Loading documents preview...
ESSAR PROJECTS (INDIA) LTD ENGINEERS INDIA LIMITED
BPCL KR PROJECT
KC Cottrell Inc.
Name of the Vendor
CONTROL LOGIC DIAGRAM
Document Title Vendor Document No.
9276-K-IF-INS651-00001
Vendor Rev
A04
PO No. PR No. EIL Bid Document No.
SM/A307-IF-PM-TN-7002/1018
FOA No.
10/J22/882/FOA-329E/AJ/13
Equipment Tag Nos. Base Descipline PROJECT DOCUMENT NUMBER
9276-K-IF-INS651-00001
A04
Document Number
A04 A03 A02 A01
3-3-2015 14-1-2015 30-12-2014 18-3-2014
Rev
Date
Revision
ISSUED FOR APPROVAL ISSUED FOR APPROVAL ISSUED FOR APPROVAL ISSUED FOR APPROVAL Purpose of Issue
J.H. Han J.H. Han J.H. Han J.H. Han
S.H. Bang S.H. Bang S.H. Bang S.H. Bang
H.W. Kim H.W. Kim H.W. Kim H.W. Kim
Prepared by
Checked by
Approved by
ENGINEERING REVIEW Comments
Document Status Code EIL
ESSAR 1 - No Comments 2 - Proceed with Manufacture/Fabrication as per Commented Documents. Revised Documents Required. 3 - Document does not conform to Basic Requirement as Marked. Resubmit for Review. Manufacturing can not start. I-
Reviewed & Retained for Information.
V - VOID Reviewed by : Name of the Dept.
By vishal shinde at 3:38 pm, Jun 29, 2015 Sign & Name of the 03/07/2015 14:08:29 Engineer RAJIV KONWAR (A816)
Date D D M M Y Y 9276-VEN-005-R2
Project : BPCL Kochi Refinery FCCU ESP Supplier : KCCI Equipment Package : ESP
27-2-2015
SUPPLIER'S DOCUMENT REPLY SHEET Document Title
CONTROL LOGIC DIAGRAM FOR ESP
Document No.
9276-K-IF-INS682-00001
NO. Rev
1
Comments
THIS COMMENT IS GIVEN ONLY FOR AUTO MODE AND A03 START COMMAND. THIS IS APPLICABLE FOR ALL THE SIGNALS OF THE ENTIRE LOGIC DIAGRAM.
Reply This sheet (sheet No.4) only was shown a typical function to MS type. MS(Motor Starter means a kind of drive function) for simply and other sheets was revised and your comments applied.
1. TAG NO AUTO MODE SHALL BE MENTIONED HERE. THIS IS REQUIRED TO IDENTIFY THE TAG IN PLC AND IN DCS VIA SERIAL COMMUNICATION. 2. IS THIS AUTO MODE - NORMALLY OPEN OR CLOSE? 3. IS IT A AI, DI OR DO SIGNAL? CONTROL LOGIC DIAGRAM FOR ESP
9276-K-IF-INS682-00001
2
A03 4. IS IT A DI SIGNAL OR A DO SIGNAL?
5. ELEMENT TYPE - IS IT VALVE OR PLC OR MCC OR PANEL? 6. WHAT IS STARTING BY THIS START COMMAND? 7. MENTION HERE THE TAG NO OF THE START COMMAND.
03/07/2015 14:08:29 RAJIV KONWAR (A816)
1 of 3
Revised and it applied the defining of DI/DO, section of LOC, etc. Alao tag. No of all auto and manual mode do not existing because only it's function to select on HMI LCD by operator. And Pxxx means sheet number. (ex. P019 is drawing sheet number is 019)
Remarks
Project : BPCL Kochi Refinery FCCU ESP Supplier : KCCI Equipment Package : ESP
27-2-2015
SUPPLIER'S DOCUMENT REPLY SHEET Document Title
Document No.
NO. Rev
Comments
Reply
1. logic diagram is for interlock I-1169 2. typical tag numbers are shown - similarly tag nos for all the tags to be assigned.All these tag nos shall be covered in IO List, P & ID and Serial modbus mapping list. 3. For interlock no I-1169 on low level of PT and low low level of PT-1151 CONTROL LOGIC DIAGRAM FOR ESP
PAL-1151 is act then Run - stand-by Blower (IF-XR-1170B) 9276-K-IF-INS682-00001
3
A03
PAL-1151 is reset then Run - stand-by Blower continue and Stopped main blower (IF-XT-1170A)
Revised and PALL-1151 case is only function alarm and monitoring.
PALL-1151 is act Maintenance the filter of suction and line duct, blower status etc. ; malfunction This logic shall be implimented here which is not clear from the diagram. please rectify the same. 4. Symbol shall be shown as per P & ID
CONTROL LOGIC DIAGRAM FOR ESP
9276-K-IF-INS682-00001
4
A03
we understand that this logic if for interlock I-1175. update the same according to typical comments.
Revised and it applied.
CONTROL LOGIC DIAGRAM FOR ESP
9276-K-IF-INS682-00001
5
A03 interlock no i-1157. update the logic as per typical comments.
Revised and it applied.
CONTROL LOGIC DIAGRAM FOR 9276-K-IF-INS682-00001 ESP 03/07/2015 14:08:29
1
A02 Tag no shall be mentioned
Revised and it applied the field instrument tag. Name.
RAJIV KONWAR (A816)
2 of 3
Remarks
Project : BPCL Kochi Refinery FCCU ESP Supplier : KCCI Equipment Package : ESP
27-2-2015
SUPPLIER'S DOCUMENT REPLY SHEET Document Title
Document No.
CONTROL LOGIC DIAGRAM FOR ESP
9276-K-IF-INS682-00001
NO. Rev
2
Comments
A02 Provide the details
Reply
Revised and it applied the location & contact condition.
Added and Revised interlock to Rectifier transformer. 1. Selected Mode 1) Normal mode ; Existing supplied operation method CONTROL LOGIC DIAGRAM FOR ESP
9276-K-IF-INS682-00001
1
2) Interlock mode ; Addition tripping interlock for TR
A01
2. Action 1) Select interlock mode by operator at SRR#5 2) If any 1(one) TR fault (failure) 3) Other 2(Two) TR’s Trips by PLC - contactor of each TR panel tripped by programmed logic.
03/07/2015 14:08:29 RAJIV KONWAR (A816)
3 of 3
Remarks
03/07/2015 14:08:29 RAJIV KONWAR (A816)
03/07/2015 14:08:29 RAJIV KONWAR (A816)
03/07/2015 14:08:29 RAJIV KONWAR (A816)
03/07/2015 14:08:29 RAJIV KONWAR (A816)
03/07/2015 14:08:29 RAJIV KONWAR (A816)
03/07/2015 14:08:29 RAJIV KONWAR (A816)
03/07/2015 14:08:29 RAJIV KONWAR (A816)
03/07/2015 14:08:29 RAJIV KONWAR (A816)
03/07/2015 14:08:29 RAJIV KONWAR (A816)
03/07/2015 14:08:29 RAJIV KONWAR (A816)
03/07/2015 14:08:29 RAJIV KONWAR (A816)
03/07/2015 14:08:29 RAJIV KONWAR (A816)
03/07/2015 14:08:29 RAJIV KONWAR (A816)
03/07/2015 14:08:29 RAJIV KONWAR (A816)
03/07/2015 14:08:29 RAJIV KONWAR (A816)
03/07/2015 14:08:29 RAJIV KONWAR (A816)
03/07/2015 14:08:29 RAJIV KONWAR (A816)
03/07/2015 14:08:29 RAJIV KONWAR (A816)
03/07/2015 14:08:29 RAJIV KONWAR (A816)
03/07/2015 14:08:29 RAJIV KONWAR (A816)
03/07/2015 14:08:29 RAJIV KONWAR (A816)
03/07/2015 14:08:29 RAJIV KONWAR (A816)
03/07/2015 14:08:29 RAJIV KONWAR (A816)
03/07/2015 14:08:29 RAJIV KONWAR (A816)
03/07/2015 14:08:29 RAJIV KONWAR (A816)
03/07/2015 14:08:29 RAJIV KONWAR (A816)
03/07/2015 14:08:29 RAJIV KONWAR (A816)
03/07/2015 14:08:29 RAJIV KONWAR (A816)
03/07/2015 14:08:29 RAJIV KONWAR (A816)
03/07/2015 14:08:29 RAJIV KONWAR (A816)
03/07/2015 14:08:29 RAJIV KONWAR (A816)
03/07/2015 14:08:29 RAJIV KONWAR (A816)
03/07/2015 14:08:29 RAJIV KONWAR (A816)
03/07/2015 14:08:29 RAJIV KONWAR (A816)
03/07/2015 14:08:29 RAJIV KONWAR (A816)
03/07/2015 14:08:29 RAJIV KONWAR (A816)
03/07/2015 14:08:29 RAJIV KONWAR (A816)
03/07/2015 14:08:29 RAJIV KONWAR (A816)
03/07/2015 14:08:29 RAJIV KONWAR (A816)
03/07/2015 14:08:29 RAJIV KONWAR (A816)
03/07/2015 14:08:29 RAJIV KONWAR (A816)
03/07/2015 14:08:29 RAJIV KONWAR (A816)
03/07/2015 14:08:29 RAJIV KONWAR (A816)
03/07/2015 14:08:29 RAJIV KONWAR (A816)
03/07/2015 14:08:29 RAJIV KONWAR (A816)
03/07/2015 14:08:29 RAJIV KONWAR (A816)
03/07/2015 14:08:29 RAJIV KONWAR (A816)
03/07/2015 14:08:29 RAJIV KONWAR (A816)
03/07/2015 14:08:29 RAJIV KONWAR (A816)
03/07/2015 14:08:29 RAJIV KONWAR (A816)
03/07/2015 14:08:29 RAJIV KONWAR (A816)
03/07/2015 14:08:29 RAJIV KONWAR (A816)
03/07/2015 14:08:29 RAJIV KONWAR (A816)
03/07/2015 14:08:29 RAJIV KONWAR (A816)
03/07/2015 14:08:29 RAJIV KONWAR (A816)
03/07/2015 14:08:29 RAJIV KONWAR (A816)
03/07/2015 14:08:29 RAJIV KONWAR (A816)
03/07/2015 14:08:29 RAJIV KONWAR (A816)
03/07/2015 14:08:29 RAJIV KONWAR (A816)
03/07/2015 14:08:29 RAJIV KONWAR (A816)
03/07/2015 14:08:29 RAJIV KONWAR (A816)
03/07/2015 14:08:29 RAJIV KONWAR (A816)
03/07/2015 14:08:29 RAJIV KONWAR (A816)
03/07/2015 14:08:29 RAJIV KONWAR (A816)
03/07/2015 14:08:29 RAJIV KONWAR (A816)
03/07/2015 14:08:29 RAJIV KONWAR (A816)
03/07/2015 14:08:29 RAJIV KONWAR (A816)
03/07/2015 14:08:29 RAJIV KONWAR (A816)
03/07/2015 14:08:29 RAJIV KONWAR (A816)
03/07/2015 14:08:29 RAJIV KONWAR (A816)
03/07/2015 14:08:29 RAJIV KONWAR (A816)
03/07/2015 14:08:29 RAJIV KONWAR (A816)
03/07/2015 14:08:29 RAJIV KONWAR (A816)
03/07/2015 14:08:29 RAJIV KONWAR (A816)
03/07/2015 14:08:29 RAJIV KONWAR (A816)
03/07/2015 14:08:29 RAJIV KONWAR (A816)
03/07/2015 14:08:29 RAJIV KONWAR (A816)
03/07/2015 14:08:29 RAJIV KONWAR (A816)
03/07/2015 14:08:29 RAJIV KONWAR (A816)
03/07/2015 14:08:29 RAJIV KONWAR (A816)
03/07/2015 14:08:29 RAJIV KONWAR (A816)
03/07/2015 14:08:29 RAJIV KONWAR (A816)
03/07/2015 14:08:29 RAJIV KONWAR (A816)
03/07/2015 14:08:29 RAJIV KONWAR (A816)
03/07/2015 14:08:29 RAJIV KONWAR (A816)
03/07/2015 14:08:29 RAJIV KONWAR (A816)
03/07/2015 14:08:29 RAJIV KONWAR (A816)
03/07/2015 14:08:29 RAJIV KONWAR (A816)
03/07/2015 14:08:29 RAJIV KONWAR (A816)
03/07/2015 14:08:29 RAJIV KONWAR (A816)
03/07/2015 14:08:29 RAJIV KONWAR (A816)
03/07/2015 14:08:29 RAJIV KONWAR (A816)
03/07/2015 14:08:29 RAJIV KONWAR (A816)
03/07/2015 14:08:29 RAJIV KONWAR (A816)