 6113-915996 6113-915987 6114-920845 6114-911908 6114-911882 6114-094266 6114-911891 6112-904475 297821 693153 6114-920916 6114-920934 6114-920925 6114-920943 905995 914218 913959 6112-907855
* * * *
* *
* * *
* * * * * * * * * * * * * * * * * *
Qty 1 1 1 2 1 1 1 1 1 1 1 1 1 1 1 4 1 2 2 2 1 2 2 1 1 1 1
Description PHR-7/51021-0700 (W110) Red LY10-DC22/DC14/DC8 (W130/270) DF19G-20S-1C (W170) Flat hinge TH-TM-112 FRONTCASE Printing (73) PV Chassis ASSY Inverter cover LCD Plate Front bracket (73) SHEET (PV-BOTTOM) SHEET (PV-BD) ISOLATION SHEET (INVERTER73) Round key top cover (ivory, large) Oval key top cover (ivory) Round key top cover (orange, small) Round key top cover (ivory, small) Touch panel washer Grommet rubber bush 15C Flat cable tie GASKET STGZ 7-10 L180 GASKET STGZ 3-5 L180 GASKET STGZ 7-7 L60 GASKET STGZ 3-5 L35 LTA104D182F Touch panel N010-0554-T347A CXA-0454 BLIND PANEL (73)
* Use the part with the latest suffix except in special circumstances.
1.34
Technical Reference Manual MEK-7300K
830
802
807
Technical Reference Manual MEK-7300K
812
806
821
816
815
J
813
815
814
824
823
801
817
819
817
803
820
805
I
H
808
822
810
825
f
e
a
818
809
1. REPLACEABLE PARTS LIST
1
1.35
1. REPLACEABLE PARTS LIST
WA-730VK Printer
Rank D C D D C C C
Index 804 811 826 827 828 829 K
Model/Code No. 6112-907873 6124-906316 6113-901449 6113-900985 483273 301488 UT-7205
* *
* * * *
Qty 1 1 1 1 1 2 1
Description PRINTER DOOR (73) WA-730V Printer label Printer case Printer holder Thermal array printer head Magnet R28E PRINTER DRIVER board
* Use the part with the latest suffix except in special circumstances.
1.36
Technical Reference Manual MEK-7300K
Section 2 Cable Wiring and Tube List Cable Wiring......................................................................................................................................................... 2.2 SOCKET HOUSING............................................................................................................................................. 2.9 Tube List............................................................................................................................................................. 2.10 Hydraulic System Diagram................................................................................................................................. 2.11 Block Diagram.................................................................................................................................................... 2.12
Technical Reference Manual MEK-7300K
2.1
2
2. CABLE WIRING AND TUBE LIST
Cable Wiring Rank No. Code No. C a 932724 C b 932403 C c 932555 C d 938638 C e 932501 C f 932377 C g 932493 C h 938647 C i 932528 C j 932537 C k 938656 C l 938665 C m 938674 C n 938683 C o 9000009803 C p 938709 C q 932448 C r 932733 C s 938718 C t 938727 C u 938736 C v 932457 C w 932368 C x 938843 C y 910641 C z 938897 C aa 938745 C ab 938807 C ac 932626 C 1a 938763
* * * * * * * * * * * * * * * * * * * * * * * * * * * * * *
Connection (Connector) [CN0501] - [CN1401] [CN0503] - [CN0103] [CN0505] - [CN0001] [CN1501] - [CN0101] [CN1502] - [CN0102] [CN1503] - [CN0104] [CN1301] - [CN0301] [CN1302] - [CN0202] [CN1401] - [CN0201] [CN1201] - [CN106] [CN0401] - [CN102] [CN0402] - [CN105] [CN1701] - [CN0102] [CN1601] - [CN0104] [CN1602] - [CN0102] [CN1603] - [CN0103] [CN1605] - [CN0101] [CN2502] - [CN0111] [CN2101] - [CN0104] [CN2502] - [CN0105] [CN2504] - [CN0201] [CN2503] - [CN0301] [CN0506] - [CN0101] [CN0902] - [CN100] [CN0107] - Switch [CN0504] - [CN0101] [CN1102] - [CN011] [CN0901] - Junction connector [CN2301] - Motor×2 [CN103] - [CN100] [CN104] [CN107] - [CN100] [CN108] [CN400] - [CN051] - [CN302] [CN300] - Electrode Junction-Motor
*
1
*
1
*
2 2
XHP-3/V0.5-2/-4 (W45) Red-Black Sub bath cable (MEK-7300) (W100)
1
PUDP-16V/PHR-11/ZHR-3/Green
DRIVER BD-Sheath pump motor
* *
1 1
PUDP-10V-S/PHR-11(W220)SP PUDP-14V/PHR-11/ZHR-3/Purple
DRIVER BD-MD Motor DRIVER BD-LYSE Pump motor
*
1
PUDP-18V/PHR-11/ZHR-3 Blue
DRIVER BD-Sample pump motor
*
1
Cap pierce cable (MEK-7300)
VALVE CONNECTION BD1-Cap pierce
* *
1 1
PHR-7/51021-0700 (W110) Red LY10-DC22/DC14/DC8 (W130/270)
* * *
1 1 1
LCD BD-Inverter LCD BD-KEY BD LCD BD-PRINT KEY BD DF19G-20S-1C (W170)-Tube LCD BD-LCD LY10-DC16 (W390) Brown MAIN BD-PRINTER BD VHR-5/SFO-61T-250A (W70/80/150) AC Inlet-Switching Power supply
12b 938932
*
1
VHR-8N (W120) Black-Red
POWER BD-Switching Power supply
12c 9000003275 7a 9000012247
1
V1.25-4/SFO-61T-250A (W70)
AC Inlet-Chassis
[CN1501] - Motor - Sensor×2 [CN1101] - Motor [CN1001] - Motor - Sensor×2 [CN1301] - Motor - Sensor×2 [CN0101] - Motor - Sensor×4 - Solenoid [CN0203] - Inverter [CN0201] - [CN0301] - [CN0401] [CN0105] - LCD [CN1604] - [CN011] AC Inlet-Switching Power supply [CN1] [CN0101] - Switching Power supply [CN2] AC Inlet-Chassis
1
ELR-02V/171822-3 (W610)
FAN junction-POWER BD
FAN junction - [CN0502]
938772
C
1c
938781
C C
1d 1e
C
4a
938941 9000003266 938914
C C
4b 5a
932582 938905
C
5b
932644
C
3a
938888
C C
8a 8b
932689 938834
C C C
8c 932671 8d 938754 12a 938923
C C
2.2
Connection (Cable ends) POWER BD-MAIN BD POWER BD-DRIVER BD POWER BD-ANALOG BD MAIN BD-DRIVER BD MAIN BD-DRIVER BD MAIN BD-DRIVER BD MAIN BD-ANALOG BD MAIN BD-ANALOG BD MAIN BD-ANALOG BD MAIN BD-CONNECTION BD ANALOG BD-MC (CONNECTION BD) ANALOG BD-MC (CONNECTION BD) MAIN BD-LIQUID SENSOR BD MAIN BD-LCD BD MAIN BD-LCD BD MAIN BD-LCD BD MAIN BD-SAMPLER JUNCTION BD DRIVER BD-VALVE CONNECTION BD1 DRIVER BD-VALVE CONNECTION BD1 DRIVER BD-VALVE CONNECTION BD1 DRIVER BD-VALVE CONNECTION BD2 DRIVER BD-VALVE CONNECTION BD3 POWER BD-LCD BD DRIVER BD-MC (CONNECTION BD) VALVE CONNECTION BD1-Switch POWER BD-LIQUID SENSOR BD DRIVER BD-MIXED PUMP BD DRIVER BD-Sub Bath junction connector DRIVER BD-Sampler motor CONNECTION BD-MEASURING BD (RBC) CONNECTION BD-MEASURING BD (WBC) CONNECTION BD-HGB AMP BD -HGB LED BD MEASURING BD-MC Electrode Sub bath junction connector Sub bath motor
1b
* *
* *
1 1 1 1 1 1 1 1 1 1 1 1 1 1 1
Cable model or description PUDP-34V-S (W400) PUDP-32V-S (W200) Red PUDP-30V-S (W160) Orange LY10-DC14 (W150) Twist pair PUDP-22V-S (W180) PUDP-20V-S (W180) PUDP-28V-S (W50) PUDP-36V-S (W120) LY10-DC28 (W70) Green-White PUDP-32V-S (W340) Purple PUDP-08V-S (W550) White VHR-10N (W640) Red LY10-DC14 (W340) Blue LY10-DC8 (W460) Twist pair LY10-DC10BR (W550/600)-Tube LY10-DC20 (W420) Brown-White LY10-DC16 (W440) Yellow-White LY10-DC22 (W310) Blue-White LY10-DC20 (W390) Purple-White LY10-DC32 (W440) Gray-White LY10-DC44 (W240) Orange-White LY10-DC12 (W230) Brown-White PUDP-16V-S (W700) LY10-DC22 (W320) Red-White 171822-2/PS-187 (W190) Blue PUDP-14V-S (W220) Green LY10-DC18 (W200) Green-White LY10-DC18/51090-0900 (W470/300) PUDP-12V-S/PHR-11 (W330) SP LY10-DC38/24/DF11-16DS (W140) Red LY10-DC38/24/DF11-16DS (W140) White HGB BD Cable (MEK-7300) (W160)
C
C
Qty 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1
Technical Reference Manual MEK-7300K
2. CABLE WIRING AND TUBE LIST
t e
f
d
ab
v
e
f d
n
j p
h
i
g
q
k
h
o
m
g
8d
i
ab
y
a
c
l
b
v
ab
x
ac
s
r
4a
aa
4b
r
s
t
5a
5b
u
y
2
Technical Reference Manual MEK-7300K
2.3
2. CABLE WIRING AND TUBE LIST NO.
a
UT-7242 (POWER BD)
【CN0501】 34 pin
NO.
b
c
d
NO.
e
f
g
h
i
j
2.4
Code no.: 938638 Name: LY10-DC14 (W150) twist pair Color: multicolor
【CN0101】 14 pin
UT-7243 (DRIVER BD)
Code no.: 932501 Name: PUDP-22V-S (W180)
【CN0102】 22 pin
Color: black UT-7243 (DRIVER BD)
Code no.: 932377 Name: PUDP-20V-S (W180) Color: white
【CN0104】 20 pin
UT-7244 (ANALOG BD)
Code no.: 932493 Name: PUDP-28V-S (W50)
【CN0301】 28 pin
Color: yellow UT-7244 (ANALOG BD)
Code no.: 938647 Name: PUDP-36V-S (W120) Color: green
【CN0202】 36 pin
UT-7244 (ANALOG BD)
Code no.: 932528 Name: LY10-DC28 (W70) green and white Color: green and white
UT-7241 (MAIN BD)
【CN1201】 32 pin
【CN0001】 30 pin
UT-7243 (DRIVER BD)
UT-7241 (MAIN BD)
【CN1402】 28 pin
NO.
Code no.: 932555 Name: PUDP-30V-S (W160) orange Color: orange
UT-7241 (MAIN BD)
【CN1302】 36 pin
NO.
UT-7244 (ANALOG BD)
UT-7241 (MAIN BD)
【CN1301】 28 pin
NO.
Color: red
UT-7241 (MAIN BD)
【CN1503】 20 pin
NO.
【CN0103】 32 pin
UT-7241 (MAIN BD)
【CN1502】 22 pin
NO.
Code no.: 932403 Name: PUDP-32V-S (W200) red
UT-7241 (MAIN BD)
【CN1501】 14 pin
【CN1401】 34 pin
UT-7243 (DRIVER BD)
UT-7242 (POWER BD)
【CN0505】 30 pin
NO.
Code no.: 932724 Name: PUDP-34V-S (W400) Color: brown
UT-7242 (POWER BD)
【CN0503】 32 pin
NO.
UT-7241 (MAIN BD)
【CN0201】 28 pin
UT-7250 (CONNECTION
Code no.: 932537 Name: PUDP-32V-S (W340) purple Color: purple
BD)
【CN106】 32 pin
Technical Reference Manual MEK-7300K
2. CABLE WIRING AND TUBE LIST NO.
k
UT-7244 (ANALOG BD)
【CN0401】 8 pin
NO.
l
m
n
o
NO.
p
NO.
q
r
s
NO.
t
Code no.: 938683 Name: LY10-DC8 (W460) twist pair Color: black, brown, red, orange and white
Code no.: 9000-009803 Name: LY10-DC10BR (W550/600) with tube Color: black and white
Technical Reference Manual MEK-7300K
【CN0102】 10 pin
UT-7246 (LCD BD)
Code no.: 938709 Name: LY10-DC20 (W420) brown and white Color: brown and white
【CN0103】 20 pin
UT-7234 (SAMPLER JUNCTION BD)
Code no.: 932448 Name: LY10-DC16 (W440) yellow and white Color: yellow and white
【CN0101】 16 pin
UT-7238 (VALVE CONNECTION BD1)
Code no.: 932733 Name: LY10-DC22 (W310) blue and white Color: blue and white
【CN0111】 22 pin
UT-7238 (VALVE CONNECTION BD1)
Code no.: 938718 Name: LY10-DC20 (W390) purple and white Color: purple and white
UT-7243 (DRIVER BD)
【CN2502】 32 pin
【CN0104】 8 pin
UT-7246 (LCD BD)
UT-7243 (DRIVER BD)
【CN2101】 20 pin
【CN0102】 14 pin
UT-7246 (LCD BD)
UT-7243 (DRIVER BD)
【CN2505】 22 pin
NO.
Code no.: 938674 Name: LY10-DC14 (W340) blue Color: blue
UT-7241 (MAIN BD)
【CN1605】 16 pin
NO.
UT-7236 (LIQUID SENSOR BD)
UT-7241 (MAIN BD)
【CN1603】 20 pin
BD)
Color: red
UT-7241 (MAIN BD)
【CN1602】 10 pin
2
【CN105】 10 pin
UT-7241 (MAIN BD)
【CN1601】 8 pin
NO.
Code no.: 938665 Name: VHR-10N (W640) red
BD)
【CN102】 8 pin
UT-7250 (CONNECTION
UT-7241 (MAIN BD)
【CN1701】 14 pin
NO.
Code no.: 938656 Name: PUDP-08V-S (W550) white Color: white
UT-7244 (ANALOG BD)
【CN0402】 10 pin
NO.
UT-7250 (CONNECTION
【CN0104】 20 pin
UT-7238 (VALVE CONNECTION BD1)
Code no.: 938727 Name: LY10-DC32 (W440) gray and white Color: gray and white
【CN0105】 32 pin
2.5
2. CABLE WIRING AND TUBE LIST NO.
u
UT-7243 (DRIVER BD)
【CN2504】 44 pin
NO.
v
w
x
y
z
aa
ab
ac
1a
Code no.: 938897 Name: PUDP-14V-S (W220) green Color: green
【CN100】 22 pin
Measurement switch
【CN0101】 14 pin
UT-7200 (MIXED PUMP
Code no.: 938745 Name: LY10-DC18 (W200) green and white Color: green and white
UT-7243 (DRIVER BD)
BD)
【CN011】 18 pin
Sub bath Connection Connector 9 pin WBC
Code no.: 938807 Name: LY10-DC18/51090-0900 (W470/300) Color: red and white
Sub bath Connection Connector 9 pin RBC
UT-7243 (DRIVER BD)
UT-7250 (CONNECTION
Code no.: 932626 Name: PUDP-12V-S/PHR-11(W330) Color: blue and green
【CN104】 16 pin
Sampler motor Sampler motor
UT-7249 (MEASURING
BD)
【CN103】 24 pin
2.6
Code no.: 910641 Name: XHP-2/PS-187 (W190) blue Color: blue
UT-7243 (DRIVER BD)
【CN2301】 12 pin
NO.
Code no.: 938843 Name: LY10-DC22 (W320) red and white Color: red and white
BD)
UT-7236 (LIQUID SENSOR BD)
【CN0901】 18 pin
NO.
【CN0101】 16 pin
UT-7250 (CONNECTION
UT-7242 (POWER BD)
【CN1102】 18 pin
NO.
【CN0301】 12 pin
UT-7238 (VALVE CONNECTION BD1)
【CN0504】 14 pin
NO.
Code no.: 932368 Name: PUDP-16V-S (W700) Color: yellow
UT-7243 (DRIVER BD)
【CN0107】 2 pin
NO.
Code no.: 932457 Name: LY10-DC12 (W230) brown and white Color: brown and white
UT-7246 (LCD BD)
【CN0902】 22 pin
NO.
【CN0201】 44 pin
UT-7240 (VALVE CONNECTION BD3)
UT-7242 (POWER BD)
【CN0506】 16 pin
NO.
Code no.: 938736 Name: LY10-DC44 (W240) orange and white Color: orange and white
UT-7243 (DRIVER BD)
【CN2503】 12 pin
NO.
UT-7239 (VALVE CONNECTION BD2)
Code no.: 938763 Name: LY10-DC38/24/DF11-16DS (W140) red Color: red
BD)
【CN100】 38 pin
Technical Reference Manual MEK-7300K
2. CABLE WIRING AND TUBE LIST NO.
1b
UT-7250 (CONNECTION
【CN107】 24 pin 【CN108】 16 pin
NO.
1c
UT-7250 (CONNECTION
UT-7249 (MEASURING
BD)
Code no.: 938772 Name: LY10-DC38/24/DF11-16DS (W140) white Color: white
BD)
2
【CN100】 38 pin
UT-7201 HGB AMP BD
BD)
【CN051】
4 pin
【CN400】 12 pin
NO.
1d
UT-7249 (MEASURING
4a
4b
5a
5b
Code no.: 9000-003266 Name: Sub bath cable (MEK-7300) (W100) Color: black
Sub bath motor 6 pin 3 pin
Sensor
Code no.: 938914 Name: PUDP-16V/PHR-11/ZHR-3/green Color: green, black and brown
Motor of sheath 11 pin Sensor 3 pin Sensor 3 pin
Code no.: 932582 Name: PUDP-10V-S/PHR-11 (W280) Color: yellow
MD motor 11 pin
UT-7243 (DRIVER BD)
【CN1001】 14 pin
NO.
MC electrode
UT-7243 (DRIVER BD)
【CN1101】 10 pin
NO.
Code no.: 938941 Name: XHP-3/V0.5-2/-4 (W45) red and black Color: red, white and black
UT-7243 (DRIVER BD)
【CN1501】 16 pin
NO.
【CN302】
5 pin
1e
Sub bath connection connector
NO.
UT-7202 HGB LED BD
BD)
【CN300】 3 pin
NO.
Code no.: 938781 Name: HGB BD cable (MEK-7300) (W160) Color: black
Code no.: 938905 Name: PUDP-14V/PHR-11/ZHR-3/purple Color: purple, black and brown
LYSE motor 11 pin Sensor Sensor
3 pin 3 pin
UT-7243 (DRIVER BD) Sample pump motor
【CN1301】 14 pin
NO.
3a
UT-7238 (VALVE CONNECTION BD1) 【CN0101】 20 pin
NO.
8a
Code no.: 932644 Name: PUDP-18V/PHR-11/ZHR-3 blue Color: blue, black and brown
Code no.: 938888 Name: Cap pierce cable (MEK-7300) Color: white, black, brown, red and orange
11 pin
Sensor Sensor
3 pin 3 pin
CAP pierce unit motor 11 pin Sensor 3 pin Sensor 3 pin Sensor 3 pin Sensor 3 pin Solenoid 2 pin
UT-7246 (LCD BD)
【CN0203】 7 pin
Technical Reference Manual MEK-7300K
Code no.: 932689 Name: PHR-7/51021-0700 (W110) red
Inverter
Color: red
2.7
2. CABLE WIRING AND TUBE LIST NO.
8b
UT-7246 (LCD BD)
UT-7247 (KEY BD) 【CN0301】
14 pin
【CN0201】 22 pin
NO.
8c
8d
12b
UT-7205 (PRINTER DRIVER BD)
Code no.: 938754 Name: LY10-DC16 (W390) brown Color: brown
Code no.: 938923 Name: VHR-5/SFO-61T-250A (W70/80/150) Color: blue, brown and green
【CN011】 16 pin
SW power source 【CN1】 5 pin
Code no.: 938932 Name: VHR-8N (W120) black and red Color: red and black
SW power source 【CN2】 8 pin
Code no.: 9000-003275 Name: V1.25-4/SFO-61T-250A (W70) Color: green and yellow
Chassis
7a
UT-7242 (POWER BD)
FAN connection connector
2.8
LCD
12c
AC inlet
NO.
20 pin
UT-7242 (POWER BD)
【CN0101】 8 pin
NO.
8 pin
12a
AC inlet
NO.
Code no.: 932671 Name: DF19G-20S-1C (W170) with tube Color: white
UT-7241 (MAIN BD)
【CN1604】 16 pin
NO.
UT-7248 (PRINTER KEY BD) 【CN0401】
UT-7246 (LCD BD)
【CN0105】 20 pin
NO.
Code no.: 938834 Name: LY10-DC22/DC14/DC8 (W130/270) Color: white
Code no.: 9000-012247 Name: ELR-02V/XHP-3 (W610) Color: black and red
【CN0502】 3 pin
Technical Reference Manual MEK-7300K
2. CABLE WIRING AND TUBE LIST
SOCKET HOUSING 2 Rank D D D D D D
NK Code No. 670258 670267 670276 670285 670347 670356
* * * * * *
Pin 4 6 8 10 22 24
Description LY10-DC4BR LY10-DC6BR LY10-DC8BR LY10-DC10BR LY10-DC22BR LY10-DC24BR
Remarks JQ-732V MC-730V JQ-730V/JQ-731V MC-730V MJ-730V MJ-730V
* Use the part with the latest suffix except in special circumstances.
LY-DC4BR
LY-DC6BR
LY-DC22BR
Technical Reference Manual MEK-7300K
LY-DC8BR
LY-DC10BR
LY-DC24BR
2.9
2. CABLE WIRING AND TUBE LIST
Tube List Units JQ-730V
MJ-730V
Tube No. 1 2 3 4 5 6 7 8 9 10 11 12 13 1 2 3 4 5 6 7 8 9 10 11 12 13
MJ-730V
Code No.
*
Tube Joints BF BO BO BF OO AB OO AB BB BB OO OO AO AB BO AO BO AO OO Pharmed
6114-094961
Pharmed
†
*
Tube Length (mm) 190 180 160 150 230 200 175 200 190 220 130 130 150 240 250 260 120 250 190 Φ0.51 × 0.9 L200 Φ1 × 3 L100
OO Pharmed
300 Φ1 × 3 L260
*
AO AO Pharmed
*
DO AO AO BO Pharmed
*
140 230 Φ1.6 × 3.2 L280 660 130 180 400 Φ1.6 × 3.2 L55 Φ1.6 × 3.2 L260 190 220 1870 210 110 400 70 410 260 340 240 275
YK-BF-190 YK-BO180 YK-BO160 YK-BF150 †
YK-AB200 †
YK-AB200 YK-BB190 YK-BB220 † †
YK-AO150 YK-AB240 YK-BO250 YK-AO260 YK-BO120 YK-AO250 †
6114-910758
*
6114-924208 YK-AO140 YK-AO230 6114-922781
14 15 16 17 18
YK-DO660 YK-AO130 YK-AO180 YK-BO400
19
6114-142027
Pharmed
20 21 22 23 24 25 26 27 28 29 30 31
†
OO BO AB AB OO OC OO AO BO AB AB OO
6114-922763
YK-BO220 YK-AB1870 YK-AB210 †
YK-00017 †
YK-AO410 YK-BO260 YK-AB340 YK-AB240 †
Units
Tube No. 1 2 3 4 1 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 1 2 3 4 5 1
Code No.
Tube Tube Length Joints (mm) MP-730V YK-CO090 CO 90 YKAO300 AO 300 YK-BC70 BC 70 YK-DO240 DO 240 JQ-731V YK-AO230 AO 230 † MC-730V OO 190 † OO 90 YK-AO080 AO 80 YK-BO120 BO 120 † OO 100 † OO 120 YK-AO140 AO 140 † OO 110 † OO 190 YK-AL320 AL 320 YK-KO210 KO 210 YK-AO140 AO 140 YK-KO90 KO 90 YK-BO180 BO 180 YK-BO240 BO 240 YK-AO140 AO 140 YK-AO170 AO 170 YK-AO200 AO 200 MP-731V YK-CO60 CO 60 YK-CO55 CO 55 YK-BC290 BC 290 YK-BC350 BC 350 YK-BO85 BO 85 MS-730V YK-00016 AC 1140 BD 1080 MS-731V 1 YK-AB130 AB 130 2 YK-AK240 AK 240 MEK-7300 1 YK-BO450 BO 450 2 YKBO390 BO 390 † 3 OO 500 4 YK-AA520 AA 520 5 YK-DH680 DH 680 6 YK-AB660 AB 660 7 YK-AB400 AB 400 8 YK-AB480 AB 480 9 YK-AA510 AA 510 10 YK-AA510 AA 510 11 YK-AO440 AO 440 † Place an order for NK Code no. YK-00015 and cut it into each suitable length. Note: Set the tube to a cutter. Then rotate the tube and get its cross-section flatly. Code No. YK-00015
2.10
Joints OO
Length (mm) 1000
Technical Reference Manual MEK-7300K
Technical Reference Manual MEK-7300K
8
MP-640V
1
5
1
6
2
Case
JQ-731V
13
Filter
R
MC-730V
OFF
ON
3
15
3 4
16 17 18
2
14
4
1
9
4
3
2
<2>
1
7
12
11
5
Filter
10
JQ-732V
6
7
MP-640V
5
8
9
W
6
<7>
Front
<1>
<11>
2
Filter
MS-731V 1
<5>
<6>
<4>
MS-730V
29
12
1st Dilution
2
31
18 19 20
13
<8>
<9>
<10>
Side
21 22 23
10
1
24
16
11
11
9
5
4
8
18
19
6
22
20
2
5
3
1
9
MO-820V
7 8
<3>
10
Manifold
Pressure Sensor
23
28
27
21
24 25
12 13
14 15 16 17
15
14
25 Thermistor
3 4
Warmer
2
1
MJ-730V
7
26
17
10
30
JQ-730V
1
1
3
2
9
6
MP-730V
4
8
1
1
3
2
2
3
2
1
4
13
12
11
5
4
7
MP-731V
ISO3 HEMO3N HEMO5
5
3
2
1
4
UT-7236
WASTE
Sensor:4
Sensor:3
HEMOLYNAC.5
HEMOLYNAC.3N
Sensor:1
CLEANAC CLEANAC.3
ISOTONAC.3
Sensor:2
2. CABLE WIRING AND TUBE LIST
Hydraulic System Diagram 2
2.11
2. CABLE WIRING AND TUBE LIST
Block Diagram
2.12
Technical Reference Manual MEK-7300K
Manufacturer
NIHON KOHDEN CORPORATION 1-31-4 Nishiochiai, Shinjuku-ku Tokyo 161-8560, Japan Phone +81 (3) 5996-8036 Fax +81 (3) 5996-8100
Sales USA
Asia
NIHON KOHDEN AMERICA, INC.
NIHON KOHDEN TRADING (SHANGHAI) CO., LTD
90 Icon Street, Foothill Ranch, CA 92610, USA Phone +1 (949) 580-1555 Fax +1 (949) 580-1550
Europe European Representative
NIHON KOHDEN EUROPE GmbH
7th Floor, Dawning Centre Tower A No.500 Hongbaoshi Road, Changning District Shanghai 201103, China Phone +86 (21) 6270-0909 Fax +86 (21) 6270-9700
Beijing Branch
Raiffeisenstrasse 10 D-61191 Rosbach v.d.H., Germany Phone +49 6003 827-0 Fax +49 6003 827-599
Room 1701, East Ocean Centre No. 24A JianGuoMenWai Street, Beijing, 100004 Phone 010-6515-5750 Fax 010-6515-5758
NIHON KOHDEN ITALIA S.r.l.
Room 2514, Yian Plaza No. 33 Jian She Liu Ma Road, Guangzhou, 510060 Phone 020-8363-3737 Fax 020-8363-3807
Guangzhou Branch Via Fratelli Bronzetti 28 I-24124 Bergamo, Italy Phone +39 035 219 543 Fax +39 035 232 546
NIHON KOHDEN SINGAPORE PTE LTD
8, rue Francois Delage, 94230 Cachan, France Phone +33 1 49 08 05 50 Fax +33 1 49 08 93 32
1 Maritime Square, #10-34 (Lobby C), Harbour Front Centre Singapore 099253 Phone +65 6376-2210 Fax +65 6376-2264
NIHON KOHDEN IBERICA S.L.
NIHON KOHDEN KOREA, INC.
NIHON KOHDEN FRANCE SARL
C/Ulises 75A E-28043 Madrid, Spain Phone +34 917 161 080 Fax +34 913 004 676
NIHON KOHDEN UK LTD Tolworth Tower, Ewell Road, Surbiton Surrey KT6 7EL, UK Phone +44 20-8390-8622 Fax +44 20-8390-4675
Hannam Tower Annex Bldg. Suite 203 730 Hannam-dong, Yongsan-gu, Seoul, Korea 141-210 Phone +82 (2) 3273-2310 Fax +82 (2) 3273-2352
Production Reagent Production
NIHON KOHDEN FIRENZE S.r.l. Via Torta 72/74 I-50019 Sesto Fiorentino Firenze, Italy Phone +39 055 3045 1 Fax +39 055 308548
The model and serial number of your instrument are identified on the rear or bottom of the unit. Write the model and serial number in the spaces provided below. Whenever you call your representative concerning this instrument, mention these two pieces of information for quick and accurate service. Model
Serial number
Your Representative
PRINTED IN JAPAN